The document describes a bike lane delineator that is made of recycled rubber, is highly visible and reflective, and is durable and long-lasting. It is 29.5 feet long, 4.75 inches wide, and 4 inches thick. It requires 3 screws for installation. The delineator has a sloped side for cyclists and a perpendicular side to prevent vehicles from entering the bike lane. It is installed with plastic anchors and screws using the instructions provided.
The document describes a bike lane delineator that is made of recycled rubber, is highly visible and reflective, and is durable and long-lasting. It is 29.5 feet long, 4.75 inches wide, and 4 inches thick. It requires 3 screws for installation. The delineator has a sloped side for cyclists and a perpendicular side to prevent vehicles from entering the bike lane. It is installed with plastic anchors and screws using the instructions provided.
The document describes a bike lane delineator that is made of recycled rubber, is highly visible and reflective, and is durable and long-lasting. It is 29.5 feet long, 4.75 inches wide, and 4 inches thick. It requires 3 screws for installation. The delineator has a sloped side for cyclists and a perpendicular side to prevent vehicles from entering the bike lane. It is installed with plastic anchors and screws using the instructions provided.
Needed 29.5(L) x 4.75(W) x 4 (Thickness) 10 lbs. 3 MADE FROM 100% RECYCLED RUBBER LONG LASTING & COST-EFFICIENT REFLECTIVE TAPE IN WHITE HIGHLY VISIBLE AT NIGHT QUICK AND SIMPLE-TO-INSTALL SUITABLE FOR PERMANENT OR TEMPORARY INSTALLATION WILL NOT CRACK, CHIP, ROT, OR FADE A smart, safe solution that effectively delineates vehicle traffic from cyclists. RECOMMENDED LOCATIONS: Municipal roadways HOAs / private communities University campuses 800-641-4143 www.gnrtech.com N E W ! Distributed by: CycleLane Bike Lane Side Vehicle Side Cycle Lanes unique profle is sloped on one side to allow cyclists to bump up to the product safely; the other side is perpendicular to the roadway preventing vehicles from entering the bicycle lane. The Cycle Lane delineator is installed with plastic anchors (shields) and screws. Installation Instructions RECOMMENDED LOCATIONS: Municipal roadways HOAs / private communities University campuses 800-641-4143 www.gnrtech.com CycleLane N E W ! Distributed by: STEP 1: Determine where the Cycle Lane should be positioned and sweep the installation surface to ensure it is clean of debris / dust. Using a chalk line, mark the location for the bike lane delineator parallel to the curb STEP 2: Position the units following the chalk line. Note: Make sure the sloped side of the product is facing the bike lane and the steep side of the product is facing vehicle trafc. (see image on left) STEP 3: Drill 9/16 (14mm) diameter holes into the surface through the existing holes in the product. The holes should be 3.5 - 4 (90-100 mm) deep to accommodate the 3 long plastic shields. STEP 4: Remove the product and clean the drilled holes of any dust / debris. Once clean, insert the plastic shields. OtHer pArking lOt sAfety & dAMAge preventiOn sOlUtiOns Park It Car Stop Home Park It Easy Rider Speed Bump Safety Rider Mini Hump Corner & Wall Guards Bollard Covers STEP 5: Re-position the product over the holes, insert bolts and steel washers and tighten. Do not over-tighten the bolts. PROPER INSTALLATION: Vehicle Trafc Cyclist Trafc