Professional Documents
Culture Documents
Transistor Inverter Inverter For Air Conditionor I Gate Drive Power MOS FET Gate Drive
Transistor Inverter Inverter For Air Conditionor I Gate Drive Power MOS FET Gate Drive
TLP250
Transistor Inverter
Inverter For Air Conditionor
I Gate Drive
Power MOS FET Gate Drive
Unit in mm
TOSHIBA
Weight: 0.54 g
1110C4
Schmatic
IF
2+
VF
3IO
(Tr 2)
VO
VO
GND
A 0.1F bypass capcitor must be
connected between pin 8 and 5 (See Note 5).
1 : N.C.
2 : Anode
3 : Cathode
4 : N.C.
5 : GND
6 : VO (Output)
7 : VO
8 : VCC
Truth Table
Input
LED
Tr1
Tr2
On
On
Off
Off
Off
On
2002-09-25
TLP250
Absolute Maximum Ratings (Ta = 25C)
Characteristic
Symbol
Rating
Unit
IF
20
mA
IF / Ta
-0.36
mA / C
IFPT
Reverse voltage
VR
Junction temperature
Tj
125
Forward current
LED
(Note 1)
(Note 2)
IOPH
-1.5
(Note 2)
IOPL
+1.5
(Ta 70C)
Detector
Output voltage
(Ta = 85C)
(Ta 70C)
Supply voltage
35
VO
24
35
VCC
(Ta = 85C)
24
VO / Ta
-0.73
V / C
VCC / Ta
-0.73
V / C
Tj
125
25
kHz
Topr
-20~85
Tstg
-55~125
Tsol
260
BVS
2500
Vrms
Junction temperature
Operating frequency
(Note 3)
(Note 4)
(Note 1)
(Note 2)
Exporenential wavefom
(Note 3)
(Note 4)
Device considerd a two terminal device: Pins 1, 2, 3 and 4 shorted together, and pins 5, 6, 7 and 8 shorted
together.
(Note 5)
A ceramic capacitor(0.1F) should be connected from pin 8 to pin 5 to stabilize the operation of the high
gain linear amplifier. Failure to provide the bypassing may impair the switching proparty. The total lead
length between capacitor and coupler should not exceed 1cm.
Symbol
Min.
Typ.
Max.
Unit
Input current, on
IF(ON)
10
mA
VF(OFF)
0.8
VCC
15
IOPH/IOPL
Topr
-20
25
Supply voltage
Peak output current
Operating temperature
30
20
0.5
70
V
A
85
2002-09-25
TLP250
Electrical Characteristics (Ta = -20~70C, unless otherwise specified)
Symbol
Test
Circuit
VF
IF = 10 mA , Ta = 25C
VF / Ta
IF = 10 mA
IR
VR = 5V, Ta = 25C
Input capacitance
CT
V = 0 , f = 1MHz , Ta = 25C
H level
IOPH
L level
IOPL
H level
VOH
L level
H level
Characteristic
Input forward voltage
Temperature coefficient of
forward voltage
Typ.*
Max.
Unit
1.6
1.8
-2.0
mV / C
10
mA
45
250
pF
IF = 10 mA
V8-6 = 4V
-0.5
-1.5
IF = 0
V6-5 = 2.5V
0.5
11
12.8
VOL
-14.2
-12.5
ICCH
11
7.5
Output current
Output voltage
Supply current
L level
ICCL
VCC = 30V
(*1)
mA
11
1.2
mA
IFHL
0.8
VCC
10
35
1.0
2.0
pF
Output
LH
IFLH
Threshold input
voltage
Output
HL
Capacitance
(input-output)
CS
VS = 0 , f = 1MHz
Ta = 25
Resistance(input-output)
RS
VS = 500V , Ta = 25C
R.H. 60%
Min.
Threshold input
current
Supply voltage
Test Condition
12
110
14
10
2002-09-25
TLP250
Switching Characteristics (Ta = -20~70C , unless otherwise specified)
Characteristic
Propagation
delay time
Symbol
LH
HL
Test
Circuit
Test Condition
tpLH
tpHL
tr
tf
IF = 8mA
VCC1 = +15V, VEE1 = -15V
RL = 200
Min.
