Professional Documents
Culture Documents
1195 UMTS Course
1195 UMTS Course
Introduction
UMTS principles
Network Architecture
WCDMA Basics
General Protocols Model
Radio Resource Management and ATM transmission
UMTS Evolution
HSDPA
TDD
All IP
UMTS Project
Network Architecture and Design
Rollout
System Acceptance Testing
Network Performances
Launch
Rollout
9 Acquisition
9 Construction System acceptance
9 Installation 9 Test plan specification
9 Integration 9 Test acceptance
Indoor
Micro Site Signalling and Areas planning
Digit analysis planning LAC/RAC/URA/SAC
Outdoor
Micro Site DCN
architecture & Planning
Tunnel Site
Special site
Indoor/Outdoor solutions
Flexible Configurations
Transmission band: 2110 – 2170 MHz
Reception band: 1920 – 1980 MHz
Channel Bandwidth: 5 MHz
Channel Element for signal
processing
Size 1800 x 600 x 600 mm (H x W x D)
Weight 290 kg
AC or DC feed
PDH-SDH Interfaces
ATM switching
RRM functionalities
Size 1800 x 600 x 600 mm (H x W x D)
Weight 290 kg
MGW
CTN
RNC 2
connections
RNC 3
NMS
RNC
ESA 12
NEMU
OMU
Ethernet
Firewall 1 Firewall 2
NMS
Router 1 Router 2 PDH / E1s
Region Region
ESA 12
ESA 12
RNC1 RNC2
NEMU
NEMU
OMU
OMU
ADM
VC12 in
VC4 ADM
(STM-1)
ADM
PDH / E1s
ADM
AXC
NodeB 1
M
LMP W
A
M
Acquisition:
request, negotiation, build permit, …
Construction:
design drawing, site building (power supply, antenna…)
Installation:
Equipment installed and commissioned.
Integration:
All the equipments are linked through the TX network
and the site is integrated to the live network
System Acceptance
Analysis and
Reporting tools
System Acceptance
1. Testing new HW or SW
2. Regression testing
3. Testing the features
Spectrum Analyser
Radiocommunication tester
Network analyser (RF generator integrated)
Microwave signal Generator
Protocol analyser
Calibration of RF path
Amplifier Validation (PA, MHA…)
Microsoft Word
Picture
Text Document