Professional Documents
Culture Documents
Question for bottom bottle: How will the rocket distance change according to the amount of water that
is in the bottom bottle?
Hypothesis for bottom bottle: If we decrease the water in the bottom of the bottle then it will go farther
because it will not be as heavy and less weight= more force
Controlled variables: Same rocket launcher, Same measure of distance, same bottle, same conditions
outside, same measure of water (what you put the water in to measure it)
Materials: Duct tape, 2 litter bottle, 20oz bottle, water, something to measure the water, rocket
launcher, cardboard (fins), scissors, meter stick
Procedure (bottom bottle): 1. gather materials
2. Take both bottles and place them on top of each other, bottom to bottom, place the little bottle
on top of the bigger bottle in the center of the bigger bottles bottom
3. Tape the two bottles together
4. take card board and cut out 3 right triangle fins all 6 inches long by 4 inches out
5. Take the newly cut fins and place them on the bigger bottle (with the little bottle facing up)
about 3 inches from the mouth on the big bottle, with about 4-5 inches between the fins
6. tape in the fins :)
7. take the big bottle and remove the cap and remove the cap of the smaller bottle
8. place the control measurement of water in the top and bottom bottle
9. put cap back on the top bottom
10. take your newly made rocket and take it outside with the rocket launcher
11. take the big bottle and place the mouth of it on the rocket launcher
12. put the pressure as 75psi
13. then launch the rocket and measure how far it went with your meter stick (that is your control
measurement)
14. then take the rocket and put your first test measurement in the bottom bottle (continue putting
your test measurements in and taking how far they go with your meterstick until you are done
with your tests
15. record your data in the table
16. finish your EDD
Graphs:
Conclusion for Bottom bottle: Our data doesn't support our hypothesis because we thought that the less
water in the bottle, the farther it would go. But it turned out to be that if we had 1000 mL in the bottle,
it went farthest with 55 meters average. When we had no water in the bottom, it went 6.3 meters on
average. If we were to do this experiment again, we would make the wings water resistant and we
would do all trials on the same day. We found that some days the wind was different and our data was
greatly effected.
Our Rocket: