Professional Documents
Culture Documents
1. Pull the back cover off the tablet to reveal the screws.
2. Remove the 8 screws, release the gray wire from the yellow tape and lift the back plate off.
3. Carefully remove the black tape and disconnect the 3 connections highlighted.
4. Remove the digitizer from the screen, carefully feeding the connector through the slot.
5. Remove the black tape adhesive from the digitizers border.
8. Carefully feed the digitizer connection back through the slot, making sure it isnt pinched, and
secure the digitizer evenly to the screen and clamp together until glue is cured.
9. Reapply the rubber seal.
11. Feed the gray wire back through the hole in the back plate and carefully maneuver the screen
back into the housing.
12. Replace the 8 screws and snap the back cover into place.
13. Connect tablet to power source and check touch screen functionality.