INTRODUCTION Maximum power point tracking is a technique that grid connected inverters, solar battery charges and solar device use to get the maximum possible power from one or more photo voltaic device typically solar panels. The main aim of this project is to obtain the maximum energy with maximum efficiency that which being obtained from the any three renewable energy sources the three renewable sources that which being opted in this project are Wind Solar Heat energy The main application level of this project is to be used and implemented in industries and for homely usage. The beneficial part of this project is that in ordinary set up there needs to be a manual facility for switching into the power source supply and controlling whereas using MPPT it seems to be much automatic mode of making i.e. does not require any manual facility and everything being done automatically. Also the future development part of power and related working of the source of could be controlled from any part of world. In this project 8051 based Microcontroller is used .The analog signals such as voltage,current and temperature are obtained digitally by using SPI Protocol ADC FEATURES Energy sources can be automatically switched Real time monitoring of electrical parameters are possible Usage report can be produced Over charge protection Can be Operated in Standby mode PV cells are being protected from higher temperature The outputs are obtained which are One AC Output (230V,50Hz) Two DC Output (12V,5 V)