Professional Documents
Culture Documents
STANDBY/ON
ORDER NO.
POWER
ARP3113
PDP-R03U
MEDIA RECEIVER
PDP-R03U
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
PDP-R03U KUC
Type
AC120V
Power Requirement
Remarks
Please connect it to the PLASMA DISPLAY PDP-503PU or PDP-433PU, for adjustment and operation inspection.
Component
PLASMA DISPLAY SYSTEM PLASMA DISPLAY MEDIA RECEIVER
System
PDP-5030HD PDP-503PU PDP-R03U
Service Manual
Remarks
Component
PLASMA DISPLAY SYSTEM PLASMA DISPLAY MEDIA RECEIVER
System
PDP-4330HD PDP-433PU PDP-R03U
Service Manual
Remarks
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
SAFTY INFORMATION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician.
B
WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 Proposition 65
NOTICE (FOR CANADIAN MODEL ONLY) Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must be of identical designation. REMARQUE (POUR MODLE CANADIEN SEULEMENT)
C
Measure leakage current to a known ear th ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the ear th ground and all exposed metal par ts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120V AC 60 Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5 mA.
ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER. 2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance have special safety related character istics. These are often not evident from visual inspection nor the protection afforded by them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement par ts which have these special safety character istics are identified in this Service Manual. Electr ical components having such features are identified by marking with a on the schematics and on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in the parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. For the latest infor mation, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PIONEER Ser vice Manual may be obtained at a nominal charge from PIONEER.
Earth ground
AC Leakage Test
F
2
1 2
PDP-R03U
3 4
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual.
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable. In accordance with the procedures or instructions described in this manual, adjustments should be performed.
3. Cleaning
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning, proper cleaning should be performed to restore their performances. B
PDP-R03U
5 6 7 8
CONTENTS
A
SAFTY INFORMATION . . . . . . . . . . . . . . . . . 1. SPECIFICATIONS . . . . . . . . . . . . . . . . . . . 2. EXPLODED VIEWS AND PARTS LIST . . . . . . . . 2.1 PACKING . . . . . . . . . . . . . . . . . . . . . 2.2 EXTERIOR SECTION . . . . . . . . . . . . . . . 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM . . . 3.1 SYSTEM BLOCK DIAGRAM . . . . . . . . . . . 3.2 SIGNAL FLOW BLOCK DIAGRAM . . . . . . . . 3.3 DC/DC CONVERTER CONNECTION DIAGRAM . 3.4 POWER BLOCK DIAGRAM . . . . . . . . . . . . 3.5 PC/IF BLOCK DIAGRAM . . . . . . . . . . . . . 3.6 PRINTED WIRING BOARD BLOCK DIAGRAM . . 3.7 OVERALL WIRING DIAGRAM (1) . . . . . . . . . 3.8 OVERALL WIRING DIAGRAM (2) . . . . . . . . . 3.9 MAIN UNIT (1/7) . . . . . . . . . . . . . . . . . . 3.10 MAIN UNIT (2/7) . . . . . . . . . . . . . . . . . 3.11 MAIN UNIT (3/7) . . . . . . . . . . . . . . . . . 3.12 MAIN UNIT (4/7) . . . . . . . . . . . . . . . . . 3.13 MAIN UNIT (5/7) . . . . . . . . . . . . . . . . . 3.14 MAIN UNIT (6/7) . . . . . . . . . . . . . . . . . 3.15 MAIN UNIT (7/7) . . . . . . . . . . . . . . . . . 3.16 FRONT UNIT . . . . . . . . . . . . . . . . . . . 3.17 AV UNIT (1/3). . . . . . . . . . . . . . . . . . . 3.18 AV UNIT (2/3). . . . . . . . . . . . . . . . . . . 3.19 AV UNIT (3/3). . . . . . . . . . . . . . . . . . . 3.20 LED UNIT. . . . . . . . . . . . . . . . . . . . . 3.21 SR CONNECT UNIT . . . . . . . . . . . . . . . 3.22 PC I/F UNIT (1/7) . . . . . . . . . . . . . . . . . 3.23 PC I/F UNIT (2/7) . . . . . . . . . . . . . . . . . 3.24 PC I/F UNIT (3/7) . . . . . . . . . . . . . . . . . 3.25 PC I/F UNIT (4/7) . . . . . . . . . . . . . . . . . 3.26 PC I/F UNIT (5/7) . . . . . . . . . . . . . . . . . 3.27 PC I/F UNIT (6/7) . . . . . . . . . . . . . . . . . 3.28 PC I/F UNIT (7/7) . . . . . . . . . . . . . . . . . 3.29 POWER and EMC UNITS . . . . . . . . . . . . 4. PCB CONNECTION DIAGRAM . . . . . . . . . . . . 4.1 POWER and EMC UNITS . . . . . . . . . . . . . 4.2 MAIN UNIT. . . . . . . . . . . . . . . . . . . . . 4.3 FRONT, LED and SR CONNECT UNIT . . . . . . 4.4 AV UNIT . . . . . . . . . . . . . . . . . . . . . . 4.5 PC I/F UNIT . . . . . . . . . . . . . . . . . . . . 5. PCB PARTS LIST . . . . . . . . . . . . . . . . . . . 6. ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . 7. GENERAL INFORMATION . . . . . . . . . . . . . . . 7.1 DIAGNOSIS . . . . . . . . . . . . . . . . . . . . 7.1.1 TROUBLE SHOOTING . . . . . . . . . . . . . 7.1.2 DISASSEMBLY . . . . . . . . . . . . . . . . . 7.2 IC . . . . . . . . . . . . . . . . . . . . . . . . . 7.3 IC DESCRIPTIONS . . . . . . . . . . . . . . . . 8. PANEL FACILITIES . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
1 2
PDP-R03U
3 4
1. SPECIFICATIONS
Item Reception System TV Function Circuit type Media Receiver, Model: PDP-R03U American TV standard NTSC system Video signal detection PLL full synchr onous detection, PLL digital synthesizer system Tuner VHF/UHF CATV Audio multiplex Terminals Rear INPUT 1 INPUT 2 INPUT 3 Antenna Front INPUT 4 PC Monitor Out Terminal OSD Language Other Features Power Requirement Dimensions Weight Accessories Rear VHF 213ch, UHF 1469ch 1125ch BTSC system S-VIDEO in, A in, COMPONENT in V S-VIDEO in, A in V S-VIDEO in, A in, COMPONENT in, RGB in V 75 UNBAL, F Type for VHF/UHF/CA in TV S-VIDEO, A in V 15 Pin mini D-Sub, Audio in S-VIDEO out, A out, Audio (Variable, Fixed) V English/French/Spanish Picture & Picture, Still image, Dual Tuner System
C B A
120 V AC, 60 Hz, 40 W (0.2 W Standby) 420 (W) 70 (H) 330 (D) mm (16 9/16 (W) 2 25/32 (H) 13 (D) inch) 4.4 kg (9.7 lbs.) Power cord, Remote control unit, Two AA size batteries, System cable, Operating instruction
accessories
PDP-R03U
5 6 7 8
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.)
2.1 PACKING
5. Operation Instructions 6. PDP Caution
B
2. System Cable 7. System Cable Caution 8. Caution Card 4. Batteries 1. Power Cord
6
1 2
PDP-R03U
3 4
6 7 8 9 10 11 12 13
PDP-R03U
5 6 7 8
8
1 2
PDP-R03U
3 4
2-15 Ratch 2-16 Screw 2-17 Screw 3 NSP 3-1 3-2 3-3 3-4 4 NSP 4-1 4-2 5 NSP 5-1 5-2 5-3 5-4 6 NSP 6-1 6-2 6-3 7 8 9 10 11 Shield Assy Shield Holder Heat Sink Spacer Top Cabinet Assy Top Cabinet Caution Label Fixing Metal Assy Fixing Metal Holder Shield Spacer Ground-Part Assy Ground-Part Spacer Gasket Holder Holder Screw Shaft Shield
E SERVICE JIGS Connector, 30-pin (PC I/F-MAIN) Connector, 50-pin (PC I/F-MAIN) Connector, 4-pin (SR-AV) Connector, 13-pin (PC I/F-FRONT) Connector, 12-pin (PC I/F-MAIN) QCNW-6099CEZZ QCNW-6100CEZZ QCNW-6101CEZZ
QCNW-6102CEZZ QCNW-6103CEZZ F
PDP-R03U
5 6 7 8
R L Y Pb Pr
IC1301 AV SWITCH CXA2069Q(90h) TV R/L-TV S1 V1 R/L1 S2 V2 R/L2 S3 V3 R/L3 S4 V4 R/L4 Y/VOUT 3 COUT3 R/L 3 V5 R/L5 V6 R/L6 Y/VOUT 2 COUT2 R/L 2 Y/VOUT1 COUT1 R/L 1
CH3
IC403 M62320(78h)
CH 3
I/O EXPANDD D0 MODE2 D1 DVs s D2 IC1602 C.C Z86129(28h) VIDEO RGB HD BOX CH3 D3 DVs s D4 D5 APCN D6 TRAP D7 DVs s
VIDEO2 S
R L
IC2504 VIDEO3 S AnalogSW(MAIN) NJM2233BM IN1 IN2 CTL V IC1401 R L Y COMPONENT AV SWITCH MM1519XQ(94h) YPbPrTV YPbPr1 YPbPr2 RGB YPbPr3 OUT1 OUT2 OUT3 CH 3 IC2505 AnalogSW(SUB) NJM2233BM IN1 IN2 CTL OUT IC1601 V-CHIP(SUB) Z86230(28h) VIDEO CH1 OUT IC1603 V-CHIP(MAIN) Z86230(2Ah) VIDEO CH3
Pb Pr
LOUT1
H/V
MONITOR OUT
SC1502 Y MUTE from TUNER AFT-1/ 2 AGC-1/2 ACL_SIG ABL I2C-CH1 I2C-CH2 I2C-CH3 SMPOW
S L MUTE V
L-MUTE PSEL-1/2 TBUS IN1 IN3 IC1102 I/O EXPANDD M 62320(74h) D1 It goes into process mode by dropping on GND. SRESET TV-COL1 TV-COL2 CH3 OUT1 ACL-SW MRDY
VIDEO4 S
D2 D3 D4 V1PLUG D5 V2PLUG D6 V3PLUG D7 V4PLUG IC1503 I/O EXPAND D M62320(74h) D0 IN1 D1 LED-R D2 D_POW D3 +2.5POW D4 IN3 POWER LED CONTROL D5 LED-G D6 DACRST D7 SMPOW or CH1
R L
PC R/ L
10
1 2
PDP-R03U
3 4
CB-GAIN
IC801 SIG. PROCESSO R (MAIN) TB1274AF(88h) CVBS/Y1 C1 LOWER LUMINANCE CNR CVBS/Y2 C2 CVBS/Y3 C3 YS2/YM YCbCr1 YCbCr2 RGB1 RGB2 CrOUT H/V CbOUT YOUT
CR-MAIN
CH3
IC803 SIG. PROCESSO R CXA2101Q(84h) YCbCr1 H/V1 YCbCr2 H/V2 YCbCr3 ROU T GOUT BOU T
CH3 IC810 LPF6.7M(MAIN) ML6426-1 RGB INA RGB INB A/B MUX SYNC RGB
LEVEL ADJ.
LEVEL ADJ.
H/V
IC811 LPF30M(MAIN) ML6426-1 RGB INA RGB INB A/B MUX SYNC RGB MAIN R MAIN G MAIN B MAIN H MAIN V SC1501
IC802 IC402 3Line COM CXD2093Q ADIN AYO ACO SIG. PROCESSO R (SUB ) TB1274AF(8Ah) CVBS/Y 1 C1 CVBS/Y2 C2 CVBS/Y 3 C3 COMB_Y COMB_C YCbCr1 RGB1 RGB2 H/V YOUT CbOUT CrOUT
CH3
IC804 LPF6.7M(SUB) ML6426-1 RGB INA RGB INB A/B MUX IC1901 H-BLK GEN. PLD EPM3064-10 SP_H/V/CLP PL_H/V HD/VD1 HD/VD2 US_H/V AW_VBLK PL_BLK/CLP HD/VD3 CNR_CLP/BLK TEXT_H/V HDS/VDS SUB H SUB V SYNC RGB SUB Y SUB Cb SUB Cr
PC I/F UNIT
IC1902 I/O EXPAND M62320(7Bh) D0 MODEC D1 MODEB D2 MODEA D3 SEL_A D4 SEL_OE D5 MFIL_SEL D6 IC7200 V-BLK GEN. AutoWide IX-3289CE Y/V IN PC I/F UNIT H/ V VBLK D7
CH3
IC604 SYNC. SEP. TA1318(D8h) HD/VD1 HD/VD2 HD/VD3 SYNC1 SYNC2 HD/VD 1 HD/VD 2 CP
E
+5 VBK +12V
IC1708 REG +5V(A ) IC15 DAC EXPAN D M62393(92h) A1 CR-MAIN A2 CR-SUB A3 +B2.5 A4 +BADJ2 A5 REFADJ A6 A7 A8 CB-GAIN RESET IC1504 AnalogSW TC7W53 IN0 IN1 CNT OUT IC1712 REG +5V(A ) T1701 DC/DC B35V D6V -5 V +12VA IC1711 REG +5V(D ) CH 1 IC1710 REG +5V(A ) IC1706 REG +8V IC1704 REG +9V(A ) IC1701 DC/DC +2.5VCV +3.3V(D) +6V IC1709 REG +5V(A) IC1713 REG +12V +2.5POW
PDP-R03U
5 6 7 8
11
12
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
13
14
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
15
16
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
17
CPCI-00 56CE
12 7 9 CLR_ SW PC _H P C_V P C_C 1B 1Y 2B 2Y 10 5 1A 1 2A 3 MAIN _H D MAIN_VD HV SEL P C_R 18 PC _G -A /+B 4A 4B OV0 _H OV0_V PC_ C3 V0_HSYNC V0_VSYNC V0_CSYNC DO_RA[9..2] DO_GA[9..2] DO_BA[9..2]
X4 25MHz
MCK_REF DCLK
CN8
4Y
LCLK
OV0_PDEN
17 P C_B RIN2 GIN2 BIN2 29,3 0 25,2 6 21,2 2 MAI N_ R MAI N_ G MAI N_ B
OV0_HSYNR
V0_HSYNR
CVIC
BINT
CN6
GOUT BOUT
I2C=CH2
IC25
XPW R_SV
AO[8..1]
BO[8..1] CO[8..1]
RT RB
CLK EXTCLP - OE
V1_VDCLK_O V1_CLP
V1 PLL
About 60MHz VCOOUT
FIN-A FIN-B
SUB _VD
OV1_PDEN
V1_PDEN
18
1 2
PDP-R03U
3 4
X6 25.175MHz X5 79.794MHz
8 8 8
5,6:VD+2.5 8:VD+3.3
LCLK(79.79 4MHz)
TMDS(4ch)
CN9
IDCK+
DVI
MCK
IC414 M24C32
3:VA+5
CN3
MON_DET
-RST _PL
VGA_ OE WXGA_OE
IRQ3 IRQ4 -C1_I NT XPWR_SV HVSEL SEL _CD SAD C_OE CAR D_RST P XOE THER MO B SREQ CLR_ SW TXD 1_T RXD 1_T IRQ0 PTC5 PTA0 PTD7 PTE6 PTB7 PTC7 AN7 PTE6 PTD4 TXD1 RXD1
TXD0 RXD0
CN7
CKIO
EXTAL
PTD1
SCK1
SCK2
PTB6
XTAL
PTF0
PTE1
PTE7
R1106
6 R1078
FLWP
WP
IO_STB
CVIC INTERNAL SUPPLY VOLTAGE MONITOR R1105 MOUNTED: VD+2.5V=2.5V R1106 MOUNTED: VD+2.5V=1.8V
44 9 10 23 7 35
R1077
AN2
PTB3 A20
PTA1
RESETP
PTD6
CKE CE2A
CPU
IRQ1 PTG2 PTJ4 PTJ5 PTE3 PTE2 PTE1 PTC4 PTC0 PTB2 PTB0 PTJ7 PTA5 PTA3
SSYSTEM KOUTEI DAC_DATA DAC_CLK ACL_SW RES_OUT3 S RESET TV_COL2 TV_COL1 HPMUTE 1 LMUTE SH_ON AWC S_R AWC S_W
CVIC INTERNAL SUPPLY VOLTAGE SELECTOR R1077 MOUNTED: VD+2.5V=2.5V R1078 MOUNTED: VD+2.5V=1.8V
CCKM
P C_V
PC DDC DETECT
CSEN2
FLASH_W SRST S1
5 4
15pin SERIAL=CH0
CN1
FWMODEN
15
PDP-R03U
5 6 7 8
19
PC/IF UNIT
VIDEO PROCESSOR CIRCUIT
POWER REG. CIRCUIT IC7 REG. CN9 CONNECTOR IC8 REG. IC320 SDRAM IC319 SDRAM
CPCI-0056CE
PANEL LINK OUTPUT CIRCUIT
B
CN8 CONNECTOR IC4 VIDEO MAIN/PC A/D CONV IC25 CIVIC
IC1 CPU
C
CN6 CONNECTOR CN CONNECTOR CN1 CONNECTOR
CPU CIRCUI T
C
D
AV UNIT
SC1101 INPUT1, INPUT2 S-VIDEO TERMINAL J1104 INPUT3 AV TERMINAL INPUT3 CONPONENT TERMINAL MONITER OUT AV TERMINAL SC1102 INPUT3, MONITER OUT S-VIDEO TERMINAL SC1103 INPUT4 RGB TERMINAL
CN5 RS-232C
IC1401 AV SWITCH IC1602 CCD IC1102 CONTROL P1301 CONNECTOR IC1301 AV SWITCH
E
SC1401 CONNECTOR COMP. AV SWITCH CIRCUIT IC1603 V-CHIP
SC1402 CONNECTOR ANALOG AV SWITCH CIRCUIT P2502 CONNECTOR IC2501 MULTI SOUND P2501 CONNECTOR
P2503 CONNECTOR
20
1 2
PDP-R03U
3 4
MAIN UNIT
SC1502 CONNECTOR
SC1503 CONNECTOR
B
SC1501 CONNECTOR SC1504 CONNECTOR IC402 SUB COMB FILTER IC403 CONTROL
IC1901 PLD
P1702 CONNECTOR IC803 RGB DECODER IC1502 DAC IC7001 Y/C SEPARATE IC801 MAIN VIDEO CHROMA P1502 CONNECTOR L1708 T1701 L1718 IC7002 MEMORY POWER SUPPLY L1710 P1703 CONNECTOR
PDP-R03U
5 6 7 8
21
RESISTOR 1. The unit of resistance is omitted. (K=k =1000 , M=M ). 2. All resistors are 5%, unless otherwise noted. (J= 5%, F= 1%, D= 0.5%) 3. All resistors are Carbon type, unless otherwise noted. C : Solid W : Cement S : Oxide Film T : Special N : Metal Coating
22
1 2
PDP-R03U
3 4
WAVEFORMS
3
IC1301 63-pin IC1301 60-pin IC1301 56-pin TP7004 TP7003 V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 500mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div B
TP812 TP603 TP803 TP802 TP801 V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 100mV/div H: 10sec/div V: 100mV/div H: 10sec/div V: 100mV/div H: 10sec/div
TP809 TP808 TP807 IC810 13-pin IC810 11-pin V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div D
&
IC1301 44-pin TP410 IC802 21-pin V: 500mV/div H: 10sec/div V: 500mV/div H: 10sec/div V: 200mV/div H: 10sec/div E
IC802 22-pin IC802 23-pin IC804 13-pin IC804 11-pin IC804 10-pin V: 200mV/div H: 10sec/div V: 200mV/div H: 10sec/div V: 500mV/div H: 10sec/div V: 500mV/div H: 10sec/div V: 500mV/div H: 10sec/div F
PDP-R03U
5 6 7 8
23
H
B
P6000
P6001
EMC UNIT
F
PC I/F UNIT
CN7 CN703 QCNW-6077CEZZ CN702
E
QCNW6084CEZZ
CN9
CN8
G
POWER UNIT
D
F
P3001
LED UNIT
24
1 2
PDP-R03U
3 4
CN6
QCNW6083CEZZ
CN1
E SR CONNECT UNIT
Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST".
