Professional Documents
Culture Documents
5 2.2
(Part 2:). 2. MDB Ground Floor, Mezzanine Floor or Ba e!ent Floor 2.1.Case Related Comments:
2.2. 6itc&en or bat&rooms are not permitted abo-e electrical room. 2.3. ,lectrical room s&all be wit& ade($ate si%e. 2.4. #ain brea4er wit& ,/ 3''7"''mA re($ired. 2.". #D8 to be eart&ed at 2 points. 2.). Any water pipe or AC d$ct passing t&ro$g& electrical room is not acceptable. 2.+. 8$sbar Riser rating m$st be same rating as brea4er. 2... 9f transformer s$pply0 main brea4er is to be AC8 0"'6A. 2.1. /ocation and si%e of main electrical room to be mar4ed. 2.1'. Cable ro$te to be t&ro$g& common area. 2.11. 8rea4er for generator and b$s co$pler to be 4 poles. 2.12. AC8 to be wit& drawable type. 2.13. ADDC s$pply to be c&ec4ed /5 or :5. 2.14. Total connected load to be c&ec4ed wit& /DN. 2.1". Cable entry to be pro-ided from section concerned 2.1). Cable ro$tes for t&e o$tgoing cables to be s&own 2.1+. Cap.8an4 to be s&own 2.1.. 8$s bar rating of #D80 not mentioned 2.11. Dimension of #D8 to accommodate in ,;R as per new reg$lation to be mar4ed. 2.2'. Clear common access to reac& in ,;R re($ired. 2.21. Ro$te of t&e b$s bar to be c&ec4ed wit& ot&er ser-ices 2.22. 9 rating of b$s bar to be mentioned 2.23. N$mber of tap7off points on eac& b$s bar riser not mar4ed 2.24. Rating of tap7off points to matc& wit& load and cable si%e. 2.2". Distrib$tion arrangement of load from b$s riser to be s&own. 2.2). /engt& and 5oltage drop of b$s riser to be gi-en 2.2+. Correction to be made in single line diagram 2.2.. 6w& meters to be mar4ed on */D 2.21. All #D8s abo-e 3''A rating s&all be wit& 3Ameters0 one -oltmeter and p&ase indicating lamps0 2.3'. Ade($ate rated brea4er re($ired on standby generator set 2.31. Ro$te of )3'mm cable from transformer to #D8 to be appro-ed by concerned section 2.32. /ocation of #D8 in 8asement or #e%%anine floor to be appro-ed by constr$ction section. 2.33. All tapoff brea4ers s&all be l$g7in7type and c$rrent limiting type. 2.34. Cables or b$s bar risers are not permitted to pass t&ro$g& generator room. 2.3". All cables r$nning $ndergro$nd m$st be installed in d$cts wit& ,CC in separate d$ct. 2.3). Distance and -oltage drop calc$lations m$st be pro-ided for all cables <in -olts= wit&in limit. 2.3+. Circ$it brea4er rating s&all matc& wit& load and cable si%e 2.3.. Calc$lation of load s&all be corrected. 5 2.2
2.31. 9n case of feeding different bloc4s from one /5 panel eac& bloc4 m$st &a-e its own #D8 and ,lectrical room. 2.4'. 8$s co$pler <4 = s&all be pro-ided between /5 panels in t&e same electrical room. 2.41. #etering arrangement to be rec&ec4ed 2.42. T&e ratings of 6>: meters to be rec&ec4ed
5 2.2
5 2.2
(Part ':) '. FDB# (n ide t)e )op , offi&e or flat 4.1.Case Related Comments.
4.2. Rating of #C8As0 RCD and wire si%e to be rec&ec4ed. 4.3. #et&od of load calc$lation to be as per R*8 re($irement. 4.4. ac4age $nits wit& eart& lea4age protection re($ired. 4.". A-ailability of spare brea4ers re($ired. 4.). N$mber of poles of different protection de-ices to be s&own 4.+. *&ow load on eac& section.<1''mA and 3'mA=. 4... N$mber of ways of single p&ase cons$mer $nit not to e?ceed 12. 4.1. All circ$its in t&e toilet and bat&room to be fed from same p&ase 3 3' mA RCD 4.1'. @le?ible Cables are not allowed for internal wiring. 4.11. ,CC Cable s&o$ld be pro-ided. 4.12. @D8;*#D8 location0 s&o$ld be in an open area easy to reac&0 not $nder stair case0 not direct to t&e s$n lig&t0 and not on 4itc&en or toilet wall 4.13. 9f feeding from #D8 s$pplied from transformer0 m$st be #CC8 type wit& min 2"6A.<9sc= 4.14. Two *plit b$s bar 1 section 1''mA RCD 3 2nd section 3'm A RCD re($ired. 4.1". 8rea4er rating for lig&ting )71"A for radial circ$it 2'A0 for rings soc4ets 3'A and for water &eater window AC and ot&er power points 2'A0 coo4er 3'A0 to be $sed. 4.1). *i%e of main feeding cable not s&own0 4.1+. N$mber of ways m$st not e?ceed 14 ways T . 4.1.. 3 p&ase load to be balanced and same p&ase to be $sed in one place 4.11. N$mber of connected points of eac& circ$it to be matc&ing wit& brea4er rating and wire si%e. 4.2'. *ign 8oard point to be s&own for t&e s&ops. 4.21. Di-ersified load to be s&own for eac& circ$it in t&e @D87 load sc&ed$le. 4.22. Bnder floor tr$n4ing s&all be p$rpose made metallic tr$n4ing. 4.23. >ater :eater is not s&own in t&e flats. Clarification re($ired. 4.24. #inim$m n$mber of soc4ets and connection points m$st be as per R*8 reg$lations 4.2". /ayo$ts m$st matc& wit& load sc&ed$les 4.2). 1"A soc4ets s&o$ld not be installed in domestic type of load 4.2+. /oad sc&ed$les to be corrected 4.2.. All mac&ines to be protected wit& eart& lea4age circ$it brea4er 4.21. All mac&ines to be connected to ring eart&
5 2.2
5 2.2