Professional Documents
Culture Documents
Name
Date Performed
Procedure
1. Construct a circuit as in Figure 1.
Figure 1
LAB 3
LAB 3
2. Apply DC input signal as indicated in Figure 1. Observe the output voltage, Va and Vb on your
multi-meter. Measure and record the values in Table 1.
3. Increase the input voltage as shown in Table 2; observe the voltage of Va and Vb. Record the
reading in Table 2a and Table 2b respectively.
Data Table
Voltage Measurement
Voltage
Measured Value
Calculated Value
% Error
Va
Vb
TABLE 1
Measured Value
Calculated Value
2
4
6
10
% Error
Vin
Measured Value
Calculated Value
LAB 3
% Error
2
4
6
10
Analysis
Discuss the significance of error in DC measurement.
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________