TUNER
TUNER
SC1502
SC1401
AV UNIT
SC1501
P2502 P2501
QCNW-6080CEZZ
MAIN UNIT
P1702
P3401
P3402
QCNW-6076CEZZ
FRONT UNIT
PDP-R03U
5 6 7 8
25
F
B
F 1/7-7/7
SR CONNECT UNIT
(DUNTKA 618DE01)
D
D
LED UNIT
B
FRONT UNIT (DUNTKA617DE01)
(DUNTKA 619DE01)
C C 1/3-3/3
AV UNIT (DUNTKA616DE01)
F
26
1 2
PDP-R03U
3 4
A A 1/7-7/7
MAIN UNIT (DUNTKA535DE04)
D
H G
POWER UNIT
(RDENC0331CEZZ)
EMC UNIT
(RDENCA 007WJZZ)
PDP-R03U
5 6 7 8
27
A 1/7 A
28
1 2
PDP-R03U
3 4
A 6/7
A 1/7
PDP-R03U
5 6 7 8
29
A 2/7
MAIN UNIT (DUNTKA535DE04)
A 1/7
A 2/7 A
30
1 2
PDP-R03U
3 4
A 7/7
A 3/7 A 4/7
D
A 4/7 A 6/7
A 7/7
F
A 2/7
PDP-R03U
5 6 7 8
31
A 2/7
A 3/7 A
32
1 2
PDP-R03U
3 4
A 5/7
B
A 4/7
C
A 6/7
A 6/7
D
A 4/7
E
A 6/7
A 7/7
A 3/7
PDP-R03U
5 6 7 8
33
A 2/7
A 3/7
A 3/7
A 4/7 A
34
1 2
PDP-R03U
3 4
A 7/7
A 7/7
A 6/7
A 4/7
PDP-R03U
5 6 7 8
35
A 7/7
A 3/7
A 6/7
A 5/7 A
36
1 2
PDP-R03U
3 4
A 7/7 A 6/7
A 3/7
C
A 3/7
D
A 3/7
A 5/7
PDP-R03U
5 6 7 8
37
C 2/3 SC1401
F 7/7 CN6
A 2/7
D
A 3/7
A 4/7
A 5/7
F
A 6/7 A
38
1 2
PDP-R03U
3 4
G
C
A 7/7
CN703
A 6/7
PDP-R03U
5 6 7 8
39
A 5/7
A 6/7
A 6/7
F
A 7/7 A
40
1 2
PDP-R03U
3 4
F 7/7 CN9
D
C 2/3 P2501
E F
A 7/7
PDP-R03U
5 6 7 8
41
F 3/7 CN8
SW3401 : CLEAR
B
42
1 2
PDP-R03U
3 4
C 2/3 P1301
F
B
PDP-R03U
5 6 7 8
43
C 1/3 A
44
1 2
PDP-R03U
3 4
C 2/3
B
C 2/3
C 3/3
C 2/3
C 2/3
C 1/3
PDP-R03U
5 6 7 8
45
C 1/3
C 1/3
C 2/3 A
46
1 2
P3402
A 7/7 P1703
P6001
PDP-R03U
3 4
A 6/7 SC1503
C
C 3/3
D
D E
A 6/7 SC1504
F
C 2/3
PDP-R03U
5 6 7 8
47
P3001
C 2/3
C 2/3
C 2/3
D
C 2/3
C 2/3
E
C 3/3
F
AV UNIT (DUNTKA616DE01)
C 3/3 A
48
1 2
PDP-R03U
3 4
C 2/3 P2503
E F
D
PDP-R03U
5 6 7 8
49
E
50
1 2
C 2/3 P2502
F 7/7 CN1
PDP-R03U
3 4
E
PDP-R03U
5 6 7 8
51
F 2/7
B
F 7/7
F 2/7
F 5/7
C
F 7/7
F 3/7
F 5/7
F A1/7
52
1 2
PDP-R03U
3 4
F 2/7
F 7/7 F 5/7
D
F 2/7
F 2/7
F 5/7 F 3/7
PDP-R03U
5 6 7 8
F 1/7
53
F 1/7
F 1/7
F 1/7
F 1/7
F A2/7
54
1
A 6/7 SC1502
PDP-R03U
2 3 4
F 3/7
F 4/7
F 4/7
F 7/7
F 2/7
PDP-R03U
5 6 7 8
55
F 7/7
F 5/7
F A3/7
56
1 2
P3401
PDP-R03U
3 4
F 4/7 F 5/7
D
F 5/7
F 3/7
PDP-R03U
5 6 7 8
57
F 7/7
F 7/7
F A4/7
58
1 2
PDP-R03U
3 4
F 5/7
F 7/7
F 5/7
F 4/7
PDP-R03U
5 6 7 8
59
F 1/7
B
F 2/7 F 3/7
D
F 4/7
F 3/7
F 7/7
F
F A5/7
60
1
F 3/7
PDP-R03U
2
F 4/7 F 7/7
3
F 4/7
F 2/7
4
F 5/7
F 6/7
F 6/7 F 2/7
5 6
F 6/7 F 7/7
PDP-R03U
7
F 1/7
8
F 5/7
61
F 5/7
F A6/7
62
1 2
F 5/7
PDP-R03U
3 4
F 7/7
F 6/7
PDP-R03U
5 6 7 8
63
F 2/7
F 1/7
F A7/7
64
1 2
A 7/7 P1702
P6000
PDP-R03U
3 4
A 6/7 SC1501
F 2/7
F 7/7
PDP-R03U
5 6 7 8
65
(LIVE) (NEUTRAL)
H
C
(LIVE) (NEUTRAL)
(LIVE) (NEUTRAL)
NOTE FOR FUSE REPLACEMENT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS ONLY.
G H
66
1 2
PDP-R03U
3 4
A 6/7 P1502
G
PDP-R03U
5 6 7 8
67
3. The parts mounted on this PCB include all necessary parts for several destinations. For further information for respective destinations, be sure to check with the schematic diagram. 4. View point of PCB diagrams.
Connector
Transistor
Capacitor
B C E B B C E D D G S G S D G S C E B C E
SIDE A
Transistor with resistor
P.C.Board
Chip Part
SIDE B
Resistor array
3-terminal regulator
68
1 2
PDP-R03U
3 4
G POWER UNIT
Q704
Q702
Q706 Q705
CN703
A P1502
H EMC UNIT
E LIVE
AC IN
NEUTRAL
G H
PDP-R03U
5 6 7
G H
69
8
SIDE A
A MAIN UNIT
F CN9
B
P1702
IC1706
C P2501
P1703
IC1704
C SC1402
IC1502
SC1504 C
Q7001
IC7001 Q424 Q427 IC405 Q616 Q619 IC406 IC7004 Q818 Q827 IC603 IC402 IC604 IC801
C
SC1401
SC1503
IC403
IC807 IC1903
SC1502 F
SC1501
P1502
A
70
1
F CN7
F CN6
PDP-R03U
2 3
G CN703
A
4
SIDE B
SIDE B
A
A MAIN UNIT
Q1710 Q1718
C
IC1712 IC7003 Q7002 Q7010
IC7002 IC407 Q407 Q408 Q414 Q415 Q416 Q420 Q421 Q428 IC602 Q601 Q615
IC1708 IC404 IC605 Q621 IC814 Q7202 Q7205 IC7201 IC1902 Q803 Q806 IC1503 Q1502 Q1503 Q1504 IC812 IC804 IC813 IC811 Q801 Q813 IC810
A
PDP-R03U
5 6 7 8
A
71
SIDE A
B FRONT UNIT
F CN8
P3401
C P1301
P3402
IC3401
Q3403
Q3402 Q3401
D LED UNIT
P3001
C P2503
E SR CONNECT UNIT
Q6005
P6000
P6001
F CN1
F
C P2502
B D E
72
1 2
B D E
PDP-R03U
3 4
4.4 AV UNIT
SIDE A SIDE A
C AV UNIT
Q1133 Q1124 Q1120 IC1103 IC1105 IC1104 Q1131 Q1135 IC2501 IC2504
IC1606 IC1604 IC1601 IC1603 IC1602 IC1611 IC1012 IC1605 IC1606 IC1615 IC1614 IC1609 IC1613 Q1113 Q1117 IC1102 Q1105 Q1106 Q1107 IC2503 Q1609 Q1610 Q1611 Q1109 Q1112 Q1104 Q1105 Q1106 Q1107
A SC1504 D P6001
E P3001
P2501
A P1703
D
P1301
B P3402 A SC1503
E
Q1125 Q1102
IC1401
SC1401
C
PDP-R03U
5 6 7 8
C
73
SIDE A
PC I/F UNIT
D P6000
CN1
C
IC319
IC25
IC1
IC320
CN9
CN8
CN6
CN7
A P1702
F
B P3401
A SC1501 A SC1502
F
74
1 2
F
PDP-R03U
3 4
SIDE B
SIDE B
A
PC I/F UNIT
B
Q103 IC414 IC19 IC2
IC27 IC28
C
IC321
IC3 Q120
IC408 IC421 IC410 IC328 Q104 Q119 IC420 IC419 IC407 Q101
IC415
F
PDP-R03U
5 6 7 8
F
75
NOTES:
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). 560 56 x 10 1 RD1/4PU 5 6 1 J 561 47k RD1/4PU 4 7 3 J 47 x 10 3 473 0.5 RN2H R 5 0 K R50 1 RS1P 1 R 0 K 1R0 Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k 562 x 10 1 5621 RN1/4PC 5 6 2 1 F
Mark No.
Description
Part No.
DUNTKA535DE04 DUNTKA617DE01 DUNTKA616DE01 DUNTKA619DE01 DUNTKA618DE01 CPCI-0056CE15 RDENC0331CEZZ RDENCA007WJZZ
Mark No.
Description
Part No.
VHiPST600iM-1Y RH-iX3289CEZZ
LIST OF ASSEMBLIES
1..MAIN UNIT 1..FRONT UNIT 1..AV UNIT 1..LED UNIT 1..SR UNIT 1..PC I/F UNIT 1..POWER UNIT 1..EMC UNIT C
TRANSISTOR
Q403 Q405 Q406 Q407 Q408 Q424 Q425 Q601 Q602 Q603 Q604 Q605 Q606 Q607 Q608 Q609 Q610 Q611 Q612 Q613 Q614 Q615 Q616 Q617 Q801 Q802 Q803 Q804 Q805 Q807 Q808 Q809 Q810 Q811 Q812 Q813 Q814 Q815 Q818 Q819 Q820 Q821 Q822 2SA1530AR 2SA1530AR 2SC3928AR 2SC3928AR 2SC3928AR 2SA1530AR 2SA1530AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SK1467 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR DTC144EE 2SC3928AR 2SA1530AR 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR DTC124EKA 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SC2735 2SC2735 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SK1467//-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VSDTC144EE/-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VSDTC124EKA-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC2735//1E VS2SC2735//1E
Mark No.
Description
Part No.
A MAIN UNIT
IC
IC402 IC403 IC404 IC604 IC801 IC802 IC803 IC804 IC807 IC808 IC810 IC811 IC812 IC814 IC1502 IC1503 IC1504 IC1701 IC1704 IC1706 IC1708 IC1709 IC1710 IC1711 IC1712 IC1713 IC1901 IC1902 IC1903 IC7001 CXD2093Q M62320FP Ml6428 TA1318AF TB1274AF TB1274AF CXA2101AQ-Tl Ml6426CS-1 TC7W34FU TC7W34FU Ml6426CS-1 Ml6426CS-4 NJM353M BA7655AF M62393FP M62320FP TC7W53FU FA3675F BA09FP-E2 BA08FP BA05FP BA05FP BA05FP BA05FP BA05FP BA12FP-E2 I.C. M62320FP TC7W34FU UPD64082GF-3BA VHiCXD2093Q-1Q VHiM62320FP-1 VHiML6428C1-1Y VHiTA1318AF-1Y VHiTB1274AF-1Q VHiTB1274AF-1Q VHiCXA2101Q-1 RH-iX3473CEZZ VHiTC7W34U/-1Y VHiTC7W34U/-1Y RH-iX3473CEZZ RH-iX3474CEZZ VHiNJM353M/-1 VHiBA7655AF-1 VHiM62393FP-1 VHiM62320FP-1 VHiTC7W53U/-1 VHiFA3675F/-1 VHiBA09T/FP-1 VHiBA08FP++-1Y VHiBA05FP++-1Y VHiBA05FP++-1Y VHiBA05FP++-1Y VHiBA05FP++-1Y VHiBA05FP++-1Y VHiBA12FP++-1Y RH-iXA194WJZZQ VHiM62320FP-1 VHiTC7W34U/-1Y VHiPD64082/-1S RH-IX3152CEZZY VHiML6428C1-1Y VHiBA033FP/-1
76
1 2
PDP-R03U
3 4
Mark No.
Q823 Q824 Q825 Q826 Q827 Q828 Q830 Q837 Q838 Q839 Q840 Q841 Q842 Q843 Q844 Q1502 Q1503 Q1504 Q1507 Q1508 Q1509 Q1510 Q1511 Q1512 Q1513 Q1701 Q1708 Q1710 Q1718 Q1719 Q7001 Q7002 Q7003 Q7004 Q7005 Q7006 Q7007 Q7008 Q7009 Q7010 Q7201 Q7206
Description
2SC2735 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SC3928AR 2SC3928AR 2SA1530AR 2SC2735 2SC2735 2SC2735 2SC3928AR 2SC3928AR 2SC3928AR DTC144EE 2SB1132Q 2SC3928AR DTC144EE DTA124EKA DTC124EKA DTA124EKA DTC124EKA DTA124EKA DTC124EKA DTC114EE DTC114EE FMMT718 2SK2503 2SC3928AR 2SA1530AR 2SC3928AR 2SA1530AR 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SC3928AR 2SC3928AR
Part No.
VS2SC2735//1E VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SC2735//1E VS2SC2735//1E VS2SC2735//1E VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VSDTC144EE/-1 VS2SB1132Q/-1 VS2SC3928AR-1 VSDTC144EE/-1 VSDTA124EKA-1 VSDTC124EKA-1 VSDTA124EKA-1 VSDTC124EKA-1 VSDTA124EKA-1 VSDTC124EKA-1 VSDTC114EE/-1 VSDTC114EE/-1 VSFMMT718//-1 VS2SK2503//-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1
Mark No.
D1713 D1715 D1716 D1717 D1719 D1720 D1723 D1724 D1727 Diode Diode Diode Diode Diode Diode Diode Diode Diode
Description
Part No.
VHDHSU119//-1 VHDSFPB56//2E VHD1SS250//1E VHDSFPB76//2E VHDSFPB76//2E VHDSFPB76//2E VHDSFPB74//2E VHDHSU119//-1 VHDHSU119//-1 VHDDAN222//-1 VHDDAN222//-1
PACKAGED CIRCUIT
X601 X801 X802 X1901 X7001 Filter Crystal Crystal Crystal Crystal RFiLA0034CEZZ RCRSB0244CEZZ RCRSB0244CEZZ RCRSZ0093CEZZY RCRSC0026CEZZY B
DIODE
D601 D801 D802 D1502 D1503 D1504 D1505 D1506 D1701 D1702 D1706 D1708 D1709 D1710 D1711 Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Zener Diode Zener Diode Zener Diode Diode VHD1SS355//-1 VHD1SS355//-1 VHD1SS355//-1 VHDDAN222//-1 VHDDAN222//-1 VHDDAN222//-1 VHD1SS355//-1 VHD1SS355//-1 VHDHSU119//-1 VHDHSU119//-1 VHDSFPB74//2E RH-EX0501CEZZY RH-EX0501CEZZY RH-EX0523CEZZ VHDSFPB74//2E VHDHSU119//-1
CAPACITOR
C403 C404 C405 C406 C407 22 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic VCEAPF0JW226M VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z F
D1712 Diode
PDP-R03U
5 6 7 8
77
Mark No.
C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C421 C422 C423 C427 C428 C429 C452 C460 C461 C462 C466 C467 C468 C614 C615 C616 C617 C618 C620 C622 C623 C624 D C625 C626 C627 C628 C629 C630 C631 C632 C633 C634 E C635 C636 C638 C639 C640 C641 C642 C643 C644 C645 C646 C647 C648 C649 C650
Description
0.1 25V Ceramic 0.1 25V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 1000p 50V Ceramic 0.022 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 16V Electrolytic 0.1 25V Ceramic 27p 50V Ceramic 56p 50V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 27p 50V Ceramic 10p 50V Ceramic 10p 50V Ceramic 100 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 1.0 50V Electrolytic 0.01 50V Ceramic 1.0 50V Electrolytic 0.1 25V Ceramic 330 16V Electrolytic 220 6.3V Electrolytic 0.01 50V Ceramic 0.1 25V Ceramic 47 16V Electrolytic 0.1 25V Ceramic 47 16V Electrolytic 0.1 25V Ceramic 220p 50V Ceramic 820p 50V Ceramic 3900p 50V Ceramic 1200p 50V Ceramic 120p 50V Ceramic 0.01 50V Ceramic 22 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 10 16V Electrolytic 10 16V Electrolytic 22 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 47 16V Electrolytic 0.1 25V Ceramic 4.7 50V Electrolytic 33 10V Electrolytic 100 16V Electrolytic 0.1 25V Ceramic 150p 50V Ceramic
Part No.
VCKYCY1EF104Z VCKYCY1EF104Z VCKYTV1CB105K VCKYTV1EB104K VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF0JN107M VCKYCY1HB102K VCKYCY1HF223Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPW1CN107M VCKYCY1EF104Z VCCCCY1HH270J VCCCCY1HH560J VCKYCY1EF104Z VCEAPF0JN107M VCCCCY1HH270J VCCCCY1HH100D VCCCCY1HH100D VCEAPW1CN107M VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1HN105M VCKYCY1HB103K VCEAPF1HW105M VCKYCY1EF104Z RC-EZ0538CEZZ VCEASH0JN227MY VCKYCY1HB103K VCKYCY1EF104Z VCEAPF1CW476M VCKYCY1EF104Z VCEAPF1CW476M VCKYCY1EF104Z VCCCCY1HH221J VCCCCY1HH821JY VCKYCY1HB392K VCKYCY1HB122K VCCCCY1HH121J VCKYCY1HB103K VCEAPF1CW226M VCEAPF1CW106M VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CW106M VCEAPF1CW106M VCEAPF1CW226M VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CW476M VCKYCY1EF104Z VCEAPF1HW475M VCEAPF1AW336M VCEAPF1CW107M VCKYCY1EF104Z VCCCCY1HH151J
Mark No.
C651 C652 C653 C654 C801 C802 C803 C804 C805 C807 C808 C809 C810 C811 C812 C813 C814 C815 C816 C817 C818 C819 C820 C821 C822 C823 C824 C825 C826 C827 C828 C829 C830 C831 C832 C833 C834 C835 C836 C837 C838 C839 C840 C841 C842 C845 C846 C847 C848 C849 C850 C851 C852 C854 C855 C856 C861 C866 C868 C869
Description
120p 50V Ceramic 270p 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 100 6.3V Electrolytic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 4.7 25V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 100 6.3V Electrolytic 9.0p 50V Ceramic 0.01 50V Ceramic 0.47 50V Electrolytic 2.2 50V Electrolytic 0.022 25V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 100 6.3V Electrolytic 0.01 50V Ceramic 0.01 50V Ceramic 10 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 4.7 25V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 0.01 50V Ceramic 9.0p 50V Ceramic 0.01 50V Ceramic 0.47 50V Electrolytic 0.1 25V Ceramic 2.2 50V Electrolytic 0.022 25V Ceramic 0.01 50V Ceramic 1.0 50V Electrolytic 1.0 50V Electrolytic 1.0 50V Electrolytic 0.1 25V Ceramic 470 16V Electrolytic 220 6.3V Electrolytic 220 6.3V Electrolytic 220 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic
Part No.
