Professional Documents
Culture Documents
Wireless Power Transmission - Soubel-1
Wireless Power Transmission - Soubel-1
Outline
Background Solar Power Satellite Microwave Power Transmission Current Designs Legal Issues Conclusion
Background
1899-1990
Nikola Tesla
Wardenclyffe
1899 Able to light lamps over 25 miles away without using wires High frequency current, of a Tesla coil, could light lamps filled with gas (like neon)
1940s to Present
World War II developed ability to convert energy to microwaves using a magnetron, no method for converting microwaves back to electricity 1964 William C. Brown demonstrated a rectenna which could convert microwave power to electricity
1940-50s Development of the Photovoltaic cell 1958 First US Satellite that used Solar Power 1970s Oil embargo brought increased interest and study
Would use microwaves to transmit power to Earth from Solar Powered Satellites
Idea gained momentum during the Oil Crises of 1970s, but after prices stabilized idea was dropped
Use the Space Shuttle to get pieces to a low orbit station Tow pieces to the assembly point using a purpose built space tug (similar to space shuttle)
More intense sunlight In geosynchronous orbit, 36,000 km (22,369 miles) an SPS would be illuminated over 99% of the time No need for costly storage devices for when the sun is not in view
Only a few days at spring and fall equinox would the satellite be in shadow
Continued
Waste heat is radiated back into space Power can be beamed to the location where it is needed, dont have to invest in as large a grid No air or water pollution is created during generation
Problems
Issues identified during the DOE study Complexity30 years to complete Size6.5 miles long by 3.3 miles wide Transmitting antenna mile in diameter(1 km)
Continued
1980s to Present
Japanese continued to study the idea of SPS throughout the 1980s In 1995 NASA began a Fresh Look Study
SPS could be competitive with other energy sources and deserves further study Research aimed at an SPS system of 250 MW Would cost around $10 billion and take 20 years National Research Council found the research worthwhile but under funded to achieve its goals
Specifications
Collector area must be between 50 (19 sq miles) and 150 square kilometers (57 sq miles) 50 Tons of material Current rates on the Space Shuttle run between $3500 and $5000 per pound 50 tons (112,000lbs)=$392,000,000
Continued
If the largest conceivable space power station were built and operated 24 hours a day all year round, it could produce the equivalent output of ten 1 million kilowattclass nuclear power stations.
Possible Designs
Deployment Issues
Maintenance
Possible Solutions
International Space Station Presidents plan for a return to the moon Either could be used as a base for construction activities
Microwaves
Frequency 2.45 GHz microwave beam Retro directive beam control capability Power level is well below international safety standard
Microwave
Laser
More developed High efficiency up to 85% Beams is far below the lethal levels of concentration even for a prolonged exposure Cause interference with satellite communication industry
Recently developed solid state lasers allow efficient transfer of power Range of 10% to 20% efficiency within a few years Conform to limits on eye and skin damage
Rectenna
An antenna comprising a mesh of dipoles and diodes for absorbing microwave energy from a transmitter and converting it into electric power.
Microwaves are received with about 85% efficiency Around 5km across (3.1 miles) 95% of the beam will fall on the rectenna
Rectenna Design
Currently there are two different design types being looked at Wire mesh reflector Built on a rigid frame above the ground Visually transparent so that it would not interfere with plant life Magic carpet Material pegged to the ground
5,000 MW Receiving Station (Rectenna). This station is about a mile and a half long.
Rectenna Issues
Size Miles across Location Aesthetic Near population center Health and environmental side effects Although claim that microwaves or lasers would be safe, how do you convince people
Current Developments
SPS 2000
Details
Project in Development in Japan Goal is to build a low cost demonstration model by 2025 8 Countries along the equator have agreed to be the site of a rectenna
Continued
10 MW satellite delivering microwave power Will not be in geosynchronous orbit, instead low orbit 1100 km (683 miles) Much cheaper to put a satellite in low orbit 200 seconds of power on each pass over rectenna
If microwave beams carrying power could be beamed uniformly over the earth they could power cell phones Biggest problem is that the antenna would have to be 25-30 cm square
Low Orbit
Communications industry proposing to have hundreds of satellites in low earth orbit These satellites will use microwaves to beam communications to the ground Could also be used to beam power
Continued
Since a low orbit microwave beam would spread less, the ground based rectenna could be smaller Would allow collectors on the ground of a few hundred meters across instead of 10 kilometers In low orbit they circle the Earth in about every 90 minutes
Issues
Air Force currently track 8500 man made objects in space, 7% satellites
Reliability
Ground based solar only works during clear days, and must have storage for night Power can be beamed to the location where it is needed, dont have to invest in as large a grid
A network of low orbit satellites could provide power to almost any point on Earth continuously because one satellite would always be in range
Legal Issues
NASA
Funding the research In charge of space flight for the United States Would be launching the satellites and doing maintenance
FCC
The FCC was established by the Communications Act of 1934 and is charged with regulating interstate and international communications by radio, television, wire, satellite and cable.
Environmental
Effects of long term exposure Exposure is equal to the amount that people receive from cell phones and microwaves The size of construction for the rectennas is massive
Location
International
Geosynchronous satellites would take up large sections of space Interference with communication satellites Low orbit satellites would require agreements about rectenna locations and flight paths
Conclusions
More reliable than ground based solar power In order for SPS to become a reality it several things have to happen: