The document appears to be instructions for a quiz on the design and analysis of flexural members. It provides directions for students to follow, warns that cheating will result in a failing grade, and lays out a problem to solve regarding designing the most practical and economical beam and girder sections for a typical floor that will be used as an office meeting room. Students are asked to design sections for an exterior girder, interior girders, and beams given loading conditions and materials used in the floor's construction.
The document appears to be instructions for a quiz on the design and analysis of flexural members. It provides directions for students to follow, warns that cheating will result in a failing grade, and lays out a problem to solve regarding designing the most practical and economical beam and girder sections for a typical floor that will be used as an office meeting room. Students are asked to design sections for an exterior girder, interior girders, and beams given loading conditions and materials used in the floor's construction.
The document appears to be instructions for a quiz on the design and analysis of flexural members. It provides directions for students to follow, warns that cheating will result in a failing grade, and lays out a problem to solve regarding designing the most practical and economical beam and girder sections for a typical floor that will be used as an office meeting room. Students are asked to design sections for an exterior girder, interior girders, and beams given loading conditions and materials used in the floor's construction.
School of Civil, Environmental and Geological Engineering (CEGE)
CE139 C1 (Special Topics in Structural Engineering) MWF (7:30 9:00) NAME: ___________________________ DATE: ___________________ SIGNATURE: ______________________ DIRECTION: Read the following problems carefully. Please follow the respective instructions for each portion of the test. Round your final answer in two decimal places. Wrong spelling is WRONG. No units (if needed) are considered to be incorrect. ANYONE CAUGHT CHEATING WILL MERIT A GRADE of 5.0 WITHOUT AN EXCUSE.
QUIZ # 2 DESIGN and ANALYSIS of FLEXURAL MEMBERS
PART 1: PROBLEM SOLVING An engineer is planning to design a typical floor. The engineer will use I- sections for the exterior girder, square tubing for the interior girders, tee section for beams. The engineer considers the practicality of connections of two members. The engineer uses 6 mm thick steel plate on the entire panel with wood block (76mm) on 13mm thick mortar and minimum mechanical electrical load of 0.15 kPa. The floor is intended to as an office meeting room. Design the most practical and economical sections for the given loading conditions.
Prepared by Engr. Ivan Dela Llana Marquez CE# 120005