VCCCCY1HH121J VCCCCY1HH271J VCKYCY1HB103K VCKYCY1EF104Z VCKYTV1EB104K VCKYCY1EF104Z VCKYCY1HB103K VCEAPF0JN107M VCKYCY1HB103K VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCEAPF1EN475MY VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYCY1HB103K VCAAPF0JJ107MY VCCCCY1HH9R0DY VCKYCY1HB103K VCEAPF1HN474M VCEAPF1HN225MY VCKYCY1EB223KY VCKYCY1HB103K VCKYTV1EB104K VCKYCY1EF104Z VCKYTV1EB104K VCKYCY1HB103K VCEAPF0JN107M VCKYCY1HB103K VCKYCY1HB103K VCEAPF1CN106M VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCEAPF1EN475MY VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCAAPF0JJ107MY VCKYCY1HB103K VCCCCY1HH9R0DY VCKYCY1HB103K VCEAPF1HN474M VCKYCY1EF104Z VCEAPF1HN225MY VCKYCY1EB223KY VCKYCY1HB103K VCEAPF1HN105M VCEAPF1HN105M VCEAPF1HN105M VCKYCY1EF104Z VCEASK1CN477MY VCEAPF0JW227MY VCEAPF0JW227MY VCEAPF0JW227MY VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1HB103K VCKYCY1EF104Z
78
1 2
PDP-R03U
3 4
Mark No.
C870 C871 C872 C873 C874 C875 C876 C877 C878 C879 C880 C881 C882 C883 C884 C885 C886 C887 C888 C890 C891 C892 C893 C894 C895 C896 C897 C898 C899 C900 C901 C902 C903 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C924 C925 C926 C927 C928 C929 C930 C931 C932 C933 C934 C935 C936 C937 C938
Description
0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 2200p 50V Ceramic 0.47 16V Ceramic 0.47 16V Ceramic 22 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 22 16V Electrolytic 22 16V Electrolytic 22 16V Electrolytic 39p 50V Ceramic 10 16V Electrolytic 0.47 16V Ceramic Ceramic 47 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 47 6.3V Electrolytic 100 6.3V Electrolytic 0.1 25V Ceramic 1.0 50V Electrolytic 0.1 25V Ceramic 0.47 50V Electrolytic 0.47 50V Electrolytic 39 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 47 16V Electrolytic 47 16V Electrolytic 0.1 25V Ceramic 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 22 16V Electrolytic 220 6.3V Electrolytic 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic
Part No.
VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1HB222K VCKYTV1CB474K VCKYTV1CB474K VCEAPF1CN226MY VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCEAPF1CW226M VCEAPF1CW226M VCEAPF1CW226M VCCCCY1HH390J VCEAPF1CN106M VCKYTV1CB474K RC-KZ1025CEZZ VCEAPF0JN476MY VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYCY1EF104Z VCEAPF0JN476MY VCEAPF0JN107M VCKYCY1EF104Z VCEAPF1HN105M VCKYCY1EF104Z VCEAPF1HN474M VCEAPF1HN474M VCAAPF1CJ396MY VCKYCY1EF104Z VCKYCY1EF104Z VCKYTV1EB104K VCKYTV1EB104K VCKYTV1EB104K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CN476MY VCEAPF1CN476MY VCKYCY1EF104Z VCEAPF1CN106M VCEAPF1CN106M VCKYCY1EF104Z VCEAPF1CN226MY VCEASH0JN227MY VCEAPF1CN106M VCEAPF1CN106M VCKYCY1EF104Z
Mark No.
C944 C950 C951 C952 C953 C954 C1502 C1503 C1504 C1505 C1506 C1511 C1512 C1701 C1702 C1703 C1704 C1705 C1706 C1707 C1709 C1711 C1712 C1713 C1714 C1715 C1717 C1718 C1719 C1720 C1721 C1722 C1724 C1725 C1727 C1728 C1729 C1731 C1732 C1733 C1734 C1735 C1736 C1737 C1738 C1740 C1741 C1742 C1743 C1744 C1745 C1746 C1748 C1749 C1750 C1751 C1752 C1753 C1754 C1755
Description
Capacitor 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 47 16V Electrolytic 47 16V Electrolytic 0.1 25V Ceramic 1.0 16V Ceramic 330 16V Electrolytic 22 16V Electrolytic 0.1 25V Ceramic 100p 50V Ceramic 0.47 16V Ceramic 1.0 16V Ceramic 0.22 16V Ceramic 0.1 25V Ceramic 0.1 16V Ceramic 0.01 50V Ceramic 1.0 16V Ceramic 2200p 50V Ceramic 2200p 50V Ceramic 0.33 16V Ceramic 100 16V Electrolytic 2200p 50V Ceramic 2200p 50V Ceramic 0.33 16V Ceramic 100 16V Electrolytic 0.1 25V Ceramic 1.0 16V Ceramic 39 16V Electrolytic 82 16V Electrolytic 220 6.3V Electrolytic 0.1 25V Ceramic 470 16V Electrolytic 0.33 16V Ceramic 100 16V Electrolytic 470 16V Electrolytic 39 16V Electrolytic 82 16V Electrolytic 330 4.0V Electrolytic 1000p 50V Ceramic 0.33 16V Ceramic 100 16V Electrolytic 1000p 50V Ceramic 1000p 50V Ceramic 1.0 16V Ceramic 1000p 50V Ceramic 0.33 16V Ceramic 100 16V Electrolytic 330 16V Electrolytic 5600p 50V Ceramic 82 16V Electrolytic 5600p 50V Ceramic 100 50V Electrolytic 0.1 50V Ceramic
Part No.
RC-KZ1025CEZZ VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF0JN107M VCEAPF1CW476M VCEAPF1CW476M VCKYCY1EF104Z VCKYTV1CF105Z VCEASH1CN337MY VCEAPF1CW226M VCKYCY1EF104Z VCCCCY1HH101J VCKYCY1CF474Z VCKYTV1CF105Z VCKYTV1CF224Z VCKYCY1EF104Z VCKYTV1CF104Z VCKYCY1HB103K VCKYTV1CB105K VCKYCY1HB222K VCKYCY1HB222K VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1HB222K VCKYCY1HB222K VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1EF104Z VCKYTV1CF105Z VCAAPF1CJ396MY VCAAPF1CJ826MY VCAAPF0JJ227MY VCKYCY1EF104Z VCEASK1CN477MY VCKYCY1CF334Z VCEAPF1CN107M VCEASK1CN477MY VCAAPF1CJ396MY VCAAPF1CJ826MY VCAAPF0GJ337MY VCKYCY1HB102K VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1HB102K VCKYCY1HB102K VCKYTV1CF105Z VCKYCY1HB102K VCKYCY1CF334Z VCEAPF1CN107M VCEASH1CN337MY VCKYCY1HB562K VCAAPF1CJ826MY VCKYCY1HB562K VCEASH1HN107MY VCKYTV1HF104Z E D
PDP-R03U
5 6 7 8
79
Mark No.
C1756 C1757 C1758 C1759 C1764 C1765 C1766 C1767 C1768 C1769 C1770 C1771 C1772 C1773 C1774 C1775 C1776 C1777 C1778 C1779 C1780 C1781 C1782 C1783 C1784 C1785 C1787 C1788 C1789 C1790 C1791 C1792 C1793 C1794 C1795 D C1796 C1797 C1798 C1901 C1902 C1903 C1904 C1905 C1906 C1907 E C1908 C1909 C1910 C1911 C7001 C7002 C7003 C7004 C7005 C7006 C7007 C7008 C7009 C7010 C7011
Description
1.0 16V Ceramic 330 16V Electrolytic 1.0 16V Ceramic Capacitor 330 16V Electrolytic 1.0 16V Ceramic Capacitor 1.0 16V Ceramic 330 16V Electrolytic Capacitor 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 470 16V Electrolytic 330 16V Electrolytic 1000p 50V Ceramic 1000p 50V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 39 16V Electrolytic 82 16V Electrolytic 150 10V Electrolytic 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic 0.33 16V Ceramic 100 16V Electrolytic 0.33 16V Ceramic 100 16V Electrolytic 0.33 16V Ceramic 100 16V Electrolytic 1000p 50V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 22p 50V Ceramic 22p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 390p 50V Ceramic 0.1 25V Ceramic 10 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic
Part No.
VCKYTV1CF105Z VCEASH1CN337MY VCKYTV1CF105Z RC-EZ1339CEZZ VCEASH1CN337MY VCKYTV1CF105Z RC-EZ1339CEZZ VCKYTV1CF105Z VCEASH1CN337MY RC-EZ1339CEZZ VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCEASK1CN477MY VCEASK1CN337MY VCKYCY1HB102K VCKYCY1HB102K VCEAPF0JW107M VCKYCY1EF104Z VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCAAPF1CJ396MY VCAAPF1CJ826MY VCAAPF1AJ157MY VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCKYCY1HB102K VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1CF334Z VCEAPF1CN107M VCKYCY1HB102K VCEAPF0JW107M VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF0JW107M VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCCCCY1HH220JY VCCCCY1HH220JY VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCCCCY1HH391JY VCKYCY1EF104Z VCEAPF1CN106M VCKYCY1EF104Z VCKYCY1EF104Z
Mark No.
C7012 C7013 C7014 C7015 C7016 C7017 C7018 C7019 C7020 C7021 C7022 C7023 C7024 C7025 C7026 C7027 C7028 C7029 C7030 C7031 C7032 C7033 C7034 C7035 C7036 C7037 C7038 C7041 C7042 C7043 C7044 C7045 C7046 C7047 C7048 C7049 C7050 C7051 C7052 C7053 C7054 C7055 C7057 C7058 C7201 C7203 C7204 C7205 C7206 C7207 C7208 C7209 C7210 C7221
Description
0.47 50V Electrolytic 0.01 50V Ceramic 0.1 25V Ceramic 470p 50V Ceramic 0.33 50V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 10 16V Electrolytic 0.1 25V Ceramic 100p 50V Ceramic 1.0 50V Elect.(N.P) 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1.0p 50V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 47 16V Electrolytic 10p 50V Ceramic 27p 50V Ceramic 10p 50V Ceramic 10p 50V Ceramic 27p 50V Ceramic 10p 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 100 6.3V Electrolytic Capacitor 100 6.3V Electrolytic 100 6.3V Electrolytic 0.1 25V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 33p 50V Ceramic 33p 50V Ceramic 33p 50V Ceramic 33p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic
Part No.
VCEAPF1HN474M VCKYCY1HB103K VCKYCY1EF104Z VCCCCY1HH471JY VCEAPF1HN334MY VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CN106M VCKYCY1EF104Z VCCCCY1HH101J VCE9PF1HW105MY VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCCCCY1HH1R0CY VCKYTV1CB105K VCKYTV1CB105K VCKYCY1EF104Z VCAAPF0JJ107MY VCKYCY1EF104Z VCEAPF1CN476MY VCCCCY1HH100D VCCCCY1HH270J VCCCCY1HH100D VCCCCY1HH100D VCCCCY1HH270J VCCCCY1HH100D VCKYCY1HB103K VCKYCY1HB103K VCEAPF0JN107M RC-EZ0416CEZZY VCEAPF0JN107M VCEAPF0JN107M VCKYCY1EF104Z VCEAPF0JN107M VCKYCY1EF104Z VCKYCY1EF104Z VCCCCY1HH330J VCCCCY1HH330J VCCCCY1HH330J VCCCCY1HH330J VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF0JW107M
RESISTOR
F R403 R405 R406 R409 R410 470 1/16W Metal Oxide 220 1/16W Metal Oxide 390 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 2.7k 1/16W Metal Oxide VRS-CY1JF471F VRS-CY1JF221F VRS-CY1JF391F VRS-CY1JF102F VRS-CY1JF272F
80
1 2
PDP-R03U
3 4
Mark No.
R411 R412 R413 R414 R415 R416 R420 R421 R422 R423 R424 R425 R435 R436 R437 R439 R440 R441 R444 R445 R446 R447 R448 R449 R450 R451 R452 R453 R454 R455 R459 R481 R528 R529 R530 R531 R536 R607 R608 R609 R610 R611 R612 R613 R614 R615 R620 R621 R622 R623 R624 R625 R626 R627 R628 R629 R630 R631 R632 R633
Description
3.3k 1/16W Metal Oxide 560 1/16W Metal Oxide 56k 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 27k 1/16W Metal Oxide 27k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 330 1/16W Metal Oxide 360 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 330 1/16W Metal Oxide 330 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 330 1/16W Metal Oxide 390 1/16W Metal Oxide 560 1/16W Metal Oxide 390 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 910 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 12k 1/16W Metal Oxide 12k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 390 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 47 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 330 1/16W Metal Oxide 470 1/16W Metal Oxide 1.2k 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 47 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 470 1/16W Metal Oxide 100 1/16W Metal Oxide 330 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 5
Part No.
VRS-CY1JF332F VRS-CY1JF561J VRS-CY1JF563J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF273J VRS-CY1JF273J VRS-CY1JF102J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF331J VRS-CY1JF361J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF331J VRS-CY1JF331J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF331J VRS-CY1JF391J VRS-CY1JF561J VRS-CY1JF391J VRS-CY1JF222J VRS-CY1JF911J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF332J VRS-CY1JF123J VRS-CY1JF123J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF391J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF332J VRS-CY1JF470J VRS-CY1JF332J VRS-CY1JF331J VRS-CY1JF471F VRS-CY1JF122J VRS-CY1JF332J VRS-CY1JF102J VRS-CY1JF470J VRS-CY1JF332J VRS-CY1JF471J VRS-CY1JF101J VRS-CY1JF331J VRS-CY1JF682J 6
Mark No.
R634 R635 R636 R637 R638 R639 R640 R641 R642 R643 R644 R646 R647 R648 R649 R650 R651 R652 R653 R654 R655 R656 R658 R659 R661 R664 R665 R666 R667 R668 R669 R670 R671 R672 R675 R676 R677 R678 R679 R680 R681 R682 R683 R684 R685 R699 R800 R801 R802 R803 R805 R807 R808 R809 R811 R812 R813 R816 R817 R818
Description
1.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 820 1/16W Metal Oxide 15k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 47 1/16W Metal Oxide 680 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 47 1/16W Metal Oxide 330 1/16W Metal Oxide 100 1/16W Metal Oxide 18k 1/16W Metal Oxide 47 1/16W Metal Oxide 5.1k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 470 1/16W Metal Oxide 220 1/16W Metal Oxide 15k 1/16W Metal Oxide 5.1k 1/16W Metal Oxide 47 1/16W Metal Oxide 1.2k 1/16W Metal Oxide 680 1/16W Metal Oxide 300 1/16W Metal Oxide 1.2k 1/16W Metal Oxide 820 1/16W Metal Oxide 47 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 0 1/16W Metal Oxide 0 1/16W Metal Oxide 33k 1/16W Metal Oxide 22k 1/16W Metal Oxide 47 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 470 1/16W Metal Oxide 10k 1/16W Metal Oxide 330 1/16W Metal Oxide 47k 1/16W Metal Oxide 18k 1/16W Metal Oxide 47 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 0 1/16W Metal Oxide 0 1/16W Metal Oxide 560 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 27k 1/16W Metal Oxide 3.9k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 27k 1/16W Metal Oxide 100 1/16W Metal Oxide 3.9k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 7
Part No.
VRS-CY1JF182J VRS-CY1JF101J VRS-CY1JF821J VRS-CY1JF153J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF182J VRS-CY1JF682J VRS-CY1JF470J VRS-CY1JF681J VRS-CY1JF222J VRS-CY1JF470J VRS-CY1JF331J VRS-CY1JF101J VRS-CY1JF183J VRS-CY1JF470J VRS-CY1JF512J VRS-CY1JF682J VRS-CY1JF471J VRS-CY1JF221J VRS-CY1JF153J VRS-CY1JF512J VRS-CY1JF470J VRS-CY1JF122J VRS-CY1JF681J VRS-CY1JF301F VRS-CY1JF122J VRS-CY1JF821J VRS-CY1JF470J VRS-CY1JF332J VRS-CY1JF222J VRS-CY1JF222J VRS-CY1JF000J VRS-CY1JF000J VRS-CY1JF333J VRS-CY1JF223J VRS-CY1JF470J VRS-CY1JF222J VRS-CY1JF471J VRS-CY1JF103J VRS-CY1JF331J VRS-CY1JF473J VRS-CY1JF183J VRS-CY1JF470J VRS-CY1JF222J VRS-CY1JF000J VRS-CY1JF000J VRS-CY1JF561J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF273J VRS-CY1JF392J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF273J VRS-CY1JF101J VRS-CY1JF392J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J F E
PDP-R03U
8
81
Mark No.
R819 R820 R821 R822 R830 R831 R832 R833 R834 R835 R836 R837 R841 R842 R844 R846 R847 R850 R851 R854 R855 R856 R857 R858 R859 R864 R865 R866 R867 R868 R869 R873 R874 R875 R876 R877 R886 R891 R892 R894 R896 R898 R899 R900 R901 E R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 F R912 R913 R914 R915 R923
Description
10k 1/16W Metal Oxide 75 1/8W Metal Oxide 75 1/8W Metal Oxide 75 1/8W Metal Oxide 680 1/16W Metal Oxide 470 1/16W Metal Oxide 47k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 47 1/16W Metal Oxide 47 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 47 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 47 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 47 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 3.3M 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 10k 1/16W Metal Oxide 22k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 18k 1/16W Metal Oxide 22k 1/16W Metal Oxide 18k 1/16W Metal Oxide 22k 1/16W Metal Oxide 18k 1/16W Metal Oxide 22k 1/16W Metal Oxide 56 1/16W Metal Oxide 150 1/8W Metal Oxide 470 1/16W Metal Oxide 180 1/16W Metal Oxide 470 1/16W Metal Oxide 4.3k 1/16W Metal Oxide 150 1/8W Metal Oxide 1.5k 1/16W Metal Oxide 56 1/16W Metal Oxide 56 1/16W Metal Oxide 1
Part No.
VRS-CY1JF103J VRS-TQ2BD750J VRS-TQ2BD750J VRS-TQ2BD750J VRS-CY1JF681J VRS-CY1JF471J VRS-CY1JF473F VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF470J VRS-CY1JF470J VRS-CY1JF102J VRS-CY1JF470J VRS-CY1JF562J VRS-CY1JF682J VRS-CY1JF470J VRS-CY1JF102J VRS-CY1JF470J VRS-CY1JF102J VRS-CY1JF472J VRS-CY1JF335J VRS-CY1JF102J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF000J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF472J VRS-CY1JF472J VRS-CY1JF472J VRS-CY1JF103J VRS-CY1JF223F VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF222J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF222J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF183J VRS-CY1JF223J VRS-CY1JF183J VRS-CY1JF223J VRS-CY1JF183J VRS-CY1JF223J VRS-CY1JF560J VRS-TQ2BD151J VRS-CY1JF471J VRS-CY1JF181J VRS-CY1JF471J VRS-CY1JF432J VRS-TQ2BD151J VRS-CY1JF152J VRS-CY1JF560J VRS-CY1JF560J
Mark No.
R924 R925 R926 R927 R928 R929 R930 R931 R932 R933 R934 R935 R936 R937 R938 R939 R940 R941 R942 R943 R944 R945 R946 R947 R948 R949 R950 R951 R952 R953 R954 R955 R956 R957 R958 R959 R960 R961 R962 R963 R964 R965 R966 R967 R968 R969 R970 R971 R972 R973 R974 R975 R976 R977 R978 R979 R980 R981 R982 R983
Description
6.8k 1/16W Metal Oxide 10k 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 56 1/16W Metal Oxide 56 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 820 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 47 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 47 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 22k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 47 1/16W Metal Oxide 11k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 47 1/16W Metal Oxide 1.0M 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 10k 1/16W Metal Oxide 8.2k 1/16W Metal Oxide 33k 1/16W Metal Oxide 56 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 3
Part No.
