Professional Documents
Culture Documents
Logic To Ladder Diagram
Logic To Ladder Diagram
There are some methods to do PLC programming. The programming methods can be
with Logic Ladder Diagram, mnemonic (statement list), and / or function block diagram.
One of the PLC programming methods that are very commonly used programming using
PLC ladder diagram. The method is practical and easy to understand. The programmer in
charge of writing a program should describe an electronic switch circuit. It can be
designed to perform the conversion of electronic circuits that already exist, and then
replace the switch function according to the functions available to software programmers.
A ladder diagram consists of a downward line on the left side with lines branching to the
right. Existing line on the left side is called the bus bar, whereas the branching lines are
lines of instructions or steps. Instructions are placed along the line of a variety of
conditions linked to the other instructions on the right side. Logic combination of the
conditions stated when and how the existing instructions on the right side are done.
Logic AND
The truth table of logic AND is as follows,
Logic OR
The truth table of logic OR is as follows,
Logic NOT
The truth table of logic NOT is as follows,
Logic NAND
Logic NAND is a development of logic AND, OR and NOT. The truth table is as
follows,
Logic NOR
This logic is also the development of the logic AND, OR and NOT. The truth table is as
follows,
Logic XOR
Similarly, the logic of the previous ones. This logic is also the development of AND, OR
and NOT. This logic is widely used in summing strand (adder). The truth table is as
follows,