Professional Documents
Culture Documents
Removal - Based Cable Clutch: B2Bg0Gp0 - Partner
Removal - Based Cable Clutch: B2Bg0Gp0 - Partner
Unclip the cable to the transmission by acting on the side tabs (2). Disconnect the cable from the deck.
2 - REST
NOTE: It is prohibited to separate the cap of the cable. CAUTION: If, during the inspection, there is a system crash or if the pedal was filed, it is necessary to make the adjustment of the position of the pedal. this position is given by the angular displacement of the
Put the pedal position (contact A). Hook the cable cap on the pedal. Stand a new clip (3) on the pedal. Fit the nozzle (4) on the apron (mounting grease G6). Clipper tip (5) of the gearbox. Install the cable on the lever (1). Repeatedly press the clutch pedal to put all in place. Check the correct plating of the tip (4) on the apron. Check operation of automatic adjustment: 1 - pull the lever (along arrow F), the lever must fall to the hand 2 - press lightly on the clutch pedal and repeat the same maneuver: the lever should not shy
Loosen: The nut (6), the screw (7). Using a claw, face up to the stop support (8). In this position, there must be an attacking game important to the pedal. Bring down the media so as to obtain a set of attack (2 mm + / - 1mm). Tighten the screws (7) nut (6). Check the sliding of the clutch cable sheath.