VRS-CY1JF682J VRS-CY1JF103J VRS-CY1JF332J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF560J VRS-CY1JF560J VRS-CY1JF102J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF821J VRS-CY1JF102J VRS-CY1JF470J VRS-CY1JF472J VRS-CY1JF470J VRS-CY1JF472J VRS-CY1JF223J VRS-CY1JF472J VRS-CY1JF470J VRS-CY1JF113F VRS-CY1JF682F VRS-CY1JF152F VRS-CY1JF470J VRS-CY1JF105J VRS-CY1JF472J VRS-CY1JF472J VRS-CY1JF103J VRS-CY1JF822J VRS-CY1JF333F VRS-CY1JF560J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J 4
82
2
PDP-R03U
Mark No.
R984 R987 R988 R989 R990 R991 R992 R993 R994 R995 R996 R997 R998 R999 R1501 R1502 R1503 R1504 R1505 R1506 R1507 R1515 R1516 R1517 R1518 R1519 R1521 R1522 R1524 R1525 R1529 R1530 R1531 R1533 R1534 R1535 R1538 R1539 R1544 R1545 R1550 R1551 R1564 R1565 R1567 R1568 R1569 R1570 R1571 R1572 R1573 R1594 R1596 R1701 R1702 R1706 R1707 R1708 R1709 R1711
Description
22k 1/16W Metal Oxide 330 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 120 1/16W Metal Oxide 39k 1/16W Metal Oxide 47 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 56 1/16W Metal Oxide 56 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 390 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 47k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 22k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10k 1/16W Metal Oxide 390 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 22k 1/16W Metal Oxide 68k 1/16W Metal Oxide 2.7k 1/16W Metal Oxide 33k 1/16W Metal Oxide 27k 1/16W Metal Oxide 39k 1/16W Metal Oxide 10 1/4W Metal Oxide 100 1/16W Metal Oxide 5
Part No.
VRS-CY1JF223J VRS-CY1JF331F VRS-CY1JF102F VRS-CY1JF121FY VRS-CY1JF393F VRS-CY1JF470J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF560J VRS-CY1JF560J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF391J VRS-CY1JF102J VRS-CY1JF472J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF473J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF223J VRS-CY1JF102J VRS-CY1JF103J VRS-CY1JF391J VRS-CY1JF102J VRS-CY1JF473J VRS-CY1JF473J VRS-CY1JF473J VRS-CY1JF473J VRS-CY1JF473J VRS-CY1JF473J VRS-CY1JF102J VRS-CY1JF223J VRS-CY1JF683J VRS-CY1JF272J VRS-CY1JF333J VRS-CY1JF273J VRS-CY1JF393J VRS-TW2ED100J VRS-CY1JF101J 6
Mark No.
R1712 R1713 R1714 R1718 R1719 R1721 R1722 R1724 R1726 R1727 R1728 R1736 R1743 R1744 R1745 R1746 R1747 R1751 R1753 R1756 R1763 R1764 R1765 R1766 R1767 R1774 R1775 R1776 R1777 R1778 R1779 R1780 R1781 R1782 R1783 R1784 R1785 R1786 R1788 R1790 R1791 R1792 R1794 R1901 R1902 R1905 R1906 R1907 R1911 R1913 R1915 R1916 R1917 R1920 R1921 R1922 R1923 R1926 R1927 R1928
Description
100 1/16W Metal Oxide 100 1/16W Metal Oxide 10k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 12 1/4W Metal Oxide 3.3k 1/16W Metal Oxide 330 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 47k 1/16W Metal Oxide 470 1/4W Metal Oxide 10k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 12 1/4W Metal Oxide 2.7k 1/16W Metal Oxide 330 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 12k 1/16W Metal Oxide 22k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 560 1/16W Metal Oxide 30k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 39k 1/16W Metal Oxide 47k 1/16W Metal Oxide 10k 1/16W Metal Oxide 12 1/4W Metal Oxide 1.0k 1/16W Metal Oxide 12k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 0 1/16W Metal Oxide 820 1W Metal Oxide 68k 1/8W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 7
Part No.
VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF103J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF472J VRS-TW2ED120J VRS-CY1JF332F VRS-CY1JF331F VRS-CY1JF152F VRS-CY1JF473F VRS-TW2ED471J VRS-CY1JF103J VRS-CY1JF472J VRS-TW2ED120J VRS-CY1JF272F VRS-CY1JF331F VRS-CY1JF182F VRS-CY1JF123F VRS-CY1JF223J VRS-CY1JF102F VRS-CY1JF561F VRS-CY1JF303F VRS-CY1JF472F VRS-CY1JF393F VRS-CY1JF473J VRS-CY1JF103J VRS-TW2ED120J VRS-CY1JF102F VRS-CY1JF123J VRS-CY1JF472J VRS-CY1JF000J VRS-CR3AD821J VRS-TQ2BD683J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J F E
PDP-R03U
8
83
Mark No.
R1929 R1930 R1931 R1932 R1933 R1934 R1935 R1936 R1937 R1938 R1941 R1942 R1943 R1944 R7001 R7002 R7003 R7004 R7005 R7006 R7007 R7008 R7009 R7010 R7011 R7012 R7013 R7014 R7015 R7016 R7017 R7018 R7019 R7020 R7021 R7023 R7027 R7028 R7031 R7034 R7035 R7036 R7037 R7038 R7039 E R7040 R7041 R7042 R7043 R7044 R7045 R7046 R7049 R7050 R7201 F R7202 R7203 R7205 R7206 R7207
Description
10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 470 1/16W Metal Oxide 470 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 33k 1/16W Metal Oxide 270 1/16W Metal Oxide 270 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 470 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 47k 1/16W Metal Oxide 220k 1/16W Metal Oxide 220 1/16W Metal Oxide 0 1/8W Metal Oxide 100 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 0 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 910 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 910 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 1.5k 1/16W Metal Oxide 2.2 1/2W Metal Oxide 2.2 1/2W Metal Oxide 47 1/16W Metal Oxide 620 1/16W Metal Oxide 1.0M 1/16W Metal Oxide 220 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1
Part No.
VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF471J VRS-CY1JF471J VRS-CY1JF102J VRS-CY1JF333J VRS-CY1JF271J VRS-CY1JF271J VRS-CY1JF182J VRS-CY1JF182J VRS-CY1JF472J VRS-CY1JF471J VRS-CY1JF102J VRS-CY1JF222J VRS-CY1JF473J VRS-CY1JF224J VRS-CY1JF221J VRS-TQ2BD000J VRS-CY1JF101J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF102J VRS-CY1JF000J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF911J VRS-CY1JF152J VRS-CY1JF152J VRS-CY1JF222J VRS-CY1JF102J VRS-CY1JF911J VRS-CY1JF152J VRS-CY1JF152J VRS-TX2HF2R2JY VRS-TX2HF2R2JY VRS-CY1JF470J VRS-CY1JF621JY VRS-CY1JF105J VRS-CY1JF221J VRS-CY1JF562J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J
Mark No.
R7208 R7209 R7210 R7211 R7215 R7216 R7217 R7224 R7225 R7237
Description
1.0k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 100 1/16W Metal Oxide
Part No.
VRS-CY1JF102J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF103J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF332J VRS-CY1JF101J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF102J
R7238 10k 1/16W Metal Oxide R7239 10k 1/16W Metal Oxide R7240 1.0k 1/16W Metal Oxide
MISCELLANEOUS PARTS
F1702 FB401 FB601 FB602 FB603 FB801 FB802 FB803 FB1701 FB1702 FB1703 FB1704 FB1705 FB1706 FB1707 FB1709 FB1710 FB1711 FB1712 FB1713 FB1714 FB1715 FB1716 FB1717 FB1718 FB1719 FB1720 FB1721 FB1722 FB1723 FB1724 FB1725 FB1727 FB1728 FB1729 FB1730 FB1731 FB1732 FB1733 FB1734 FB1735 FB1736 FB1737 FB1740 FB1741 Fuse 4A Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead QFS-D0011CEZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0051TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0006TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ
84
2
PDP-R03U
3 4
Mark No.
FB1742 FB1744 FB1745 FB1746 FB1747 FB1748 FB1749 FB1750 FB1751 FB1752 FB1901 FB1902 FB7001 FB7002 FB7003 FB7004 FB7005 FB7006 FB7007 FB7008
Description
Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead
Part No.
RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0210TAZZ RBLN-0060TAZZ RBLN-0060TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0059CEZZY RBLN-0059CEZZY RBLN-0059CEZZY RBLN-0059CEZZY RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0061TAZZ QFSHD1002CEZZ QFSHD1002CEZZ QPLGN0056CEZZY QPLGN0549FJZZY QPLGN0060CEZZY QPLGN0550FJZZY QPLGN0062CEZZY QPLGN1094CEZZ QSOCN0490FJZZ QSOCN0464FJZZ QSOCN0550FJZZY QSOCN0490FJZZ QCNW-6077CEZZ
Mark No.
Description
Part No.
RFiLN0017TAZZ VP-1M100J1R6N
CAPACITOR
C3401 C3402 C3403 C3404 C3405 C3406 C3407 C3408 C3409 C3410 C3411 C3412 C3414 C3415 C3416 C3417 C3418 C3420 C3421 C3422 C3423 C3426 C3427 C3428 C3429 C3430 C3431 C3432 C3433 C3434 100 6.3V Electrolytic 0.01 50V Ceramic 0.1 25V Ceramic 47 16V Electrolytic 0.01 50V Ceramic 10 16V Electrolytic 0.01 50V Ceramic 10 16V Electrolytic 0.01 50V Ceramic 10 16V Electrolytic 10 16V Electrolytic 10 16V Electrolytic 10p 50V Ceramic 10 16V Electrolytic 0.1 25V Ceramic 10p 50V Ceramic 10 16V Electrolytic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 10 25V Electrolytic 10 25V Electrolytic 100p 50V Ceramic 100p 50V Ceramic 56p 50V Ceramic 56p 50V Ceramic 100p 50V Ceramic 1000p 50V Ceramic 1000p 50V Ceramic VCEAPF0JW107M VCKYCY1HB103K VCKYCY1EF104Z VCEAPF1CW476M VCKYCY1HB103K VCEAPF1CN106M VCKYCY1HB103K VCEAPF1CN106M VCKYCY1HB103K VCEAPF1CN106M VCEAPF1CN106M VCEAPF1CN106M VCCCCY1HH100D VCEAPF1CN106M VCKYCY1EF104Z VCCCCY1HH100D VCEAPF1CN106M VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K C VCKYCY1EF104Z VCEAPW1EN106M VCEAPW1EN106M VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH560J VCCCCY1HH560J VCCCCY1HH101J VCKYCY1HB102K VCKYCY1HB102K VCCCCY1HH101J VCKYCY1HB102K VCKYCY1HB102K D
FB7201 Ferrite Bead FB7203 Ferrite Bead FH1703 Fuse Holder FH1704 Fuse Holder P801 Plug 6-Pin P1502 P1504 P1702 P1703 P1901 Plug 12-Pin Plug 10-Pin Plug 13-Pin Plug 12-Pin Plug
SC1501 Socket 30-Pin SC1502 Socket 50-Pin SC1503 Socket 30-Pin SC1504 Socket 30-Pin Connecting Cord
B FRONT UNIT
IC
IC3401 24LC21T VHi24LC21//-1
C3435 100p 50V Ceramic C3436 1000p 50V Ceramic C3437 1000p 50V Ceramic
RESISTOR
R3401 R3402 R3403 R3404 R3405 R3406 R3407 R3408 R3409 R3410 R3411 R3412 R3413 R3414 R3415 R3416 R3417 R3418 R3422 R3423 560 1/8W Metal Oxide 100 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 10k 1/16W Metal Oxide 560 1/8W Metal Oxide 100 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 10k 1/16W Metal Oxide 560 1/8W Metal Oxide 100 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 100 1/16W Metal Oxide 47k 1/16W Metal Oxide 47k 1/16W Metal Oxide 75 1/4W Metal Oxide 75 1/4W Metal Oxide VRS-TQ2BD561J VRS-CY1JF101J VRS-CY1JF562J VRS-CY1JF103J VRS-TQ2BD561J VRS-CY1JF101J VRS-CY1JF562J VRS-CY1JF103J VRS-TQ2BD561J VRS-CY1JF101J VRS-CY1JF562J VRS-CY1JF103J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF222J VRS-CY1JF101J VRS-CY1JF473J VRS-CY1JF473J VRS-TW2ED750J VRS-TW2ED750J VRS-TW2ED750J
TRANSISTOR
Q3401 2SC2735 Q3402 2SC2735 Q3403 2SC2735 VS2SC2735//1E VS2SC2735//1E VS2SC2735//1E
DIODE
D3401 D3402 D3403 D3404 D3405 D3406 D3407 D3408 D3409 Zener Diode Diode Diode Diode Zener Diode Zener Diode Zener Diode Zener Diode Diode RH-EX1264CEZZ VHDMA3120WA-1 VHDMA3120WA-1 VHDMA3120WA-1 RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1271CEZZ RH-EX1271CEZZ VHDDAN222//-1
FILTER, COIL
FL3401 FL3402 FL3403 FL3412 FL3413 Filter Filter Filter Filter Filter 5 RFiLN0003TAZZ RFiLN0003TAZZ RFiLN0003TAZZ RFiLN0017TAZZ RFiLN0017TAZZ 6
PDP-R03U
7 8
85
Mark No.
R3425 R3427 R3428 R3429 R3430 R3431 R3432 R3433 R3434 R3435 R3436 R3437 R3439 R3440 R3441 R3442 R3443 R3444 R3445 R3446 R3447 R3448 R3449 R3450 C R3451 R3453 R3454 R3455 R3456
Description
100 1/16W Metal Oxide 0 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 75 1/8W Metal Oxide 100 1/16W Metal Oxide 75 1/4W Metal Oxide 10k 1/16W Metal Oxide 270k 1/16W Metal Oxide 75 1/8W Metal Oxide 47 1/16W Metal Oxide 47 1/16W Metal Oxide 47 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100 1/16W Metal Oxide 4.7 1/4W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 4.7 1/4W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide
Part No.
VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF104J VRS-CY1JF104J VRS-TQ2BD750J VRS-CY1JF101J VRS-TW2ED750J VRS-CY1JF103J VRS-CY1JF274F VRS-TQ2BD750J VRS-CY1JF470J VRS-CY1JF470J VRS-CY1JF470J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF101J VRS-TW2ED4R7J VRS-CY1JF102J VRS-CY1JF102J VRS-TW2ED4R7J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF222J VRS-CY1JF222J VRS-TV1JD102J VRS-TV1JD102J
Mark No.
Description
Part No.
VHiZ86230S+-1Y VHiZ86129S+-1Y VHiZ86230S+-1Y RH-IX3370CEN1Q VHiPST529DM-1 VHiNJ2233BM-1Y VHiNJ2233BM-1Y
IC1601 Z8623012SSC IC1602 Z8612912SSC IC1603 Z8623012SSC IC2501 IC2503 IC2504 IC2505 MSP3440G-QA-B8 PST529DMT NJM2233BM NJM2233BM
TRANSISTOR
Q1101 Q1102 Q1103 Q1104 Q1105 Q1106 Q1107 Q1108 Q1111 Q1112 Q1401 Q1402 Q1403 Q1405 Q1406 Q1407 Q1581 Q1582 Q1601 Q1602 Q2502 Q2503 Q2504 Q2505 Q2506 2SC3928AR DTC314TK DTC314TK 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR 2SC3928AR 2SC3928AR 2SA1530AR 2SC3928AR 2SC3928AR 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1298Y(PDP-R03T) DTC144TE(PDP-R03T) 2SC3928AR 2SC3928AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR 2SA1530AR VS2SC3928AR-1 VSDTC314TK/-1 VSDTC314TK/-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1298Y/-1Y VSDTC144TE/-1Y VS2SC3928AR-1 VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VSDTA144EE/-1 VSDTC144EE/-1
SWITCH
SW3401Switch QSW-K0069CEZZ
MISCELLANEOUS PARTS
D FB3401 FB3402 FB3403 FB3404 FB3405 FB3406 FB3407 FB3408 FB3409 J3401 Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Jack 3-RCA/DIN RBLN-0076TAZZ RBLN-0060TAZZ RBLN-0060TAZZ RBLN-0060TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ QJAKZ0102PEZZ QJAKJ0047CEZZ QPLGN1278GEZZ QPLGN0428FJZZ QSOCN1594CEZZ
DIODE
D1101 D1102 D1103 D1104 D1110 D1301 D1302 D1303 D1304 D1305 D1306 D1307 D1308 D1309 D1310 D1311 D1312 D1313 D1401 D1402 Zener Diode Zener Diode Diode Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Zener Diode Diode Diode RH-EX1264CEZZ RH-EX1264CEZZ VHDHSU119//-1 VHDHSU119//-1 RH-EX0207CEZZY RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ RH-EX1264CEZZ VHDMA157A//-1 VHDMA157A//-1 VHDMA157A//-1 VHDMA157A//-1 VHDMA157A//-1
J3403 Jack (PC-SIN) P3401 Plug 12-Pin P3402 Plug 18-Pin SC3401 Socket 15-Pin D-sub
C AV UNIT
TUNER
TU1101 Tuner TU1102 Tuner VTUVT2U5UW253 VTUVT2U5UF253
IC
IC1101 IC1102 IC1103 IC1104 IC1105 BA05FP M62320FP BA05FP MM1506XNRE MM1506XNRE VHiBA05FP++-1Y VHiM62320FP-1 VHiBA05FP++-1Y VHiMM1506XN-1 VHiMM1506XN-1 VHiCXA2069Q-1 VHiMM1519XQ-1
86
1 2
PDP-R03U
3 4
Mark No.
D1411 Diode D1412 Diode D1413 D1581 D1582 D1583 D2502 D2503 D2504 D2505 D2506
Description
Part No.
VHDMA157A//-1 VHDMA157A//-1 VHDMA157A//-1 VHDHSU119//-1 VHDHSU119//-1 VHDHSU119//-1 VHDDAN222//-1 VHD1SS250//1E VHD1SS250//1E VHDMA157A//-1 VHDHSU119//-1
Mark No.
C1111 C1112 C1113 C1114 C1115 C1116 C1119 C1120 C1121 C1122 C1123 C1124 C1125 C1126 C1127 C1128 C1129 C1130 C1131 C1132 C1133 C1134 C1135 C1136 C1137 C1138 C1139 C1140 C1141 C1142 C1143 C1144 C1145 C1146 C1147 C1148 C1149 C1150 C1151 C1152 C1153 C1154 C1155 C1156 C1157 C1158 C1159 C1160 C1161 C1162 C1164 C1165 C1166 C1167 C1168 C1169 C1170 C1171 C1172 C1173
Description
1000p 50V Ceramic 0.1 25V Ceramic 10 16V Elect.(N.P) 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 1.0 16V Ceramic 470 16V Electrolytic 1.0 16V Ceramic 10 16V Electrolytic 1.0 16V Ceramic 1.0 16V Ceramic 10 16V Electrolytic 1.0 16V Ceramic 1.0 16V Ceramic 10 16V Electrolytic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 470 16V Electrolytic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 33p 50V Ceramic 33p 50V Ceramic 10 16V Electrolytic 10 16V Electrolytic 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 0.01 50V Ceramic 220 6.3V Electrolytic 0.01 50V Ceramic 100 6.3V Electrolytic 39 16V Electrolytic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic
Part No.