Typ.*
Max.
0.15
0.5
0.15
0.5
Unit
CMH
-5000
V / s
CML
5000
V / s
2002-09-25
TLP250
Test Circuit 1 :
0.1F
VCC
A
4
IOPL
V6-5
8
1
VCC1
VCC
0.1F
0.1F
V8-6
IF
IF
RL
V VOH
IOPH
VEE1
Test Circuit 5 : VOL
8
1
VCC1
0.1F
VF
RL
V
VOL
4
VEE1
2002-09-25
TLP250
Test Circuit 6: tpLH, tpHL, tr tf
8
IF
IF
0.1F
tr
tf
VCC1
VOH
VO
RL
VO
GND
VOL
tpLH
100
80%
80%
tpHL
VEE1
0.1F
VCC
B
VO
4
VCM
+
600V
VCM
90%
10%
tf
tr
SW :A(IF=8mA)
CMH
VO
3V
SW :B(IF=0)
26V
CHL
CML(CMH) is the maximum rate of rise (fall) of the common mode voltage that can be sustained with the output
voltage in the low (high) state.
2002-09-25
TLP250
IF VF
Forward current IF
(mA)
50
30
VF / Ta IF
-2.6
Ta = 25 C
100
10
5
3
1
0.5
0.3
0.1
0.05
0.03
0.01
1.0
1.4
1.2
1.8
1.6
Forward voltage
VF
-2.4
-2.2
-2.0
-1.8
-1.6
-1.4
0.1
2.0
0.3 0.5
(V)
Forward current
IF Ta
IF
(mA)
10
30
VCC Ta
40
30
(V)
40
20
10
0
0
20
40
60
30
20
10
0
80
100
20
40
60
80
100
IOPH, IOPL Ta
PW 2.5 s, f 15 KHz
2
0
0
20
40
60
80
100
2002-09-25
TLP250
000707EBC
TOSHIBA is continually working to improve the quality and reliability of its products. Nevertheless, semiconductor
devices in general can malfunction or fail due to their inherent electrical sensitivity and vulnerability to physical
stress. It is the responsibility of the buyer, when utilizing TOSHIBA products, to comply with the standards of
safety in making a safe design for the entire system, and to avoid situations in which a malfunction or failure of
such TOSHIBA products could cause loss of human life, bodily injury or damage to property.
In developing your designs, please ensure that TOSHIBA products are used within specified operating ranges as
set forth in the most recent TOSHIBA products specifications. Also, please keep in mind the precautions and
conditions set forth in the Handling Guide for Semiconductor Devices, or TOSHIBA Semiconductor Reliability
Handbook etc..
The TOSHIBA products listed in this document are intended for usage in general electronics applications
(computer, personal equipment, office equipment, measuring equipment, industrial robotics, domestic appliances,
etc.). These TOSHIBA products are neither intended nor warranted for usage in equipment that requires
extraordinarily high quality and/or reliability or a malfunction or failure of which may cause loss of human life or
bodily injury (Unintended Usage). Unintended Usage include atomic energy control instruments, airplane or
spaceship instruments, transportation instruments, traffic signal instruments, combustion control instruments,
medical instruments, all types of safety devices, etc.. Unintended Usage of TOSHIBA products listed in this
document shall be made at the customers own risk.
Gallium arsenide (GaAs) is a substance used in the products described in this document. GaAs dust and fumes
are toxic. Do not break, cut or pulverize the product, or use chemicals to dissolve them. When disposing of the
products, follow the appropriate regulations. Do not dispose of the products with other industrial waste or with
domestic garbage.
The products described in this document are subject to the foreign exchange and foreign trade laws.
The information contained herein is presented only as a guide for the applications of our products. No
responsibility is assumed by TOSHIBA CORPORATION for any infringements of intellectual property or other
rights of the third parties which may result from its use. No license is granted by implication or otherwise under
any intellectual property or other rights of TOSHIBA CORPORATION or others.
The information contained herein is subject to change without notice.
2002-09-25