Gautam Buddha University Submitted by, Vivek Kumar Gupta Roll no 10ime059 Mtech 2 nd sem Design Submitted to, Mr. Anurag Dixit Dept. of Mechanical Engineering School Of Engineering
2. Material of the beam: The material of the beam is taken as structural steel. Which has following properties
3. Ansys analysis steps:
Step1. Start the workbench module of ansys. Step2. Select the static structural 100mm 100mm 4mm 1000mm Force Fy=100N
1. Drawing of beam x y
Step3. Select Engineering data and double click on it. A window will open from where choose library icon.
This library will show different materials in it. From here choose structral steel.
Step 4: return to project: go to geometry tab which will open Ansys modeller. Form here design the 3d model of cantilever beam given in question.
Step 5: return back to the project and choose the model option form work bench. From the modeller choose mesh from the project tree.
Meshing: Meshing option will provide different option given below in the box naming Details of mesh. From this option set sizing of mesh as fine. Then click generate to generate the mesh. This will generate following meshing.
Step6 Supports : click the supports command from the menu bar of ansys model module.
And provide fixed support at any one of the cross section of the beam.
Step 7 loading: Select the loads button from menu bar Apply load of -100 N at the other end of cross section of the beam in y direction ,.
Step 8 Solution: select the solution link from the tree diagram and select whatever solution you want , in our case it is the deformation, equivalent stress and strain ( von mises) .
Finally click on solve option given on top at the title bar and let the program solve the given condition. Finally the results will be generated.