Professional Documents
Culture Documents
Huawei 3G Introduction
Huawei 3G Introduction
www.huawei.com
Copyright
Part1 3G Overview Part2 RNC Hardware Introduction Part3 NodeB Hardware Introduction Part4 NodeB Hardware Installation Introduction
Copyright
Page1
Part1 3G Overview Part2 RNC Hardware Introduction Part3 NodeB Hardware Introduction Part4 NodeB Hardware Installation Introduction
Copyright
Page2
Route to 3G
l l l l
1G: Analog 2G : 1st digital mobile telephony 2.5G: transition from 2G to 3G 3G standard: IMT 2000
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved. Page3
3G Advantages
l l l l
Greater subscriber capacity Fast packet-based data services like e-mail, short message service (SMS), and Internet access at broadband speeds. Most carriers also expect consumers to want:
p p p p
location services interactive gaming streaming video home monitoring and control
Copyright
Page4
3G Capabilities
l
384 kbps for motion up to 120 km/hour 144 kbps for high speed mobility (> 120 km/hour) 2 mbps for stationary devices
Frequencies
p p
Copyright
Page5
UMTS / WCDMA
l l
WCDMA: Wideband Direct Sequence Code Division Multiple Access The WCDMA system uses the following frequency spectrum - Uplink 1920 MHz ~ 1980 MHz - Downlink 2110 MHz ~ 2170 MHz Channel Bandwidth: 5MHz Chip rate: 3.84 Mcps
l l
Copyright
Page6
UTRAN
Iub Node B
Uu
UE
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved. Page7
Part1 3G Overview Part2 RNC Hardware Introduction Part3 NodeB Hardware Introduction Part4 NodeB Hardware Installation Introduction
Copyright
Page8
UTRAN
Iu
CN
Iu-CS
RNC
Iub
CS NodeB
Iu b
Iu-PS
Iur
NodeB PS Iu-BC Iub
NodeB
RNC
CBC
Copyright
Page9
RNC Functions
l
System information broadcasting Handover Cell resource allocation Radio resource management
Copyright
Page10
Capacity
l l l l
Up to 51,000 equivalent voice channels Up to 3,264 Mbit/s PS service processing Up to 1,700 NodeBs and 5,100 Cells Single-Subrack solution:
p
6,000
Copyright
Page11
BSC6810 Cabinets
l
RSR: RNC Switching Rack RBR: RNC Business Rack RSS: RNC Switching Subrack RBS: RNC Business Subrack
RBS RBS RBS RBS
RSS
RBS
RSR
RBR
Full Configuration
Copyright
Page12
Boards in RSS
14 15 16 17 18 19 20 21 22 23 24 25 26 27
Rear board
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
O M U a
O M U a
R I N T
R I N T
R I N T
R I N T
Backplane
Backplane
C S U a
01
C S Front board U a
00
S P U a
02
S P U a
03
S P U a
04
S S P C U U a a
05 06
S C U a
07
D P U b
08
D P U b
D P U b
D P U b
11
G C U a
12
G C U a
13
09 10
Copyright
Page13
Boards in RBS
14 15 16 17 18 19 20 21 22 23 24 25 26 27
Rear board
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
Backplane
Backplane
S P U a
00
Front board
S P U a
01
S P U a
02
S P U a
03
S P U a
04
S S P C U U a a
05 06
S C U a
07
D P U b
08
D P U b
D P U b
D P U b
11
D P U b
12
D P U b
13
09 10
Copyright
Page14
Transport Subsystem
l
RINT in RSS
14 15 16 17 18 19 20 21 22 23 24 25 26 27
Rear board
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
O M U a
O M U a
R I N T
R I N T
R I N T
R I N T
Backplane
Backplane
C S U a
01
C S Front board U a
00
S P U a
02
S P U a
03
S P U a
04
S S P C U U a a
05 06
S C U a
07
D P U b
08
D P U b
D P U b
D P U b
11
G G C C U U a a
12 13
09 10
Copyright
Page15
Transport Subsystem
l
RINT in RBS
14 15 16 17 18 19 20 21 22 23 24 25 26 27
Rear board
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
R I N T
Backplane
Backplane
S P U a
00
Front board
S P U a
01
S P U a
02
S P U a
03
S P U a
04
S S P C U U a a
05 06
S C U a
07
D P U b
08
D P U b
D P U b
D P U b
11
D P U b
12
D P U b
13
09 10
Copyright
Page16
Transport Subsystem
l
Copyright
Page17
Part1 3G Overview Part2 RNC Hardware Introduction Part3 NodeB Hardware Introduction Part4 NodeB Hardware Installation Introduction
Copyright
Page18
DBS3900 Overview
l l
DBS3900 is a distributed NodeB of forth generation NodeB. DBS3900 system consists of:
p
BBU3900
Antenna
TMA RF jumper
Feeder
Grounding cable
Power cable
BBU3900
RF jumper
Copyright
Page19
High capacity;
p
BBU3900 supports 24 cells, with 1,536 UL CEs and 1,536 DL CEs. One RRU3804 supports the 4-carrier configuration. When the NodeB expands from 1x1 to 1x4 or from 3x1 to 3x4, no extra RRU is required. Characteristics of the DBS3900
When using the 1.25 G optical module, cascading levels When using the 2.5 G optical module, cascading levels 8
Copyright
Page20
Supports ATM !IP and ATM/IP dual stack networking; Supports multiple clock and synchronization modes;
HSDPA allows the traffic at up to 14.4 Mbps for a single cell The peak uplink data rate of an HSUPA subscriber is up to 5.76 Mbit/s.
