This document provides instructions for binding a 2.4GHz transmitter to a receiver. It outlines an 8-step process: 1) connect a bind plug to the receiver, 2) power on the receiver, 3) power on the transmitter while holding the bind switch up and ensuring the throttle and trims are centered, 4) release the bind switch, 5) remove the bind plug, 6) confirm the receiver LED is illuminated and the transmitter now has full control over all surfaces and controls. The factory will initially bind the transmitter to the receiver but this process must be followed if they become unbound or an additional receiver is purchased.
This document provides instructions for binding a 2.4GHz transmitter to a receiver. It outlines an 8-step process: 1) connect a bind plug to the receiver, 2) power on the receiver, 3) power on the transmitter while holding the bind switch up and ensuring the throttle and trims are centered, 4) release the bind switch, 5) remove the bind plug, 6) confirm the receiver LED is illuminated and the transmitter now has full control over all surfaces and controls. The factory will initially bind the transmitter to the receiver but this process must be followed if they become unbound or an additional receiver is purchased.
This document provides instructions for binding a 2.4GHz transmitter to a receiver. It outlines an 8-step process: 1) connect a bind plug to the receiver, 2) power on the receiver, 3) power on the transmitter while holding the bind switch up and ensuring the throttle and trims are centered, 4) release the bind switch, 5) remove the bind plug, 6) confirm the receiver LED is illuminated and the transmitter now has full control over all surfaces and controls. The factory will initially bind the transmitter to the receiver but this process must be followed if they become unbound or an additional receiver is purchased.
Reverses direction of channels 1- 4 Switches in lower position Normal direction of channels 1- 4 This 2.4GHZfeatures aunique coding protocol, to usethis Transmitter with a receiver it must be bound to the receiver. Thefactory will bind the transmitter to the receiver but should it become unbound or should you purchasea second receiver then pleasefollow the procedure outlined below. 1. Connect abind plug to the receiver. 2. Switch on the power to the receiver, the green receiver LEDwill now flash. 3. Nowpick upthe Transmitter, before you switch it on pleaseensure that the throttle is inthe lowest position andthat all the trims areinthe middle position. 4. Holding the bind switch inthe up position now switch on the transmitter. 5. Thetransmitter green LEDwill start fla~hing andthe receiver LEDwill havegone off. '::- 6. Releasethe bind switch on the transmitter. 7. Removethe bind plug on the receiver, the GreenLEDwill now illuminate on the receiver andwill now be bound to the transmitter. 8. Finallyconfirm that you havenow havefull contro lover all surfacesand controls Pleasenote it will depend on your model if you havea4or 6channel radio transmitter.