Professional Documents
Culture Documents
sku: DEV-09002
Replacement: KIT-10015. We now build the kit in-house. This page is for reference only.
Description: This kit from Nuxie includes everything needed to build a function generator
capable of producing sine, triangle and square waves from 25Hz to over 250kHz. An XR2206
IC is used to generate the various waveforms.
Note: This kit requires a ~14V or higher AC or DC 2.1mm center positive wall wart to fully
drive the 12V regulator. Any AC or DC wall-wart that outputs 13V or above should work.
Output Waveforms: 5V TTL Square Wave and selectable Sine or Triangle Wave
Output Frequency: 25Hz to over 250kHz using kit components. Can be modified to 0.01Hz to
1MHz.
The amplitude and frequency adjustment pots are mounted on the board for easy adjustment. An
ON/OFF switch, Waveform selector switch and Frequency range switch are also mounted on the
board.
Kit Includes:
FunGen PCB
XR2206 Function Generator IC
74HC04 Hex Inverter IC
LM741 Op Amp IC
2.1mm Centre Positive DC Jack
100uF or 10uF Cap
5 - 1uF Cap
2 - 0.1uF Cap
0.22uF Cap
2.2nF Cap
200Ohm Resistor
2 - 1kOhm Resistor
3 - 10kIhm Resistor
1N4001 Diode
3 - Slide Switches
2 - 50kOhm Potentiometer
1 - 250kOhm Potentiometer
7812 Voltage Regulator
78L05 Voltage Regulator
2x Dual Screw Terminal Connectors