Copyright
Page21
Copyright
Page22
Full configuration
Baseband unit
Typical configuration
BBU3900 Module
l l
The optional boards are the UELP, UFLP, UTRP, and UEIU.
2006 Huawei Technologies Co., Ltd. All rights reserved. Page23
Copyright
Boar d
WMPT UTRP WBBP UELP UFLP
Slot 0
Slot 1
Slot 2
Slot 3
Slot 4
Slot 5
Slot 6
available
Slot 7
available
available available
available available
available available
available available
Copyright
Section2 RRU Hardware Section3 Section4 Section5 DBS3900 Cables Antenna and Feeder Subsystem Networking and Configuration
Copyright
Page25
&NOTES:
The RRU3801E appearance (Panel and Ports) is the same with the RRU3804;
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved. Page26
Copyright
Section2 RRU Hardware Section3 Section4 Section5 DBS3900 Cables Antenna and Feeder Subsystem Networking and Configuration
Copyright
Page28
Copyright
Page29
BBU3900
Copyright
Page30
Optical cable
BBU3900
Power cable
Copyright
Page31
Section2 RRU Hardware Section3 Section4 Section5 DBS3900 Cables Antenna and Feeder Subsystem Networking and Configuration
Copyright
Page32
(1) Directional antenna (4) Outdoor cable rack (7) Outdoor grounding bar
(2) Pole
(13) Feeder
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved. Page33
Copyright
Page34
Copyright
Page35
Section2 RRU Hardware Section3 Section4 Section5 DBS3900 Cables Antenna and Feeder Subsystem Networking and Configuration
Copyright
Page36
BBU Networking
l
BBUs and RNC can form multiple networking modes such as star, chain,
BBU
BBU
BBU
Copyright
Page37
RRU Networking
l
BBUs and RRUs can form multiple networking modes such as star, chain, tree, ring, and hybrid For both chain and tree networking modes: p When using the 1.25 G optical module, cascading levels 4 p When using the 2.5 G optical module, cascading levels 8
Copyright
Page38
Typical Configuration!1
RRU
BBU3900
Copyright
Page39
Typical Configuration!2
Applied to long stretched areas
RRU
BBU3900
Copyright
Page40
Typical Configuration!3
1/3
RRU
cities
RRU
RRU
BBU3900
Copyright
Page41
Part1 3G Overview Part2 RNC Hardware Introduction Part3 NodeB Hardware Introduction Part4 NodeB Hardware Installation Introduction
Copyright
Page42
Copyright
Page43
Copyright
Page44
Installation Scenarios
l Installing the BBU in the APM30 l Installing the BBU in the BTS3012 Cabinet
Copyright
Page45
The APM30 is a supporting solution to the outdoor applications of Huawei wireless products
APM30
The APM30 provides 48 V DC power and power backup for the distributed base stations and mini base stations, and provides space for the user equipment. It also performs functions such as battery management and monitoring, and lightning protection.
The APM30 can work with the distributed base stations and the separated base stations
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved.
Scenario 1
with built-in batteries
Scenario 2
with battery cabinet
Copyright
Page47
Copyright
Page48
Copyright
Page49
Cable Connections
Copyright
Page50
Copyright
Page52
+
Three modules installation
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved. Page53
Installation Modes
Copyright
Page54
Installation Modes
Copyright
Page55
Copyright
Page56