Professional Documents
Culture Documents
com
2. Procedures
1) Start the printer in firmware update mode.
(Printer)
- Press Paper, Ink and Power buttons at the same time.
- Contitue pressing them more than 8 seconds.
--> All LEDs light as below.
(PC)
If New hardware detection wizard appears,
Click<Cancel>.
(Printer)
Paper LED is turned off.
(Printer)
While erasing ROM date, LEDs blink by the following order.
(Printer)
While writing ROM date, LEDs blink by the following order.
(Printer)
While verifying ROM date, all LEDs light as below.
(Printer)
When update is completed, all LEDs blink by 5 cycles per second.
<Caution>
If LEDs blink by the following order, FW has not been updated correctly.
Please try again after turning off the printer by pressing Power button.