VCKYCY1HB102K VCKYCY1EF104Z VCE9PF1CW106M VCKYCY1EF104Z VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1EF104Z VCKYCY1HB103K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1EF104Z VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K VCKYCY1EF104Z VCKYTV1CB105K VCEAPW1CN477M VCKYTV1CB105K VCEAPF1CW106M VCKYTV1CB105K VCKYTV1CB105K VCEAPF1CW106M VCKYTV1CB105K VCKYTV1CB105K VCEAPF1CW106M VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCEAPW1CN477M VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCCCCY1HH330J VCCCCY1HH330J VCEAPF1CW106M VCEAPF1CW106M VCEAPF1CW106M VCEAPF1CW106M VCKYCY1EF104Z VCKYCY1HB103K VCAAPF0JJ227MY VCKYCY1HB103K VCAAPF0JJ107MY VCAAPF1CJ396MY VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J E D
PACKAGED CIRCUIT
X1601 Crystal X1602 Crystal X2501 Crystal RCRSCA005WJZZY RCRSCA005WJZZY RCRSB0250GEZZ
FILTER, COIL
FL1101 FL1102 FL1103 FL1104 FL1105 FL1106 FL1107 FL1108 FL1109 FL1110 FL1111 FL1112 FL1113 FL1114 FL1115 FL1116 FL1117 FL1118 FL1119 FL1120 FL1121 L1101 L1102 L1401 L2501 L2502 L2503 L2504 Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Filter Peaking 4.7H Peaking 4.7H Peaking 10H Peaking 100H Peaking 4.7H Peaking 100H Peaking 4.7H RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0017TAZZ RFiLN0003TAZZ RFiLN0003TAZZ RFiLN0003TAZZ VP-1M4R7J1R2N VP-1M4R7J1R2N VP-1M100J1R6N VP-1M101J7R7N VP-1M4R7J1R2N VP-1M101J7R7N VP-1M4R7J1R2N
CONTROL
R1121 Variable Resistor R1219 Variable Resistor RVR-M7997TAZZ RVR-M7997TAZZ
CAPACITOR
C1101 C1102 C1103 C1104 C1105 C1106 C1107 C1108 C1109 C1110 0.01 50V Ceramic 220 6.3V Electrolytic 0.01 50V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 39 16V Electrolytic 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic VCKYCY1HB103K VCAAPF0JJ227MY VCKYCY1HB103K VCKYCY1EF104Z VCAAPF0JJ107MY VCAAPF1CJ396MY VCKYCY1EF104Z VCKYCY1HB103K VCKYCY1HB103K VCKYCY1HB103K
PDP-R03U
5 6 7 8
87
Mark No.
C1174 C1175 C1176 C1177 C1178 C1179 C1180 C1181 C1182 C1309 C1310 C1311 C1312 C1313 C1314 C1316 C1320 C1321 C1324 C1325 C1326 C1327 C1328 C1401 C1402 C1404 C1406 C1407 C1408 C1409 C1410 C1411 C1412 C1413 C1415 D C1417 C1419 C1420 C1421 C1422 C1434 C1435 C1436 C1581 C1601 E C1602 C1603 C1604 C1605 C1606 C1607 C1608 C1609 C1612 C1614 C1615 C1616 C1617 C1618 C1619
Description
10 16V Electrolytic 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 1000p 50V Ceramic 10 16V Elect.(N.P) 0.1 25V Ceramic 10 50V Electrolytic 0.1 25V Ceramic 0.1 25V Ceramic 22 16V Electrolytic 10 10V Elect.(N.P) 1000p 50V Ceramic 1000p 50V Ceramic 1.0 16V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 0.1 25V Ceramic 0.1 16V Ceramic 0.1 16V Ceramic 0.1 16V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 16V Electrolytic 0.1 16V Ceramic 0.1 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 100 16V Electrolytic 0.1 16V Ceramic 0.1 16V Ceramic 0.1 16V Ceramic 22 16V Electrolytic(PDP-R03T) 0.1 16V Ceramic 27p 50V Ceramic 18p 50V Ceramic 560p 50V Ceramic 0.1 25V Ceramic 0.068 16V Ceramic 6800p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 16V Ceramic 560p 50V Ceramic 0.1 25V Ceramic 0.068 16V Ceramic 6800p 50V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic
Part No.
VCEAPF1CN106M VCEAPF1CN106M VCEAPF1CN106M VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1HB102K VCE9PF1CW106M VCKYCY1EF104Z VCEAPF1HW106MY VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CW226M VCE9PF1AW106M VCKYCY1HB102K VCKYCY1HB102K VCKYTV1CB105K VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCCCCY1HH101J VCKYCY1EF104Z VCKYCY1CB104K VCKYCY1CB104K VCKYCY1CB104K VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCEAPF1CW107M VCKYCY1CB104K VCKYCY1CB104K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1EF104Z VCKYTV1CB105K VCKYTV1CB105K VCEAPF1CW107M VCKYCY1CB104K VCKYCY1CB104K VCKYCY1CB104K VCEAPF1CW226M VCKYCY1CB104K VCCCCY1HH270J VCCCCY1HH180J VCCCCY1HH561JY VCKYCY1EF104Z VCKYCY1CB683KY VCKYCY1HB682KY VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1CB104K VCCCCY1HH561JY VCKYCY1EF104Z VCKYCY1CB683KY VCKYCY1HB682KY VCKYCY1EF104Z VCEAPF0JW107M
Mark No.
C1621 C1622 C1623 C1624 C1625 C1626 C1627 C1628 C1629 C1630 C1640 C1641 C1642 C1643 C1644 C1645 C2501 C2502 C2503 C2512 C2513 C2514 C2515 C2516 C2517 C2518 C2519 C2520 C2521 C2522 C2523 C2524 C2525 C2526 C2527 C2528 C2529 C2530 C2531 C2532 C2533 C2534 C2535 C2536 C2537 C2538 C2539 C2543 C2544 C2545 C2546 C2547 C2548 C2553 C2554
Description
0.1 25V Ceramic 0.1 16V Ceramic 27p 50V Ceramic 18p 50V Ceramic 560p 50V Ceramic 0.1 25V Ceramic 6800p 50V Ceramic 0.068 16V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 150p 50V Ceramic 150p 50V Ceramic 150p 50V Ceramic 150p 50V Ceramic 150p 50V Ceramic 150p 50V Ceramic 0.1 25V Ceramic 100 6.3V Electrolytic 0.1 25V Ceramic 3300p 50V Ceramic 3300p 50V Ceramic 3300p 50V Ceramic 3300p 50V Ceramic 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 100 16V Electrolytic 100 16V Electrolytic 3.3 50V Electrolytic 0.1 25V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 10 16V Electrolytic 1.0 16V Ceramic 100 6.3V Electrolytic 56p 50V Ceramic 0.01 50V Ceramic 56p 50V Ceramic 5.0p 50V Ceramic 5.0p 50V Ceramic 470 6.3V Electrolytic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 1.0 16V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic
Part No.
VCKYCY1EF104Z VCKYCY1CB104K VCCCCY1HH270J VCCCCY1HH180J VCCCCY1HH561JY VCKYCY1EF104Z VCKYCY1HB682KY VCKYCY1CB683KY VCKYCY1EF104Z VCEAPF0JW107M VCCCCY1HH151J VCCCCY1HH151J VCCCCY1HH151J VCCCCY1HH151J VCCCCY1HH151J VCCCCY1HH151J VCKYCY1EF104Z VCEAPF0JW107M VCKYCY1EF104Z VCKYCY1HB332K VCKYCY1HB332K VCKYCY1HB332K VCKYCY1HB332K VCEAPF1CW106M VCEAPF1CW106M VCKYCY1EF104Z VCEAPF1CW107M VCEAPF1CW107M VCEAPF1HW335M VCKYCY1EF104Z VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1EF104Z VCEAPF1CW106M VCKYTV1CB105K VCEAPF0JW107M VCCCCY1HH560J VCKYCY1HB103K VCCCCY1HH560J VCCCCY1HH5R0C VCCCCY1HH5R0C VCEASH0JN477MY VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYTV1CB105K VCKYCY1EF104Z VCKYCY1EF104Z VCKYCY1HB103K VCKYCY1HB103K
RESISTOR
R1104 R1105 R1107 R1110 68 1/16W Metal Oxide 68 1/16W Metal Oxide 0 1/16W Metal Oxide 68k 1/16W Metal Oxide VRS-CY1JF680JY VRS-CY1JF680JY VRS-CY1JF000J VRS-CY1JF683J
88
1 2
PDP-R03U
3 4
Mark No.
R1113 R1114 R1115 R1116 R1117 R1118 R1119 R1120 R1122 R1123 R1124 R1125 R1126 R1127 R1128 R1129 R1130 R1131 R1135 R1136 R1137 R1138 R1139 R1140 R1141 R1142 R1143 R1144 R1145 R1146 R1147 R1148 R1149 R1150 R1151 R1152 R1153 R1154 R1155 R1156 R1157 R1158 R1159 R1160 R1161 R1162 R1163 R1164 R1165 R1166 R1167 R1168 R1169 R1170 R1171 R1172 R1173 R1174 R1175
Description
1.0k 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 470 1/16W Metal Oxide 22k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 10k 1/16W Metal Oxide 270k 1/16W Metal Oxide 75 1/16W Metal Oxide 75 1/8W Metal Oxide 75 1/8W Metal Oxide 10k 1/16W Metal Oxide 270k 1/16W Metal Oxide 75 1/16W Metal Oxide 10k 1/16W Metal Oxide 270k 1/16W Metal Oxide 75 1/16W Metal Oxide 75 1/8W Metal Oxide 68 1/2W Metal Oxide 100k 1/16W Metal Oxide 68 1/2W Metal Oxide 100k 1/16W Metal Oxide 100 1/16W Metal Oxide 75 1/8W Metal Oxide 100 1/16W Metal Oxide 75 1/8W Metal Oxide 100 1/16W Metal Oxide 75 1/8W Metal Oxide 75 1/8W Metal Oxide 220 1/16W Metal Oxide 220 1/16W Metal Oxide 75 1/8W Metal Oxide 220 1/16W Metal Oxide 220 1/16W Metal Oxide 100 1/16W Metal Oxide 75 1/8W Metal Oxide 68 1/2W Metal Oxide 100k 1/16W Metal Oxide 220 1/16W Metal Oxide 270 1/16W Metal Oxide 220k 1/16W Metal Oxide 220 1/16W Metal Oxide 270 1/16W Metal Oxide 220k 1/16W Metal Oxide 560k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 560k 1/16W Metal Oxide 5
Part No.
VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF562J VRS-CY1JF101J VRS-CY1JF122J VRS-CY1JF222J VRS-CY1JF222J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF471J VRS-CY1JF223J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF222J VRS-CY1JF222J VRS-CY1JF103J VRS-CY1JF274JY VRS-TV1JD750JY VRS-TQ2BD750J VRS-TQ2BD750J VRS-CY1JF103J VRS-CY1JF274JY VRS-TV1JD750JY VRS-CY1JF103J VRS-CY1JF274JY VRS-TV1JD750JY VRS-TQ2BD750J VRS-TX2HF680J VRS-CY1JF104J VRS-TX2HF680J VRS-CY1JF104J VRS-CY1JF101J VRS-TQ2BD750J VRS-CY1JF101J VRS-TQ2BD750J VRS-CY1JF101J VRS-TQ2BD750J VRS-TQ2BD750J VRS-CY1JF221J VRS-CY1JF221J VRS-TQ2BD750J VRS-CY1JF221J VRS-CY1JF221J VRS-CY1JF101J VRS-TQ2BD750J VRS-TX2HF680J VRS-CY1JF104J VRS-CY1JF221J VRS-CY1JF271J VRS-CY1JF224J VRS-CY1JF221J VRS-CY1JF271J VRS-CY1JF224J VRS-CY1JF564J VRS-CY1JF102J VRS-CY1JF564J 6
Mark No.
R1177 R1178 R1179 R1180 R1181 R1182 R1183 R1184 R1185 R1186 R1187 R1188 R1189 R1190 R1191 R1192 R1196 R1197 R1199 R1202 R1204 R1205 R1206 R1207 R1208 R1209 R1210 R1211 R1212 R1213 R1214 R1215 R1216 R1217 R1218 R1220 R1301 R1302 R1303 R1304 R1305 R1306 R1307 R1308 R1309 R1310 R1311 R1312 R1313 R1314 R1315 R1316 R1317 R1318 R1319 R1320 R1321 R1322 R1323
Description
22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 100 1/16W Metal Oxide 22k 1/16W Metal Oxide 560 1/16W Metal Oxide 560 1/16W Metal Oxide 75 1/8W Metal Oxide 75 1/8W Metal Oxide 100 1/16W Metal Oxide 75 1/8W Metal Oxide 68 1/16W Metal Oxide 68 1/16W Metal Oxide 0 1/16W Metal Oxide 68k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 560 1/8W Metal Oxide 75 1/4W Metal Oxide 75 1/4W Metal Oxide 75 1/4W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 100 1/16W Metal Oxide 1.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 470 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 7
Part No.
VRS-CY1JF102J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF101J VRS-CY1JF223J VRS-CY1JF561J VRS-CY1JF561J VRS-TQ2BD750J VRS-TQ2BD750J VRS-CY1JF101J VRS-TQ2BD750J VRS-CY1JF680JY VRS-CY1JF680JY VRS-CY1JF000J VRS-CY1JF683J VRS-CY1JF101J VRS-CY1JF102J VRS-TQ2BD561J VRS-TW2ED750J VRS-TW2ED750J VRS-TW2ED750J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF562J VRS-CY1JF101J VRS-CY1JF122J VRS-CY1JF222J VRS-CY1JF222J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF471J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF101J F A
PDP-R03U
8
89
Mark No.
R1325 R1326 R1327 R1328 R1329 R1330 R1331 R1332 R1334 R1335 R1336 R1337 R1338 R1339 R1340 R1341 R1342 R1343 R1344 R1345 R1348 R1349 R1350 R1354 R1405 R1406 R1407 R1408 R1409 R1411 R1412 R1413 R1418 R1421 R1422 R1423 R1424 R1425 R1429 R1430 R1431 R1432 R1433 R1437 R1438 R1439 R1443 R1444 R1445 R1446 R1457 R1458 R1459 R1460 R1461 F R1462 R1463 R1581 R1582
Description
1.0k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 220 1/4W Metal Oxide 220 1/4W Metal Oxide 220 1/4W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 560 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 10 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 10 1/16W Metal Oxide 1.0k 1/16W Metal Oxide
Part No.
VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF682J VRS-CY1JF682J VRS-TW2ED221J VRS-TW2ED221J VRS-TW2ED221J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF561J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF000J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF000J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF103J VRS-CA1JF101J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF100J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF100J VRS-CY1JF102J VRS-CY1JF100J VRS-CY1JF102J
Mark No.
R1584 R1601 R1602 R1603 R1604 R1605 R1606 R1607 R1608 R1609 R1610 R1611 R1612 R1613 R1614 R1615 R1616 R1617 R1618 R1619 R1620 R1623 R1624 R1625 R1626 R1627 R1629 R1630 R1631 R1632 R1633 R1634 R1635 R1636 R1637 R1638 R1639 R1640 R1641 R1642 R1643 R1644 R1645 R1650 R1651 R1652 R2501 R2502 R2503 R2505 R2510 R2511 R2513 R2514 R2515 R2516 R2517 R2518 R2519
Description
Part No.
1.0k 1/16W Metal Oxide 470 1/16W Metal Oxide 0 1/16W Metal Oxide 820k 1/16W Metal Oxide Resistor 0 1/16W Metal Oxide 470 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 470 1/16W Metal Oxide 120 1/16W Metal Oxide 100 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 0 1/16W Metal Oxide 820k 1/16W Metal Oxide Resistor 470 1/16W Metal Oxide 6.8k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 0 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 330 1/16W Metal Oxide 330 1/16W Metal Oxide 330 1/16W Metal Oxide 100 1/16W Metal Oxide 22k 1/16W Metal Oxide 22k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 3.3k 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 3
VRS-CY1JF102J VRS-CY1JF471J VRS-CY1JF000J VRS-CY1JF824JY RR-SZ0080CEZZY VRS-CY1JF000J VRS-CY1JF471J VRS-CY1JF682J VRS-CY1JF103F VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF102J VRS-CY1JF471J VRS-CY1JF121JY VRS-CY1JF101J VRS-CY1JF682J VRS-CY1JF103F VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF182J VRS-CY1JF102J VRS-CY1JF000J VRS-CY1JF824JY RR-SZ0080CEZZY VRS-CY1JF471J VRS-CY1JF682J VRS-CY1JF103F VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF182J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF182J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF182J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF331J VRS-CY1JF331J VRS-CY1JF331J VRS-CA1JF101J VRS-CY1JF223J VRS-CY1JF223J VRS-CY1JF102J VRS-CY1JF332J VRS-CY1JF562J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF102J 4
10 1/16W Metal Oxide VRS-CY1JF100J 0 1/16W Metal Oxide VRS-CY1JF000J 33 1W Metal Oxide(PDP-R03T) VRS-CR3AD330J 10k 1/16W Metal Oxide(PDP-R03T) VRS-CY1JF103J
90
1 2
PDP-R03U
Mark No.
R2521 R2522 R2523 R2524 R2525 R2526 R2527 R2528 R2531 R2534 R2535 R2537 R2538 R2539 R2540
Description
100 1/16W Metal Oxide 100 1/16W Metal Oxide 1.0M 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 22k 1/16W Metal Oxide 5.6k 1/16W Metal Oxide 0 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 22 1/16W Metal Oxide 22 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide 100 1/16W Metal Oxide
Part No.
VRS-CY1JF102J VRS-CA1JF101J VRS-CA1JF101J VRS-CY1JF105J VRS-CY1JF222J VRS-CY1JF223J VRS-CY1JF562J VRS-CY1JF000J VRS-CA1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF220J VRS-CY1JF220J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF101J VRS-CY1JF000J VRS-CY1JF102J VRS-CY1JF102J
Mark No.
Description
Part No.
VSDTC144EE/-1 VSDTC144EE/-1 A
DIODE
D3001 Photodiode RH-PX0421CEZZ
RESISTOR
R3001 R3002 R3003 R3004 R3005 R3006 R3007 R3008 R3010 R3011 470 1/16W Metal Oxide 22k 1/16W Metal Oxide 100k 1/16W Metal Oxide 1.8k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 0 1/16W Metal Oxide VRS-CY1JF471J VRS-CY1JF223J VRS-CY1JF104J VRS-CY1JF182J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF000J VRS-CY1JF000J
R2542 0 1/16W Metal Oxide R2555 1.0k 1/16W Metal Oxide R2556 1.0k 1/16W Metal Oxide
MISCELLANEOUS PARTS
P3001 Plug 5-Pin Connecting Cord QPLGN0564TAZZ QCNW-6076CEZZ
MISCELLANEOUS PARTS
FB1101 FB1102 FB1103 FB1104 FB1105 FB1106 FB1107 FB1108 FB1109 FB1110 FB1401 FB1402 FB1602 FB2501 FB2502 FB2503 FB2504 FB2505 FB2506 FB2507 J1103 J1104 P1301 P1402 P2501 Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Ferrite Bead Video 1/2,Compo 1IN Video 3,Compo 3IN,Monitor Plug 18-Pin Socket 30-Pin Plug 12-Pin RBLN-0065CEZZY RBLN-0065CEZZY RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0062TAZZ RBLN-0061TAZZ RBLN-0061TAZZ RBLN-0064TAZZY RBLN-0051TAZZ RBLN-0060TAZZ RBLN-0051TAZZ RBLN-0051TAZZ RBLN-0051TAZZ RBLN-0051TAZZ RBLN-0051TAZZ QTANJ0974CEZZ QTANJ0974CEZZ QPLGN0428FJZZ QSOCN0490FJZZ QPLGN0062CEZZY QPLGN0478GEZZ QPLGN0578GEZZ QSOCD0834CEZZ QSOCD0834CEZZ QSOCN1594CEZZ QSOCN0550FJZZY QCNW-6073CEZZ QCNW-6079CEZZ
E SR UNIT
TRANSISTOR
Q6001 Q6002 Q6003 Q6004 Q6005 2SC3928AR 2SA1530AR 2SA1530AR 2SC3928AR DTC314TK VS2SC3928AR-1 VS2SA1530AR-1 VS2SA1530AR-1 VS2SC3928AR-1 VSDTC314TK/-1 VSDTC314TK/-1 VS2SA1530AR-1 VS2SC3928AR-1 C
DIODE
D6000 D6001 D6002 D6003 D6004 D6006 D6007 D6008 D6009 D6010 D6011 D6012 D6013 D6014 D6015 Diode Diode Zener Diode Zener Diode Diode Diode Diode Diode Diode Diode Zener Diode Zener Diode Diode Diode Zener Diode VHDMA157A//-1 VHDMA157A//-1 RH-EX1264CEZZ RH-EX1264CEZZ VHDMA157A//-1 VHDMA157A//-1 VHDMA157A//-1 VHD1SS355//-1 VHD1SS355//-1 VHD1SS355//-1 RH-EX1264CEZZ RH-EX1264CEZZ VHDMA157A//-1 VHDMA157A//-1 RH-EX1232CEZZY D
P2502 Plug 4-Pin P2503 Plug 5-Pin SC1101 Socket DINx2 SC1102 Socket DINx2 SC1103 Socket 15Pin D-sub SC1401 Socket 30-Pin Connecting Cord Connecting Cord
CAPACITOR
C6000 C6001 C6002 C6003 C6004 10 16V Electrolytic 10 16V Electrolytic 0.1 25V Ceramic 1.0 10V Ceramic 1.0 10V Ceramic VCEAPF1CW106M VCEAPF1CW106M VCKYCY1EF104Z VCKYCY1AF105Z VCKYCY1AF105Z
D LED UNIT
TRANSISTOR
Q3001 2SC3928AR Q3002 2SC3928AR Q3003 DTC144EE VS2SC3928AR-1 VS2SC3928AR-1 VSDTC144EE/-1
RESISTOR
R6000 R6001 R6002 R6003 R6004 56 1/16W Metal Oxide 56 1/16W Metal Oxide 56 1/16W Metal Oxide 47k 1/16W Metal Oxide 56 1/16W Metal Oxide VRS-CY1JF560J VRS-CY1JF560J VRS-CY1JF560J VRS-CY1JF473J VRS-CY1JF560J F
PDP-R03U
5 6 7 8
91
Mark No.
