release. Step 7: Repeat Step 5 for the next two layers. NOTE: The petals on each layer (aside from the base layer) should be glued over the gaps in between the petals on the layer under- neath - refer to the top view of the ASSEMBLED WATER LILY FLOWER template). Step 6: Cut another two lots of 8 petals out of a different coloured foam sheet using the PETAL C and D templates. Repeat Step 3 for these petals. Step 5: Glue down the smaller lot of petals (PETAL B) on top of the base layer. Ensure each petal is glued over the gap between the petals below. Step 4: Glue down the flat end of the largest petals (PETAL A) on top of the lily pad, forming the base flower shape. Step 2: Cut out the flower petals for the water lily flower. Use the PETAL A and B templates to cut 8 of each from a foam sheet. Step 1: Using the WATER LILY PAD template provided, trace it onto a foam sheet and cut around the outline. WATER LILY PAD ASSEMBLED WATER LILY FLOWER (TOP VIEW) x1 PETAL A x8 PETAL B x8 PETAL C x8 PETAL D x8