Professional Documents
Culture Documents
MegaPractica Paso A Paso
MegaPractica Paso A Paso
Introduction
In this practice Packet Tracer Skills Exam, you will:
configure VLANs using VTP configure inter-VLAN routing modify STP configure port security add a wireless LAN
Addressing Table
Device Interface Fa0/0.10 Fa0/0.20 Router1 Fa0/0.43 Fa0/0.67 Internet WRS Wireless SW_DS1 SW_AC2 SW_AC3 PC1 PC2 PC3 PC4 VLAN 43 VLAN 43 VLAN 43 NIC NIC NIC NIC 172.16.100.1 172.16.43.11 172.16.43.12 172.16.43.13 172.16.10.10 172.16.20.10 172.16.10.11 DHCP assigned 255.255.255.0 255.255.255.0 255.255.255.0 255.255.255.0 255.255.255.0 255.255.255.0 255.255.255.0 255.255.255.0 n/a 172.16.43.1 172.16.43.1 172.16.43.1 172.16.10.1 172.16.20.1 172.16.10.1 172.16.100.1 172.16.43.1 172.16.67.1 172.16.67.10 255.255.255.0 255.255.255.0 255.255.255.0 n/a n/a 172.16.67.1 Address 172.16.10.1 172.16.20.1 Subnet Mask 255.255.255.0 255.255.255.0 Default Gateway n/a n/a
Note: The password for user EXEC mode is cisco. The password for privileged EXEC mode is class.
All contents are Copyright 19922010 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 1 of 4
b. To configure the switches for remote management access, create and enable interface VLAN 43 on all three switches.
b. Create and name the following VLANs on SW_DS1. c. VLAN 10: Student VLAN 20: Faculty VLAN 43: Management VLAN 67: Wireless
Step 2: Configure SW_AC2 and SW_AC3 as VTP clients to participate in the CCNA VTP domain.
All contents are Copyright 19922010 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 2 of 4
a. Step 1: Configure access ports on access layer switches. Configure the appropriate interfaces on SW_AC2 and SW_AC3 for static access. Assign VLANs according to the port assignments table.
All contents are Copyright 19922010 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 3 of 4
b. Configure wireless security. c. Set the SSID to WRS_LAN. Enable WEP security and use 12345ABCDE as key1.
d. Configure PC4 to access the wireless network that is provided by WRS. PC4 uses DHCP to obtain addressing information. Note: It will not be possible for devices to ping PC4 since PC4 is behind the WRS NAT firewall.
All contents are Copyright 19922010 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 4 of 4