R6005 R6006 R6007 R6011 R6012 R6013 R6014 R6015 R6016 R6017 R6018 R6019 R6020 R6021 R6022 R6023 R6024 R6025 R6030 R6031 R6032 R6033 R6036 R6037 R6038
Description
56 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 56 1/16W Metal Oxide 470 1/16W Metal Oxide 470 1/16W Metal Oxide 0 1/8W Metal Oxide 0 1/8W Metal Oxide 220 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 2.2k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 4.7k 1/16W Metal Oxide 10k 1/16W Metal Oxide 220k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide 100k 1/16W Metal Oxide 100k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 1.0k 1/16W Metal Oxide 22k 1/16W Metal Oxide 10k 1/16W Metal Oxide 10k 1/16W Metal Oxide
Part No.
VRS-CY1JF560J VRS-CY1JF102J VRS-CY1JF560J VRS-CY1JF471J VRS-CY1JF471J VRS-TQ2BD000J VRS-TQ2BD000J VRS-CY1JF221J VRS-CY1JF472J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF222J VRS-CY1JF472J VRS-CY1JF472J VRS-CY1JF103J VRS-CY1JF224J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF104J VRS-CY1JF104J VRS-CY1JF102J VRS-CY1JF102J VRS-CY1JF223J VRS-CY1JF103J VRS-CY1JF103J VRS-CY1JF681J VRS-CY1JF105J
Mark No.
IC404 IC405 IC408 IC410
Description
74LVX125MTC uPD4721G HD74HCT244T or 74VHCT244AMTC HD74HCT244T or 74VHCT244AMTC 74LCX157MTC PQ1R33 BA09FP TC7WH123FK TC7WH126FK HD74HCT125T TC7WH123FK NC7S08P5
Part No.
9DK001-12105 9DK001-15107 9DK001-12085 9DK001-12086 9DK001-12085 9DK001-12086 9DK001-12103 9DK001-15093 9DK001-15109 9DK001-12102 9DK001-12096 9DK001-12070 9DK001-12102 9DK001-12106
TRANSISTOR
Q12 Q13 Q15 Q102 Q103 Q104 Q105 Q107 Q108 Q109 Q110 Q111 Q112 Q113 Q114 Q117 Q118 Q119 Q120 IMB3A 2SC2412KQ 2SA1037AKQ NDC7002N 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SA1037AKQ 2SA1037AKQ 2SA1037AKQ 2SC2412KQ 2SC2412KQ 2SC2412KQ 2SC2412KQ NDC7002N 9DK001-20025 9DK001-20011 9DK001-20012 9DK001-20036 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20012 9DK001-20012 9DK001-20012 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20011 9DK001-20036
R6039 680 1/16W Metal Oxide R6040 1.0M 1/16W Metal Oxide
MISCELLANEOUS PARTS
FB6000 FB6001 FB6002 J6001 J6002 D Ferrite Bead Ferrite Bead Ferrite Bead Jack Jack RBLN-0060TAZZ RBLN-0060TAZZ RBLN-0060TAZZ QJAKJ0110CEZZ QJAKJ0110CEZZ QPLGN1474TAZZY QPLGN0480GEZZ QSOCZ2015CEZZ QCNW-A280WJZZ
P6000 Plug 14-Pin P6001 Plug 4-Pin SC6000 Socket 15-Pin D-Sub Connecting Cord
DIODE
D9 D20 D50 D51 D52 D53 D54 D55 D56 D57 D70 D71 D72 D73 D75 D76 D77 Diode 1SS187 Diode 1SS187 Diode 1SS193 Diode 1SS193 Diode 1SS193 Diode 1SS193 Diode MA3120WA Diode MA3120WA Diode MA3120WA Diode MA3120WA Diode 1SS355 Diode 1SS355 Diode 1SS355 Diode 1SS400 Diode 1SS187 Diode 1SS187 Diode 1SS400 9DK001-30018 9DK001-30018 9DK001-30001 9DK001-30001 9DK001-30001 9DK001-30001 9DK001-30022 9DK001-30022 9DK001-30022 9DK001-30022 9DK001-30020 9DK001-30020 9DK001-30020 9DK001-30021 9DK001-30018 9DK001-30018 9DK001-30021
F PC I/F UNIT
IC
IC2 IC3 IC4 IC7 IC8 E IC19 IC27 IC28 IC53 IC310 IC316 IC319 IC320 IC321 IC322 F IC327 IC328 IC400 IC402 PST623XW LH28F320S3NS-L11 MSM51V181865F-60TS-K 74LVX86MTC TLC5733A TL431CPS HY57V653220BTC-7 HY57V653220BTC-7 HY57V653220BTC-7 HY57V653220BTC-7 NJM4560M TLC2933IPW 74LVX86MTC 74LVX125MTC 9DK001-15060 RH-IX3430CEZZQ 9DK001-11027 9DK001-12079 9DK001-15082 9DK001-15053 9DK001-11024 9DK001-11024 9DK001-11024 9DK001-11024 9DK001-15084 9DK001-15054 9DK001-12079 9DK001-12105 PST600IM AT24C128N-10SC-1.8 CXA3506R PQ05TZ11 PQ20VZ11 9DK001-15061 9DK001-11020 9DK001-15079 9DK001-15038 9DK001-15071
PACKAGED CIRCUIT
X1 X3 X4 Crystal, 6MHz Crystal, FXO-31FL (1.8432MHz) Crystal, FXO-31FL (25MHz) 9DK001-80012 9DK001-80011 9DK001-80018
92
1 2
PDP-R03U
3 4
Mark No.
X5 X6
Description
Crystal, DS07515V (79.794MHz) Crystal, 25.175MHz
Part No.
9DK001-80029 9DK001-80031
Mark No.
C34 C35 C36 C37 C38 C42 C43 C51 C52 C53 C62 C70 C78 C79 C80 C81 C82 C83 C84 C96 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C126 C127 C128 C130 C131 C132 C133 C134 C135 C136 C137 C138 C143 C144 C145 C146 C147 C148 C149 C350 C361 C366 C367 C531
Description
0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 47 6.3V EL 47 16V EL 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 47 6.3V EL 47 6.3V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1 10V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 1 10V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100p 50V Ceramic 0.33 16V Film 100p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 47 6.3V EL 0.01 50V Ceramic 47 6.3V EL 0.01 50V Ceramic 47 6.3V EL 0.01 50V Ceramic 0.01 50V Ceramic 47 6.3V EL 100 6.3V EL 100 4V EL 47 6.3V EL 7
Part No.
9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-40089 9DK001-40079 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-40089 9DK001-40089 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42111 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42111 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42099 9DK001-42149 9DK001-42099 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42096 9DK001-40089 9DK001-42096 9DK001-40089 9DK001-42096 9DK001-40089 9DK001-42096 9DK001-42096 9DK001-40089 9DK001-40080 9DK001-40091 9DK001-40089 F E
CAPACITOR
C1 C2 C6 C7 C8 C9 C10 C12 C13 C14 C15 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 10 10V Ceramic or 10 25V Ceramic 15p 50V Ceramic 15p 50V Ceramic 0.01 50V Ceramic 10 10V Ceramic or 10 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 470p 50V Ceramic 470p 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 10 16V EL 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.047 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 9DK001-42094 9DK001-42094 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42131 9DK001-42118 9DK001-42103 9DK001-42103 9DK001-42096 9DK001-42131 9DK001-42118 9DK001-42096 9DK001-42096 9DK001-42104 9DK001-42104 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-40077 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42105 9DK001-42094 9DK001-42094 9DK001-42094
PDP-R03U
5 6 8
93
Mark No.
C532 C537 C538 C542 C543 C544 C545 C546 C550 C551 C552 C553 C554 C555 C556 C557 C558 C559 C562 C563 C564 C565 C566 C573 C574 C575 C576 C577 C578 C579 C580 C581 C582 C583 C584 C585 C586 C587 C588 C589 C590 C591 C592 C593 E C594 C595 C596 C597 C598 C599 C600 C697 C698 C700 F C702 C704 C705 C706 C715
Description
0.01 50V Ceramic 10 16V EL 0.1 25V Ceramic 10 16V EL 0.1 25V Ceramic 2200p 50V Ceramic 2200p 50V Ceramic 2200p 50V Ceramic 10 16V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 10 16V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 10 10V Ceramic or 10 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 33 6.3V OS 0.1 25V Ceramic 330p 50V Ceramic 47 6.3V EL 47 6.3V EL 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 47 6.3V EL 47 6.3V EL 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic 0.47 16V Ceramic 0.47 16V Ceramic 0.47 16V Ceramic 1 10V Ceramic 0.1 16V Film 0.01 50V Ceramic 0.01 50V Ceramic 1
Part No.
9DK001-42096 9DK001-40077 9DK001-42094 9DK001-40077 9DK001-42094 9DK001-42102 9DK001-42102 9DK001-42102 9DK001-40077 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-40077 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42131 9DK001-42118 9DK001-42094 9DK001-42094 9DK001-40106 9DK001-42094 9DK001-42123 9DK001-40089 9DK001-40089 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-40089 9DK001-40089 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42096 9DK001-42152 9DK001-42152 9DK001-42152 9DK001-42111 9DK001-42145 9DK001-42096 9DK001-42096
Mark No.
C716 C717 C741 C757 C759 C762 C763 C764 C766 C767 C768 C769 C776 C777 C800 C802 C803 C804 C805 C806 C807 C808 C813 C814 C815 C816 C817 C818 C819 C820 C821 C822 C823 C824 C825 C826 C827 C828 C829 C830 C831 C832 C833 C834 C835 C836 C837 C838 C839 C840 C841 C842 C843 C844 C845 C846 C847 C848 C849 C850
Description
0.01 50V Ceramic 0.01 50V Ceramic 47 6.3V EL 4.7 10V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 6.8 10V OS 1 10V Ceramic 4.7 10V Ceramic 6.8 10V OS 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 2.2 50V EL 2.2 50V EL 2.2 50V EL 2.2 50V EL 2.2 50V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100 6.3V EL 0.1 25V Ceramic 100 6.3V EL 220 4V EL 3
Part No.
9DK001-42096 9DK001-42096 9DK001-40089 9DK001-42113 9DK001-42096 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-40104 9DK001-42111 9DK001-42113 9DK001-40104 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-40103 9DK001-40103 9DK001-40103 9DK001-40103 9DK001-40103 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-40080 9DK001-42094 9DK001-40080 9DK001-40092 4
94
2
PDP-R03U
Mark No.
C851 C852 C853 C854 C855 C856 C857 C858 C859 C860 C863 C864 C865 C867 C868 C869 C870 C872 C874 C875 C876 C878 C879 C880 C881 C882 C883 C884 C885 C886 C887 C888 C889 C890 C891 C894 C895 C896 C897 C898 C899 C900 C904 C905 C907 C908 C913 C916 C917 C918
Description
100 6.3V EL 47 6.3V EL 0.01 50V Ceramic 47 16V EL 82p 50V Ceramic 0.1 25V Ceramic 10 16V EL 82p 50V Ceramic 0.1 25V Ceramic 10 16V EL 82p 50V Ceramic 82p 50V Ceramic 82p 50V Ceramic 10 16V EL 0.1 25V Ceramic 0.1 25V Ceramic 82p 50V Ceramic 0.1 25V Ceramic 82p 50V Ceramic 82p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 82p 50V Ceramic 0.47 16V Ceramic 0.1 25V Ceramic 22 16V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.47 16V Ceramic 120p 50V Ceramic 120p 50V Ceramic 120p 50V Ceramic 10 16V EL 10 16V EL 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 100p 50V Ceramic 100p 50V Ceramic 100p 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.1 25V Ceramic 0.1 25V Ceramic 0.01 50V Ceramic 0.01 50V Ceramic
Part No.
9DK001-40080 9DK001-40089 9DK001-42096 9DK001-40079 9DK001-42133 9DK001-42094 9DK001-40077 9DK001-42133 9DK001-42094 9DK001-40077 9DK001-42133 9DK001-42133 9DK001-42133 9DK001-40077 9DK001-42094 9DK001-42094 9DK001-42133 9DK001-42094 9DK001-42133 9DK001-42133 9DK001-42094 9DK001-42094 9DK001-42133 9DK001-42152 9DK001-42094 9DK001-40078 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42152 9DK001-42151 9DK001-42151 9DK001-42151 9DK001-40077 9DK001-40077 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42099 9DK001-42099 9DK001-42099 9DK001-42094 9DK001-42094 9DK001-42094 9DK001-42096 9DK001-42094 9DK001-42094 9DK001-42096 9DK001-42096
Mark No.
R27 R29 R33 R34 R35 R36 R40 R43 R44 R50 R51 R57 R58 R62 R65 R75 R80 R83 R88 R91 R96 R121 R122 R123 R124 R128 R132 R133 R138 R140 R289 R340 R650 R651 R652 R654 R656 R664 R665 R671 R677 R678 R680 R681 R682 R687 R688 R689 R690 R691 R692 R693 R694 R695 R696 R697 R698 R699 R702 R708
Description
27k 1/16W Chip1608 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 68 1/16W Chip1608 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10k 1/16W Resistor Array 10 1/16W Resistor Array 10k 1/16W Resistor Array 0 1/16W Chip1608 270 1/10W Chip2125 0 1/16W Chip1608 270 1/10W Chip2125 0 1/16W Chip1608 270 1/10W Chip2125 47 1/4W Chip3216 47 1/4W Chip3216 1.6k 1/16W Chip1608 1.0k 1/16W Chip1608 10 1/16W Chip1608 3.3k 1/16W Chip1608 3k 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 4.7k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 6.8k 1/16W Resistor Array 10k 1/16W Resistor Array 150 1/16W Chip1608 4.7k 1/16W Chip1608 15k 1/16W Chip1608 15k 1/16W Chip1608 15k 1/16W Chip1608 470 1/16W Chip1608 1.2k 1/16W Chip1608 3k 1/16W Chip1608 3k 1/16W Chip1608 1.2k 1/16W Chip1608 470 1/16W Chip1608 15 1/16W Chip1608 470 1/16W Chip1608 1.8k 1/16W Chip1608 1.8k 1/16W Chip1608 22 1/16W Chip1608 22 1/16W Chip1608 22 1/16W Chip1608 22 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Resistor Array 10k 1/16W Resistor Array 7
Part No.
9DK001-50209 9DK001-51030 A 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-50163 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-51030 9DK001-51029 9DK001-51030 9DK001-50149 9DK001-50103 9DK001-50149 9DK001-50103 9DK001-50149 9DK001-50103 9DK001-50065 9DK001-50065 9DK001-50256 9DK001-50237 9DK001-50150 9DK001-50156 9DK001-50155 9DK001-50149 9DK001-50149 9DK001-50183 9DK001-50185 9DK001-50185 9DK001-51037 9DK001-51030 9DK001-50204 9DK001-50183 9DK001-50259 9DK001-50259 9DK001-50259 9DK001-50173 9DK001-50254 9DK001-50155 9DK001-50155 9DK001-50254 9DK001-50173 9DK001-50201 9DK001-50173 9DK001-50205 9DK001-50205 9DK001-50159 9DK001-50159 9DK001-50159 9DK001-50159 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-51030 9DK001-51030 B
RESISTOR
R10 R11 R16 R17 R18 R19 R21 R22 10k 1/16W Resistor Array 10k 1/16W Resistor Array 1.69k 1/16W Chip1608 33k 1/16W Chip1608 2.15k 1/16W Chip1608 10k 1/16W Resistor Array 0 1/16W Chip1608 10k 1/16W Chip1608 9DK001-51030 9DK001-51030 9DK001-50198 9DK001-50210 9DK001-50199 9DK001-51030 9DK001-50149 9DK001-50185
PDP-R03U
5 6 8
95
Mark No.
R730 R731 A R733 R734 R735 R736 R737 R738 R739 R740 R742 R743 B R745 R747 R749 R757 R758 R758 R759 R760 R763 R764 R765 R867 R868 R869 R876 R877 R879 R881 R883 R885 R887 R901 R911 R912 R920 R921 R922 R924 R925 R926 R927 R928 R929 R930 R934 R936 R937 R939 R940 R941 R947 R951 R959 R960 R961 R962 R963 R964
Description
680 1/16W Chip1608 620 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 10k 1/16W Chip1608 0 1/16W Chip1608 1.8k 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 10k 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 510 1/16W Chip1608 510 1/16W Chip1608 510 1/16W Chip1608 0 1/16W Chip1608 10k 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/4W Chip3216 10 1/10W Chip2125 10 1/10W Chip2125 100 1/16W Chip1608 100 1/16W Chip1608 10k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 0 1/16W Chip1608 100 1/16W Chip1608 100 1/16W Chip1608 100 1/16W Chip1608 100 1/16W Chip1608 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 56 1/16W Resistor Array 6.8k 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 1
Part No.
9DK001-50175 9DK001-50271 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50185 9DK001-50149 9DK001-50205 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50185 9DK001-50177 9DK001-50177 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50217 9DK001-50217 9DK001-50217 9DK001-50149 9DK001-50185 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50113 9DK001-50121 9DK001-50121 9DK001-50165 9DK001-50165 9DK001-50185 9DK001-50183 9DK001-50183 9DK001-50149 9DK001-50165 9DK001-50165 9DK001-50165 9DK001-50165 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51039 9DK001-51037 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040
Mark No.
R965 R966 R967 R968 R969 R970 R971 R972 R973 R974 R975 R976 R977 R978 R979 R980 R993 R998 R999 R1000 R1001 R1002 R1003 R1004 R1005 R1006 R1007 R1008 R1009 R1011 R1012 R1013 R1015 R1017 R1019 R1022 R1023 R1024 R1025 R1026 R1027 R1028 R1029 R1030 R1031 R1032 R1033 R1034 R1035 R1036 R1037 R1038 R1042 R1043 R1044 R1045 R1048
Description
68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 68 1/16W Resistor Array 33 1/16W Resistor Array 33 1/16W Resistor Array 33 1/16W Resistor Array 33 1/16W Resistor Array 33 1/16W Resistor Array 33 1/16W Resistor Array 10k 1/16W Chip1608 68 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 510 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 100 1/16W Chip1608 100 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 2.2k 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 2.2k 1/16W Chip1608 33k 1/16W Chip1608 1k 1/16W Chip1608 47 1/16W Chip1608 47 1/16W Chip1608 47 1/16W Chip1608 2.2k 1/16W Chip1608 3.3k 1/16W Chip1608 3.3k 1/16W Chip1608 3.3k 1/16W Chip1608 0 1/16W Chip1608 220 1/16W Chip1608 220 1/16W Chip1608 220 1/16W Chip1608 1M 1/16W Chip1608 1k 1/16W Chip1608 22k 1/16W Chip1608 100k 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 100k 1/16W Chip1608 1k 1/16W Chip1608 22k 1/16W Chip1608 100k 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 1k 1/16W Chip1608 560 1/16W Chip1608 47 1/16W Chip1608
Part No.
