Professional Documents
Culture Documents
01-05 Classmark Update Procedure
01-05 Classmark Update Procedure
Contents
Contents
5 Classmark Update Procedure...................................................................................................5-1
5.1 Classmark Overview .....................................................................................................................................5-2
5.2 Classmark Update Procedure ........................................................................................................................5-2
Issue 02 (2007-06-30)
Figures
Figures
Figure 5-1 Classmark update procedure.............................................................................................................5-2
ii
Issue 02(2007-06-30)
Describes
Issue 02 (2007-06-30)
5-1
BSS
MSC
System Information
Type 3
ECSC
BCCH
SABM
SDCCH
Classmark Change(1)
Complete Layer 3
Inforamtion
Classmark Update(2)
SDCCH
Classmark Request(3)
Classmark Enquiry(4)
main DCCH
Classmark Change(5)
main DCCH
Classmark Update(6)
5-2
Issue 02(2007-06-30)
Step 1 Upon receipt of the Classmark Change message from the MS, the BSS sends a Classmark
Update message. This message contains classmark 2 information element and classmark 3
information element of the MS. The Classmark Update is a bi-directional message.
Step 2 When a Mobility Management (MM) connection is established between the MS and the MSC,
the MSC can initiate a classmark update procedure by sending a Classmark Request message
on the Signaling Connection Control Part (SCCP) to the BSS.
Step 3 Upon receipt of the Classmark Request from the MSC, the BSS either takes no action or takes
the following actions:
z
Step 4 Upon receipt of the Classmark Enquiry message from the BSS, the MS returns a Classmark
Change message to the BSS. The Classmark Change message contains the updated classmark 2
message of the MS. It may also contain the classmark 3 message.
Step 5 Refer to Step 1.
----End
Procedure Explanation
Figure 5-1 is divided into the following three parts by the broken lines:
z
The upper section defines whether the ECSC is supported in System Information Type 3.
The middle section shows the classmark update procedure initiated by the MS when the
ECSC is enabled. :
Issue 02 (2007-06-30)
The lower section shows the classmark update procedure initiated by the MSC.
5-3