Professional Documents
Culture Documents
Juicer OWNER Maual Revised
Juicer OWNER Maual Revised
Juice press machine was primarily designed for Gerson patients; Gerson Institutes guidelines should be followed for juice recipes and food preparation. Warranty information. The juice press factory hydraulic presser is warranted by the Juice press factory only to the original consumer or other person for whom the original consumer purchased it as a gift, to be free from defects in material or workmanship under normal use for a period of one (1) year from the date of its original consumer purchase (date of purchase). If there should be a defect covered by this warranty within the warranty period, Juice press factory will at its election either repair or replace the presser or defective part, free of charge, provided it is properly packaged and delivered to Juice press factory. Within the Continental United States only, the freight will be paid by Juice press factory for up to one year from the date of purchase, Method of freight will be at the discretion of Juice press factory. This warranty does not cover loss or damage due to abuse, mishandling, alteration, accident, failure to follow operating instructions, or damage caused by parts or service not authorized by Juice press factory. Juice press factory will not be liable for commercial consequential or incidental damages. Since some states do not allow this limitation, it may not apply to you. Any part damaged by a cause not within the coverage of this warranty, may be purchased from Juice press factory at the current list price plus freight. In case of damage during shipment of your new juice presser, do NOT send the juicer back to Juice press factory. Immediately report such damage to the delivering carrier and have the carrier fill out an inspection report. This warranty provides specific legal rights and you may also have other rights which vary from state to state.
4; Place folded cloth in the center of the lower tray. Make sure drain port is not blocked. -Place lower tray on the top of the lower press plate (on top of the jack). Note: the clear vinyl extension tube attached to the lower stainless tray can be turned in any direction to channel juice into a container or cup/ glass. Turn the tube inward if the cup/glass is placed front of the presser. turn the tube fully to the left if a cup is placed on the left side of the press.
-Use the flattened end of supplied blue lever to close hydraulic jacks release valve (located at the bottom of jack) by turning the valve clockwise (hand tighten only). -Place round end of the blue lever into the actuating arm, start operating hydraulic jack by moving the lever (pumping) in up-down motion several times. Keep hand and fingers out of the tray. -SUPPORT top of the press frame with one hand to prevent it from tipping. -Once upper and lower trays are fully compressed allow it to stand compressed for a minute, this will allow all the juice to be squeezed out. After leaving the pulp compressed for a minute, you should be able to push the handle one more time. It is ok to push hard on the lever. -After the juice stops draining, slowly open the release valve (located at the bottom of the jack) counter clockwise (no more than 1 turn) - For best result: the already compressed pulp could be re-folded to smaller size and pressed again. The smaller the folded pulp/cloth the more efficient the pressing will be. Note: Juice cloths are slightly oversized for average use, cloth can be trimmed to size to accommodate juicing loads. Start out with a smaller load, until you are familiar with the juicers operation. Please call us if you need additional cloths, also replacement cloths are also available in most fabric stores: Recommended juice cloth: We recommend using cloths that are NOT treated with chemicals and close to being natural as possible and should be made of 100% cotton. Fabric stores carry 100 % cotton cloth called: drill. This is a medium density, untreated, unbleached fabric.