9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51040 9DK001-51042 9DK001-51042 9DK001-51042 9DK001-51042 9DK001-51042 9DK001-51042 9DK001-50185 9DK001-50163 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50217 9DK001-50183 9DK001-50183 9DK001-50165 9DK001-50165 9DK001-50177 9DK001-50177 9DK001-50179 9DK001-50177 9DK001-50177 9DK001-50179 9DK001-50210 9DK001-50177 9DK001-50161 9DK001-50161 9DK001-50161 9DK001-50179 9DK001-50181 9DK001-50181 9DK001-50181 9DK001-50149 9DK001-50169 9DK001-50169 9DK001-50169 9DK001-50190 9DK001-50177 9DK001-50186 9DK001-50212 9DK001-50177 9DK001-50177 9DK001-50212 9DK001-50177 9DK001-50186 9DK001-50212 9DK001-50177 9DK001-50177 9DK001-50177 9DK001-50174 9DK001-50161 9DK001-50161 9DK001-50161 9DK001-50183 4
R1049 47 1/16W Chip1608 R1050 47 1/16W Chip1608 R1051 4.7k 1/16W Chip1608
96
2
PDP-R03U
3
Mark No.
Description
Part No.
9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50183 9DK001-50207 9DK001-51039 9DK001-50159 9DK001-50177 9DK001-50185 9DK001-50207 9DK001-50165 9DK001-50149 9DK001-51039 9DK001-51039 9DK001-50165 9DK001-50185 9DK001-50177 9DK001-50214 9DK001-50183 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50149 9DK001-50088 9DK001-50185 9DK001-50161 9DK001-50110 9DK001-50110 9DK001-50110 9DK001-50110 9DK001-50080 9DK001-50110 9DK001-50110 9DK001-50110
R1052 4.7k 1/16W Chip1608 R1053 4.7k 1/16W Chip1608 R1054 R1055 R1056 R1058 R1059 R1060 R1061 R1062 R1077 R1079 R1082 R1083 R1084 R1085 R1089 R1099 R1101 R1102 R1104 R1105 R1107 R1108 R1110 R1120 R1121 R1122 R1123 R1124 R1125 R1126 R1127 R1128 FB15 FB18 FB19 FL1 FL98 FL99 FL102 FL110 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 4.7k 1/16W Chip1608 6.8k 1/16W Chip1608 56 1/16W Resistor Array 22 1/16W Chip1608 1k 1/16W Chip1608 10k 1/16W Chip1608 6.8k 1/16W Chip1608 100 1/16W Chip1608 0 1/16W Chip1608 56 1/16W Resistor Array 56 1/16W Resistor Array 100 1/16W Chip1608 10k 1/16W Chip1608 1k 1/16W Chip1608 16k 1/16W Chip1608 4.7k 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 0 1/16W Chip1608 10 1/4W Chip3216 10k 1/16W Chip1608 47 1/16W Chip1608 0 1/10W Chip2125 0 1/10W Chip2125 0 1/10W Chip2125 0 1/10W Chip2125 33 1/10W Chip2125 0 1/10W Chip2125 0 1/10W Chip2125 0 1/10W Chip2125
Mark No. IC
IC701 IC702 IC703
Description
NJM2375AD TNY264P TA76431
Part No.
VHiNJM2375AD1 VHiTNY264P/-1 VHiTA76431S15
TRANSISTOR
Q701 Q702 Q703 Q704 Q705 Q706 Q707 Q708 Q709 2SK2662 2SC1741AS 2SK2700 2SC1741AS DTD113ZS DTC124ESA DTA124XSA DTC124ESA DTA114ESA VS2SK2662//-1 VS2SC1741AS-1 VS2SK2700//-1 VS2SC1741AS-1 VSDTD113ZS/-1 VSDTC124ESA-1 VSDTA124XSA-1 VSDTC124ESA-1 VSDTA114ESA-1
DIODE
D701 D702 D703 D704 D705 D706 D707 D708 D709 D710 D711 D713 D714 D715 D716 D717 Diode Diode Diode Diode Zener Diode Diode Diode Diode Diode Diode Zener Diode Diode 1SS270A Zener Diode Zener Diode Diode VHDD3SB60//-1 VHD5JL2CZ47-1 VHD1SS270ATE1 VHD1SS270ATE1 VHEHZS18-3/-1 VHD1SS270ATE1 VHD05NH45//-1 VHD05NH45//-1 VHDAG01////-1 VHDFMB26L//-1 VHEHZS12A3/-1 VHDRK39LFC3-1 VHD1SS270ATE1 VHEHZS3CLL/-1 VHEHZS6C2//-1 VHD1SS270ATE1
PACKAGED CIRCUIT
> PC701 > PC702 > PC703 > PC704
Photo Coupler PC123FY Photo Coupler PC123FY Photo Coupler PC123FY Photo Coupler PC123FY VHPPC123FY2VHPPC123FY2VHPPC123FY2VHPPC123FY2D
TRANSFORMER SWITCH
S1 Switch Slide 9DK001-70012
MISCELLANEOUS PARTS
FB50 FB51 FB52 FB53 CN1 CN3 CN5 CN6 CN7 CN8 CN9 Ferrite Bead Chip2125 Ferrite Bead Chip2125 Ferrite Bead Chip2125 Ferrite Bead Chip2125 Connector, 15-pin Connector, 29-pin Connector, JEY-9P-1A3F Connector, 30-pin Connector, 50-pin Connector, 12-pin Connector, 13-pin 9DK001-81060 9DK001-81060 9DK001-81060 9DK001-81060 9DK001-60074 9DK001-60053 9DK001-60066 9DK001-60067 9DK001-60058 9DK001-60070 9DK001-60071
CAPACITOR
> C704 > C705
C706 C707 C708 C709 C710 C711 C713 C714 C715 C716 0.01 275V Film 1000p 250V Ceramic 0.82 400V Film 220p 2kV Ceramic 56 450V EL. 0.01 50V Ceramic 100 35V EL. 0.47 12V Ceramic 220p 2kV Ceramic 220p 2kV Ceramic 0.1 16V Ceramic 0.1 16V Ceramic RC-M2E103RES RCDE0910R102 RC-M2G824MDSC RCDE0707R221S RC-E2W566KMMZ RCDD350BC103K RC-E1V107SNPW RC-DD312F474Z RCDE0707R221S RCDE0707R221S RCDD407SR104K RCDD407SR104K
G POWER UNIT
5 6
PDP-R03U
7 8
97
Mark No.
C717 C718 C719 C720 C721 C722 C723 C724 C725 C726 C727 C728 C729 B C730 C731 C732 C733
Description
4700p 50V Ceramic 0.01 50V Ceramic 22 400V EL. 100p 2kV Ceramic 0.1 16V Ceramic 22 50V EL. 470 25V EL. 470 25V EL. 470 25V EL. 0.1 16V Ceramic 470 25V EL. 220 10V EL. 220 10V EL. 0.1 16V Ceramic 0.047 50V Ceramic 1 50V EL. 2200p 50V Ceramic
Part No.
RCDD107-B472K RCDD350BC103K RC-E2G226KMXZ RCDE0705SL101 RCDD407SR104K RC-E1H226SNPJ RC-E1E477SNPW RC-E1E477SNPW RC-E1E477SNPW RCDD407SR104K RC-E1E477SNPW RC-E1A227SNPW RC-E1A227SNPW RCDD407SR104K RCDD407SR473K RC-E1H105SNPR RCDD106-B222K
Mark No.
Description
Part No.
MISCELLANEOUS PARTS
FB701 FB702 > RL701 > F702 CN702 Ferrite Bead Ferrite Bead Relay Fuse T2A 250V TR-5 Connector, 3-pin RCORF1011SNEZ RCORF1011SNEZ RRLYD1010SNE QFS-A1129SNE QCNCM1003SNEZ QCNCM1766SNEZ PRDAF1085SNEZ PRDAF1073SNEZ
H EMC UNIT
DIODE
> VA701 Varistor
VHVNV470D10-
FILTER
> L701 > L702
Filter Filter RCiLZ1230SNE RCiLZ1230SNE
RESISTOR
R702 R703 R704 R705 R706 C R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 R729 R730 R731 R732 R733 R734 R735 R736 R737 R738 R739 R740 1M 1/4W Carbon 1M 1/4W Carbon 22k 1/4W Carbon 10 1/4W Carbon 0.15 2W M-Ox. 820k 1/4W Carbon 750k 1/4W Carbon 0 1/4W Carbon 15k 1/4W Carbon 560 1/4W Carbon 1k 1/4W Carbon 10k 1/4W Carbon 100 2W M-Ox. 270k 1/2W Carbon 270k 1/2W Carbon 18k 1/4W Carbon 5.6k 1/4W Carbon 3 3W M-Ox. 1.5k 1/4W Carbon 220 1/2W Carbon 68 1/4W Carbon 100 1/4W Carbon 470 1/4W Carbon 1k 1/4W Carbon 1.2k 1/4W Carbon 1.5k 1/2W Carbon 10 1/4W Carbon 100 1/4W Carbon 220 1/4W Carbon 1k 1/4W Carbon 10k 1/4W Carbon 3.6k 1/4W Carbon 150 1/4W Carbon 1k 1/4W Carbon 1k 1/4W Carbon 2.2k 1/4W Carbon 2.2k 1/4W Carbon 5.6k 1/4W Carbon 51k 1/4W Carbon VRD-HT2EY105J VRD-HT2EY105J VRD-HT2EY223J VRD-HT2EY100J RR-HRNMR15J2C VRD-HT2EY824J VRD-HT2EY754J VRD-HT2EY000J VRD-HT2EY153J VRD-HT2EY561J VRD-HT2EY102J VRD-HT2EY103J VRS-RE3DA101J VRD-HT2HY274J VRD-HT2HY274J VRD-HT2EY183J VRD-HT2EY562J RR-HRSM3R0J3C VRD-HT2EY152J VRD-HT2HY221J VRD-HT2EY680J VRD-HT2EY101J VRD-HT2EY471J VRD-HT2EY102J VRD-HT2EY122J VRD-HT2HY152J VRD-HT2EY100J VRD-HT2EY101J VRD-HT2EY221J VRD-HT2EY102J VRD-HT2EY103J VRNHT2EK3601F VRNHT2EK1500F VRNHT2EK1001F VRD-HT2EY102J VRD-HT2EY222J VRD-HT2EY222J VRD-HT2EY562J VRD-HT2EY513J
CAPACITOR
> C701 > C702 > C703 > C735
0.22 275V Film 1000p 250V Ceramic 1000p 250V Ceramic 0.22 275V Film RC-M2E224RES RCDE0910R102 RCDE0910R102 RC-M2E224RES
RESISTOR
R701 R741 R742 390k 1/2W Carbon VRD-HT2HY394J 5.6M 1/2W Carbon(PDP-R03U) RR-RCR50+565J 5.6M 1/2W Carbon(PDP-R03U) RR-RCR50+565J
MISCELLANEOUS PARTS
> F701 Fuse T2A 250V TR-5 > CN701 Socket, 3-pin
CNW701 Connecting Cord (NF) CNW702 Connecting Cord (Earth) QFS-A1129SNE QSOCA1012SNE QCNW-1765SNEZ QCNW-1769SNEZ
SWITCH
> SW701 Switch 98
1 2 QSW-P0591CEZ
PDP-R03U
3 4
6. ADJUSTMENT
A
(1) Using the system cable, interconnect the plasma display and the AVC system. (2) Connect the plasma display to the AC power source. (3) Connect the AVC System to the AC power source.
2. Procedure for turning ON the power
(1) Turn ON the AC power switch located on the plasma display. The power indicator on the plasma display will start blinking in red. (When the AC power switch on the AVC System is not ON, the power indicator on the plasma display always blinks in red.) (2) Turn ON the power switch located on the AVC System. The power indicator on the AVC System will be illuminated in green. Simultaneously, the power indicator on the plasma display will change from blinking in red to illumination in green. Now the system has started up. (3) If the power indicators on the AVC System and on the plasma display are both illuminated in red, press the power key located on the remote controller and the power button located on the plasma display. The power indicators on the plasma display and on the AVC System will change from red to green. Now the system has started up.
PDP-R03U
5 6 7 8
99
1. Entering the process adjustment mode With the system being ON, turn OFF the main power of the plasma display. Next holding down the INPUT SELECT and CH UP buttons on the plasma display itself, turn ON the main power again. Now the adjustment mode screen shows up. 2. Adjustments in the adjustment process mode
[Steps] Make adjustments using the process adjustment mode buttons, listed below. [Description] Following the items displayed on the process adjustment menu screen, adjust the settings given in their adjustment tables.
3. Procedure for making factory settings
[Steps] In the process adjustment mode, move the cursor to the line INDUSTRY INIT onscreen. Turn ON with the VOL key and press the SET/ENTER key. (Within the adjustment process, the channel settings remain unchanged. Once you exit the process adjustment mode, the channel settings entered in the delivery adjustment mode become valid.) [Description] The users adjustment parameters and others will be set to the default values. Keep in mind that the channel settings will also be initialized.
(1) Descriptions of special buttons in process adjustment mode (All on the remote controller) Cursor UP key : Returns to the previous page. Cursor DOWN key : Proceeds to the next page. Vol UP key : Increases the adjusted value by 1. Vol DOWN key : Decreases the adjusted value by 1. Cursor RIGHT key : Increases the adjusted value by 10. Cursor LEFT key : Decreases the adjusted value by 10. CH UP key : Moves up the cursor. CH DOWN key : Moves down the cursor. (2) Process adjustment menu table The items displayed on the menu screen must be written down before replacing the EEPROM at the AVC System side.
100
1 2
PDP-R03U
3 4
(2) Organization of process adjustment screen Page Input Source Distinguish Signal HDCP The example of a display 1/16 +Badj3.3V +Badj2.5V KEY WRITE INDUSTRY INIT CENTER Version OSD version CVIC Version MONITOR version PANEL Version FLASH version MONITOR Model MODEL select MAIN MODEL select AV Model Select MONITOR STANDBY TYPE 2 1
C A
INPUT1 No SIG HDCP:ON 128 024 OFF OFF MR MAIN E 2001/11/14A MR OSD 2001/09/06A W2001/10/02 17.28 X2001/10/02 V2001/09/12 09.12 F6 91xx -00 -01 11
B
Parameter display +B Adj3.3V +B Adj2.5V SUB N358 Y SUB N358 COLOR GAIN SUB N358 TINT N358 Y CONTRAST N358 COLOR GAIN MAIN CR GAIN N358 N358 TINT MAIN CONTRAST 15K MAIN SUB BRIGHT 15K COMP 15K Y CONTRAST COMP 15K COLOR GAIN MAIN CR GAIN COMP 15K COMP HDTV CONTRAST COMP HDTV SUB BRIGHT PEAK ACL SW
Description 3.3 V adjustment 2.2 V adjustment Sub N358 Y level adiustment Sub N358 color gain adjustment Sub N358 tint adjustment Main N358 Y contrast adjustment Main N358 color gain adjustment Main N358 Cr level adjustment Main N358 Tint adjustment Main Contrast adjustment (15k) Main sub bright adjustment (15k) COMP 15k Y level adjustment COMP 15k Color gain adjustment COMP 15k Cr level adjustment COMP HDTV contrast level adjustment COMP HDTV black level adjustment
The values for the above parameters should be written down before the EEPROM is replaced on the AVC System.
PDP-R03U
5 6 7 8
101
1) Before replacing the PC I/F unit, write down the values for the parameters listed on the 2nd and 3rd pages of the Adjustment Process A screen. If the values for the parameters cannot be written down because the PC I/F unit is completely broken or for any other reason, make all the adjustments in accordance with the paragraph for Adjustment procedure and parameters, rather than the following procedures. (End) Set the parameters listed on the 2nd and 3rd pages of the Adjustment Process A screen to the values you have written down.
Adjustment parameters
1) Analog adjustment
(1) Prior adjustment for AVC system chassis
B
Adjustment item
1 2 3 Process adjustment mode AVC center 3.3V adjustment AVC center 2.5V adjustment
Description
Adjustment procedure
Call the process adjustment mode.
Adjust output voltage of DC/DC 3.3 V line to 3.25 0.01 V. Adjust output voltage of DC/DC 2.5 V line to 2.6 0.01 V.
Adjustment item
1 2 Setup Tuner level adjustment
Description
Adjustment procedure
1. Receive the SPLIT FIELD color bar signal. white 100%, 75% color bar, modulation
1. Adjust the V-LEVEL (R1121) control so that the tuner output (TP1101) on the AV PWB (DUNTKA616) should be 1.0 0.02 Vp-p. 2. Adjust the V-LEVEL (R1219) control so that the tuner output (TP1201) on the AV PWB (DUNTKA616) should be 1.0 0.02 Vp-p.
1.0Vp-p
D
1. Adjust TB1274_MAIN output (pin (3) of P801) so that the level shown below should be 0.3 0.01 Vp-p.
E
0.3Vp-p
1. Adjust TB1274_MAIN output (pin (3) of P801) so that the waveform should become as shown below.
Smoothed
102
1 2
PDP-R03U
3 4
Adjustment item
6 MAIN N358 Cr level adjustment
Description
Adjustment procedure
1. Adjust TB1274_MAIN output (pin (5) of P801) so that the level shown below should be 0.3 0.01 Vp-p.
A
0.3Vp-p
Peak ACL: OFF Check DC Tran 01 Press the TWIN PICTURE key.
1. Turn off the PEAK ACL control. Adjust the output (TP815) of IC810 to have 1.1 Vp-p from the pedestal level. Adjusted value: 1.1 0.02 V 1. Select the special TWIN PICTURE settings for adjustment (so that the same video source is reflected on MAIN/SUB). 1. Adjust TB1274_SUB output (TP806) to 0.9 0.02 Vp-p.
B
0.9Vp-p
1. Adjust TB1274_SUB output (TP805) so that the level shown below should be 0.68 0.01 Vp-p.
0.68Vp-p
C
Adjustment item
1 2 3 Setup COMPONENT 15 kHz Y level adjustment COMPONENT 15 kHz COLOR GAIN adjustment
Description
Adjustment procedure
1. Select the component 15 kHz source (100% white color bar signal). 1. Adjust TB1274_MAIN output (pin (1) of P801) to 0.7 0.01 Vp-p. 1. Adjust TB1274_MAIN output (pin (3) of P801) so that the level shown below should be 0.7 0.01 Vp-p.
0.7Vp-p
1. Adjust TB1274_MAIN output (pin (3) of P801) so that the level shown below should be 0.7 0.01 Vp-p.
E
0.7Vp-p
PDP-R03U
5 6 7 8
103
Adjustment item
A
Description
Adjustment procedure
1. Select the component HDTV source (100% white color bar signal).
Setup
1. Turn off the PEAK ACL control. Adjust the output (TP815) of IC810 to have 1.1 0.02 Vp-p from the pedestal level.
Description
Adjustment procedure
Check the PEAK ACL is "ON" and DC Tran is "00". Press the Delivery Setup key on the remote controller. Or position the cursor on the INDUSTRY INIT line, set the line to ON with the VOL key, and then press the ENTER key. The adjustment is finished when the line turns OFF.
INDUSTRY INIT
Then turn off the AC power supply of the AVC System. (Be careful not to use the power switches of the remote controller and panel unit.)
