Knives Knives source side group load side group Insulators Tps Tcs A.T. line switch Down transformer In the high-voltage reaches the blades load side group but before the blades are a bridge between the high voltage line with the rays away from the blades reach the load side and from there to TCs a switch of the switch goes up through the blades TPs to source-side group, among the blades of the source side and load si de blades are bridging or BAIPASS used to leave out the switch when you want to work in the or serviced, without interrupting the service. Group blade source si de there are 3 lines going from there to the blades on load side group and then to the TCs and then to switch banks, it serves to protect some of the processor load from there to the side cutters source group from there to the nozzles of hi gh-voltage transformer, and among these are other rays away. These structures se rve only to support a certain height, lines and blades from the floor level, thi s point is for people who come are not subjected to magnetic attraction or creat e an arc with the lines, which could cause the death of a high downloads.