Professional Documents
Culture Documents
AB
19, 22, 25, 32, 38, 43, 50, 63 Milimeter 50, 75, 100, 125 Milimeter 1.00, 1.20, 1.30, 1.50 Meter
Other than sizes of ( Thickness , Width & Length ) which are not mentioned above of the Rough Sawn Timber Rubber Wood is considered as Special Size. Additional allowance for the thickness & widthness is 0-3 mm. and for the length is not less than 0-30 mm. Quality & Characteristics for Grabe of Rough Sawn Timber Rubber Wood
AB
Note :Note :Note :a. For those selected rough sawn timber rubber wood after a. For those selected rough sawn timber rubber wood after a. The mixing ratio grade of selected Kiln Dried rough sawn defects selection & the maximum length shall be more defects selection & the minimum length shall be more timber rubber wood after defects selection as described than or equal to 80% ( provided 4 sides is clear ) of the than 30cm after cutting & add up shall be more than under the Thai Parawood Association Specification for wood length as per sizes mentioned above. 70% of the wood length as per sizes mentioned above. Grade - ( A : B ) is 40% : 60% accordingly. Sides with a little defects is acceptable. =< 20% >= 30cm L 20% L >= 30cm 80% T W
Four Sides is clear & can use without defects. >= 80%
T W
T W b. For those selected rough sawn timber rubber wood after defects selection & the minimum length after cutting shall be more than 60% of the wood length as per sizes mentioned above.
<= 40%
>= 60% T W
Moisture Content ( MC ) Maximum 12% Definations :1. " Timber " - means as Kiln Dried Rough Sawn Timber after has gone through the chemical threatment process. 2. " 4 Sides Clear " - means 4 sides of the wood without any defects BUT EXCEPT the defects which is less than or equal to 5 mm. size is not counted / described as defects. 3. " Defects " - means such as Black Knots, Cracks, Black Lines , Bad Fungus, Blue Stains, Bucks & Cores. REMARKS : If there is any insect holes found on the timber woods is considered Defects.