This document describes how to access the service program mode on a copier or printer. It involves turning on the device, entering "71" using number keys, pressing and holding the stop key until a dot appears, pressing stop again and then start. This puts the device in service program mode indicated by a "5" blinking. An SP mode number can then be entered using number keys to adjust settings, and the current setting is viewed by pressing start. Exiting is done by opening and closing the front cover or turning the power off and on.
This document describes how to access the service program mode on a copier or printer. It involves turning on the device, entering "71" using number keys, pressing and holding the stop key until a dot appears, pressing stop again and then start. This puts the device in service program mode indicated by a "5" blinking. An SP mode number can then be entered using number keys to adjust settings, and the current setting is viewed by pressing start. Exiting is done by opening and closing the front cover or turning the power off and on.
This document describes how to access the service program mode on a copier or printer. It involves turning on the device, entering "71" using number keys, pressing and holding the stop key until a dot appears, pressing stop again and then start. This puts the device in service program mode indicated by a "5" blinking. An SP mode number can then be entered using number keys to adjust settings, and the current setting is viewed by pressing start. Exiting is done by opening and closing the front cover or turning the power off and on.
15.1 ACCESS PROCEDURE 1-KEY OPERATION 1. Turn on the main switch. 2. Enter "71" by using the number keys. 3. Press and hold the key until a dot (•) appears in the top left corner of the Copy Counter and then release it. 4. Press the key again and then press the key. NOTE: "5" will blink in the Copy Counter to show that the SP mode has been accessed. 5. Enter the desired SP mode number using the number keys. The SP mode numbers are given in the Service Program Mode Table. NOTE: "1" is displayed in the Manual ID indicator (as shown below) instead of "1" in the Copy Counter when SP mode numbers over "100" are entered. The maximum number is "111".
: "1" A203M500.wmf
6. Press the key to view the current setting.
NOTE: To enter a different SP mode number, press the key. 7. To leave SP mode, open and close the front cover or turn the main switch off and on.