J1103 SC1101 J1104 SC1102 SC1103 TU1102 U/V TUNER TU1101 U/V TUNER
C
IC1401 AV SWITCH IC1602 CCD IC1102 P1301 CONNECTOR IC1301 AV SWITCH
TP1101
IC1601 V-CHIP
SC1502 CONNECTOR
SC1401 CONNECTOR
TP1201
IC1603 V-CHIP
R1219 R1121
D
IC802 SUB VIDEO CHROMA SC1503 CONNECTOR SC1402 CONNECTOR P2502 CONNECTOR IC2501 MULTI SOUND P2501 CONNECTOR
TP806 TP805
SC1501 CONNECTOR IC1901 PLD SC1504 CONNECTOR IC402 SUB COMB FILTER IC403 CONTROL IC604 SYNC SEPARATE
P2503 CONNECTOR
E
P1901 PROGRAMMING CONNECTOR
TP1701
P801 TP815
IC801 MAIN VIDEO CHROMA L1708
IC1502 DAC
TP1702
IC1502 DAC
104
1 2
PDP-R03U
3 4
No sound
No sound from speaker No audio output (INPUT 1/2/3) No audio output (INPUT4)
7.1 DIAGNOSIS
7. GENERAL INFORMATION
5 Is audio output available at each related pin of IC2501 (MULTI SOUND PROCESSOR) normal? IC2501 Pins (37) and (36) (SC1 OUT L/R) YES YES Is audio output available at each related pin of IC2501 (MULTI SOUND PROCESSOR) normal? IC2501 Pins (37) and (36) (SC1 OUT L/R) Check the circuit between pins (37)/(36) of IC2501 and pins (5)/(14) of J1103 (INPUT1), pins (2)/(11) of J1103 (INPUT2), and pins (5)/(14) of J1104 (INPUT3), as well as audio mute circuit. Check the circuit between pins (37)/(36) of IC2501 and pins (10)/(13) of J3401 (INPUT4), as well as audio mute circuit. YES YES NO Check IC2501 (MULTI SOUND PROCESSOR) and its peripheral circuits. On TV reception YES On external input / PC input Is tuner audio input available at each related pin of IC2501 (MULTI SOUND PROCESSOR) normal? IC2501 Pin (67) (SOUND S-IF1) IC2501 Pin (69) (SOUND S-IF2) NO Check B.P.F. of SIF1 and SIF2 respectively. NO NO Check U/V tuner (TU1101, TU1102) and peripherals. NO NO E D C B
Does output icon denote speaker when operating audio volume control?
NO
Is audio output available at each related pin of IC2501 (MULTI SOUND PROCESSOR) normal? IC2501 Pins (34) and (33) (SC2 OUT L/R) YES
Check the circuit between pins (34)/(33) of IC2501 and pins (2)/(11) of J1104 (Monitor audio output), as well as audio mute circuit. YES
Does output icon denote lineout when operating audio volume control?
NO
PDP-R03U
Is audio output available at each related pin of IC2501 (MULTI SOUND PROCESSOR) normal ? IC2501 Pins (36) and (37) (SC1 OUT L/R)
YES
YES
Is audio output available at each related pin of IC1301 (AV SWITCH) normal? IC1301 Pins (52) and (54)(MAIN L/R) IC1301 Pins (43) and (45)(SUB L/R) IC1301 Pins (38) and (40)(MONITOR OUT L/R)
YES
Is each audio input circuit between J3401 (PC INPUT/AUDIO) and pins (29)/(31) of IC1301 normal? 8
105
106
No picture (1)
1
No external input <INPUT2> No external input <INPUT3> No external input <INPUT4> Is "INPUT2" selected NO on the Input Select menu screen? Select "INPUT2" on the menu screen. YES NO Check the line between pin (20) of J1003 and pin (8) of IC1301. NO YES Is there AV signal input at pin (15) of IC1301 (AV SWITCH)? Check the line between pin (23) of J1104 and pin (15) of IC1301. YES Is there AV signal input at pin (22) of IC1301 (AV SWITCH)? YES NO Are there MAIN and SUB video signal outputs at pins (56) and (44) of IC1301, respectively? YES <SUB system> NO Check IC7001 and its peripheral circuits. YES NO YES NO Check the line between IC7001 and IC801. Check IC402 and its peripheral circuits. NO Check the line between pin (7) of J3401 and pin (22) of IC1301. Select "INPUT3" on the menu screen. YES Is "INPUT3" selected NO on the Input Select menu screen? Is "INPUT4" selected NO on the Input Select menu screen? Select "INPUT4" on the menu screen. Is there AV signal input at pin (8) of IC1301 (AV SWITCH)? YES Check IC1301 and its peripheral circuits. Is there video signal at pins (2) and (1) of IC402 (Sub Comb Filter)? YES
YES
NO
Check the line between pin (23) of J1003 and pin (1) of IC1301.
YES
<MAIN system>
PDP-R03U
A
YES NO Check IC801 and its peripheral circuits.
Are there MAIN-Y and MAIN-C signal inputs at pins (1) and (48) of IC801 (MAIN VIDEO CHROMA) respectively?
Are there SUB-Y and SUB-C signal input at pin (44) and (1) of IC802 (SUB VIDEO CHROMA), respectively? YES
NO
D E
YES NO Check the line between IC801 and IC803.
Are there MAIN-Component-Y/Cb/Cr signal outputs at pins (21), (22) and (23) of IC801, respectively?
Are there SUB-Y/Cb/Cr signal outputs at pins (21), (22) and (23) of IC802, respectively? YES Are there SUB-Y/Cb/Cr signal inputs at pins (5), (9) and (7) of IC810 (6.7MHz L.P.F.), respectively? YES
NO
3
YES NO Check IC803 and its peripheral circuits. NO Check between IC803 and IC810. YES NO Check IC810 and its peripheral circuits. YES Check the PC I/F unit.
Are there MAIN-Component-Y/Cb/Cr signal inputs at pins (69), (68) and (67) of IC803 (RGB DECODER), respectively?
NO
Are there MAIN-R/G/B signal outputs at pins (35), (37) and (39) of IC803, respectively?
Are there SUB-R/G/B signal outputs at pins (13), (11) and (10) of IC810, respectively? YES
NO
Are there MAIN-R/G/B signal inputs at pins (5), (7) and (9) of IC810 (6.7MHz L.P.F.), respectively?
Are there MAIN-R/G/B signal outputs at pins (13), (11) and (10) of IC810, respectively?
Power switch on, but no power (Front LED indicator does not change from red to green, but remains in red.) Power-on failure (Front LED indicator stays off.) NO
NO Reinsert the connectors, and turn on the power again. YES NO Turn on the PDP's power switch. Are F701 and F702 intact in place? YES Is the PS_ON terminal (pin (1) of CN703) at HI (3.5V)? NO YES NO Check the PS_ON line. Does the BACK5V line function? YES NO
5 NO Is the impedance of the M+10V line as specified? (Measure the resistance between F1702 and GND.) YES NO Are there voltage fluctuations along the OVP line (pin (12) of P1502)? Check the M+10V line as well as its circuit parts. Check the set's wire harnesses, FFCs and other parts for their connections. YES NO Check the internal parts of the power unit (Q703, Q704, Q708, Q709, D717, D710 and D711). Are the D_POW and B+2.5V_POW settings (pins (30), (32), (33) and (34) of IC1701) at HI? YES Are the DC/DC converter output lines and MOS-FET (Q1712, Q1716, Q1726 and Q1718) as specified? YES NO NO Chekc the D_POW and B+2.5V_POW lines (pins (6) and (7) of IC1503). Replace IC1701. Check the DC/DC converter output lines and replace the MOS-FET (Q1712, Q1716, Q1726 and Q1718). E D C B
Are the MDR and DVI cable connectors (white and gray) properly connected with the PDP and the set as well?
Reinsert the power cable connector and turn on the power again.
YES
YES
Replace F701 or F702 and turn on the power again. If the fuse blows out again, replace VA701, Q701, Q703 and IC702 and check the performance again.
YES
Check the BACK5V line. Is there any defective part or short-circuit? 6 YES Repair the defective part or short-circuit. Check the performance again. NO Check IC701, T702, PC703 and their peripheral circuits.
PDP-R03U
Do the +5V line (pin (10) of P1703), +2.5V line (pins (5) and (6) of P1702), NO and +3.3V line (pin (8) of P1702) all function?
YES
8 A
107
Check the set's wire harnesses, FFCs and other parts for their connections.
108
No BS power 1 NO Make sure the harnesses (CN704 and P5701) are properly connected. YES NO Check the BS_POW line. YES NO Check IC5703 and its peripheral circuits as well as the BS3.3V line circuits. 2 YES NO Check IC5704, Q5702 and their peripheral circuits as well as the BS5V line circuits. YES YES 3 NO Is the ANTPOW terminal (pin (30) of IC5704) at HI? YES YES YES Check IC5704, Q5704, IC5705 and their peripheral circuits as well as the LNB_POW line circuits. Check the ANTPOW line. 4
Is the M+10V signal (pins (1), (2) and (3) of P5701) applied?
Does the BS3.3V line (pins (8), (9) and (10) of P5703) function?
Does the BS5V line (pins (6) and (7) of P5703) function?
PDP-R03U
NO
Check the set's connector harnesses and FFCs for their connections.
No picture (2) No external input picture (INPUT3 COMPONENT) No external input picture (INPUT3 RGB)
NO
NO
NO
5
YES NO Check the circuit between pins (26)/(17) and (8) of JC1103 and pins (59)/(61)/ (63) of IC1401. Is component signal input available at pins (5), (7) and (9) of IC1401 (AV SWITCH)? NO Check the circuit between pins (26)/(17)/(8) of J1104 and pins (5)/(7)/(9) of IC1401. Is RGB signal input available at pins (15), (17) and (19) of IC1401 (AV SWITCH)? YES <HDTV> NO Check IC1401 and its peripheral circuits. Is COMPONET/RGB signal output available at pins (38), (36) and (34) on IC1401? YES NO YES <SUB> NO Check IC1401 and its peripheral circuits. YES Is COMPONENT signal output available at pins (44), (42) and (40) of IC1401? YES NO NO Check the circuit between pins (50)/(48)/(46) of IC1401 and (19)/(18)/(17) of IC801. Is component signal input available at pins (19), (18) and (17) of IC802 (SUB VIDEO CHROMA), respectively? NO YES Check the circuit between pins (44)/(42)/(40) of IC1401 and pins (19)/(18)/(17) of IC803. Is COMPONET/RGB signal input available at pins (6), (5) and (4) of IC803 (RGB DECODER), respectively? YES NO
Is "COMPONENT" of "INPUT1" selected on Input Select menu screen? Select "COMPONENT" of "INPUT1" on menu selection screen. Select "COMPONENT"of "INPUT3" on menu selection screen. Is "RGB" of "INPUT3" selected on Input Select menu screen?
YES
Is COMPONENT signal input available at pins (59), (61) and (63) on IC1401 (AV SWITCH)? YES
Check the circuit between pins (1)/(2)/(3) of SC1103 and pins (15)/(17)/(19) of IC1401.
<MAIN>
Is COMPONENT signal output available at pins (50), (48) and (46) on IC1401?
YES
Is COMPONENT signal input available at pins (19), (18) and (17) of IC801 (MAIN VIDEO CHROMA), respectively ?
Check the circuit between pins (38)/(36)/(34) of IC1401 and pins (6)/(5)/(4) of IC803.
YES
Are there MAIN-R/G/B signal inputs at pins (5), (7) and (9) of IC811 (30MHz L.P .F.), respectively? YES
NO
PDP-R03U
No picture (3) No external input picture (INPUT2 S-IN) Is "INPUT2" selected NO on Input Select menu screen? YES Select "INPUT2" on menu selection screen. Is "INPUT3" selected NO on Input Select menu screen? YES Check the circuit between pins (9)/(10) of SC1101 and pins (3)/(5) of IC1301. Is Y signal input available at pin (10) and C signal input at pin (12) of IC1301 (AV SWITCH), respectively? YES NO Check the circuit between pins (3)/(4) of SC1101 and pins (10)/(12) of IC1301. Is Y signal input available at pin (17) and C signal input at pin (19) of IC1301 (AV SWITCH), respectively? YES NO
Are there MAIN-R/G/B signal outputs at pins (13), (11) and (10) of IC811, respectively? YES
NO
7
No external input picture (INPUT3 S-IN) Select "INPUT3" on menu selection screen. Check the circuit between pins (2)/(1) of SC1102 and pins (9)/(10) of IC1301.
YES
Is Y signal input available at pin (3) and C signal input at NO pin (5) of IC1301 (AV SWITCH), respectively?
Is Y signal input available at pin (24) and C signal input at pin (26) of IC1301 (AV SWITCH), respectively? YES
NO
Check the circuit between pins (2)/(1) of J3401 and pins (24)/(26) of IC1301.
8 E
YES
109
Is MAIN-Y signal output available at pin (56) and MAIN-C signal output at pin (58) of IC1301, respectively?
A B
D C
NO
C
Check IC1301 and its peripheral circuits.
Is SUB-Y signal output available at pin (44) and SUB-C signal output at pin (47) of IC1301, respectively?
110
No picture (4) No picture (5) No monitor picture (S-OUT) No TV picture YES Check IC1301 and its peripheral circuits. Confirm input signal is S-INPUT. Is video output available at pin (19) of TU1101 and TU1102 (U/V tuner)? NO YES NO Check U/V tuner and its peripheral circuits. YES Check IC1301 and its peripheral circuits. YES Is video input signal available at pins (63) and (60) of IC1301? Is Y signal output NO available at pin (39) and C signal output at pin (37) of IC1301 (AV SWITCH), respectively? YES Check the circuit between pin (19) of TUNER and pins (63)/(60) of IC1301. Check the circuit between pins (39)/(37) of IC1301 and pins (3)/(4) of SC1102.
NO
YES
Check the circuit between pin (41) of IC1301 and pin (20) of J1104.
Synchronization failure
PDP-R03U
NO Check IC803 and its peripheral circuits. NO Check the circuit between pins (35)/(34) of IC1901 and pins (66)/(65) of IC803. SUB NO Check IC1901 and its peripheral circuits. YES NO Check the circuit between pins (4)/(9) of IC801 and pins (2)/(44) of IC1901. Is VD2/HD2 input available at pins (20) and (19) of IC1901? YES NO Check IC801 and its peripheral circuits. Is HD2/VDM2 output available NO at pins (9) and (4) of IC802 (SUB VIDEO CHROMA)? Check IC802 and its peripheral circuits. NO Check the circuit between pins (4)/(9) of IC802 and pins (20)/(19) of IC1901. Is HDS/VDS output available at pins (21) and (22) on IC1901 (PLD)? NO Check IC1901 and its peripheral circuits.
MAIN
Is VDM/HDM output available at pins (28) and (29) of IC803 (RGB DECODER)?
YES 3
YES
YES
HDTV Is SP-VD/HD input available NO at pins (5) and (40) of IC1901? YES Is SP-HD/VD output available at pins (16) and (28) of IC604 (SYNC SEP)? NO Check IC604 and its peripheral circuits. Check the circuit between pins (28)/(16) of IC604 and pins (5)/(40) of IC1901.
YES
Is HD1/VD1 output available at pins (9) and (4) of IC801 (MAIN VIDEO CHROMA)?
No picture
5 No TV, video and component picture No SUB picture on dual screen Is input at pins (126), (136) and (141) of IC4 normal? YES Check CN6 and its peripheral circuits. Is digital output section of IC4 normal? YES NO NO NO Check CN6 and its peripheral circuits. YES NO Check IC4 and its peripheral circuits. YES NO Check IC25 and its peripheral circuits. YES Is digital output section of IC310 normal? Check IC310 and its peripheral circuits. NO Are TL207, TL208 and TL211 normal? NO Is digital output of IC25 normal? NO Is signal at pins (21), (22), (24), (25), (27), (28), (30) and (31) of IC413? (The signal is of high frequency (a little less than 1GHz). Pay due attention to it during observation.) YES NO Connecting cable or monitor is problem. PC I/F Unit (CPCi0056CE) internal problem is likely. E D C B
No PC picture
YES
YES
PDP-R03U
YES
7 A
7 8
111
7.1.2 DISASSEMBLY
A
1. Remove the six lock screws from the back of the top cabinet. Slide the top cabinet backward and detach it. 2. Remove the three lock screws from the front panel. Undo the three hooks at the top and the four hooks at the bottom, and detach the front panel. 3. Remove the two hexagonal shafts from the front shield. Undo the four hooks on both sides and detach the front shield. 4. Remove the three lock screws from the front unit and detach this unit. 5. Remove the one lock screw from the LED unit and detach this unit. 6. Remove the PC I/F unit and SR unit assemblies. 6-1. Remove the two hexagonal shafts each from the system cable (white) terminal and the RS-232C terminal, both on the PC I/F unit. 6-2. Remove two lock screws from the system cable (gray) terminal also on the SR unit. 6-3. Remove the two lock screws from the PC I/F unit bracket. 6-4. Remove the four lock screws from the PC I/F unit and SR unit assemblies. Take out these assemblies. 6-5. Remove the three lock screws from the brackets of the PC I/F unit and SR unit assemblies. Detach the shield. 6-6. Remove the six lock screws from the PC I/F unit. Detach this unit from the bracket. 6-7. Remove the two lock screws from the SR unit. Detach this unit from the bracket. 7. Remove the seven lock screws from the main unit and detach this unit.
Top cabinet
C
6-4 6-5 1
EMC Unit 4 SR Unit 6-7 Front Unit Power Unit 8-3 8-1 8-2 6-1 9-1 6-1 10
AV Unit
E
2 LED Unit 5 2 3 3 3
Bottom cabinet
112
1 2
PDP-R03U
3 4
8. Remove the AV unit. 8-1. Remove the coaxial cable from the antenna terminal. 8-2. Remove the three lock screws from the antenna terminals 8-3. Remove the six lock screws from the AV unit. 8-4. Remove the six lock screws from the AV unit and detach this unit. 9. Remove the EMC unit assemblies. 9-1. Remove the two lock screws from the EMC unit bracket. 9-2. Remove the two lock screws from the EMC unit and detach this unit. 10. Remove the three lock screws from the power unit and detach this unit.
PDP-R03U
5 6 7 8
113
7.2 IC
A The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams.
List of IC
VHiCXA2069Q-1, VHiMM1519XQ-1, RH-iX3370CEN1Q, VHiTB1274AF-1Q, VHiCXA2101Q-1, RH-iXA194WJZZ, VHiTA1318AF-1, VHiPD64082/-1, VHiCXD2093Q-1, RH-iX3473CEZZ, VHiFA3675F/-1, VHiZ86129S+-1Y, VHiZ86230S+-1Y
114
1 2
PDP-R03U
3 4
Pin Function
Pin No. 63 1 8 15 22 30 60 3 10 17 24 49 5 12 19 26 51 62, 2 9, 16 23, 29 59, 64 4, 11 18, 25 31, 61 53 41 44 56 39 58 47 37 52 43 38 54 45 40 6 13 20 27 7 14 21 28 32 33 34 36 Pin Name TV V1 V2 V3 V4 V5 V6 Y1 Y2 Y3 Y4 YIN1 C1 C2 C3 C4 CIN1 LTV, LV1 LV2, LV3 LV4, LV5 LV6, RTV RV1, RV2 RV3, RV4 RV5, RV6 VOUT1 VOUT3 V/YOUT2 YOUT1 YOUT3 COUT1 COUT2 COUT3 LOUT1 LOUT2 LOUT3 ROUT1 ROUT2 ROUT3 S2-1 S2-2 S2-3 S2-4 S-1 S-2 S-3 S-4 ADR SCL SDA DC OUT I/O I I I I I I I I I I I I I I I I I I I I I I I I O O O O O O O O O O O O O O I I I I I I I I I I I O Pin Function Video signal input. Composite video signal input A
Y/C-separated signal input terminal for luminance signal input. YIN1 to feed in the Y/C-separated signal of VOUT1 output.
Y/C-separated signal input terminal for chrominance signal input. CIN1 to feed in the Y/C-separated signal of VOUT1 output.
Video signal output terminal for composite video signal output. Video signal output terminal for selection between composite video signal output and luminance signal output by I2C Bus control. Video signal output terminal for luminance signal output. Video signal output terminal for chrominance signal output. C
Used to detect C signal-superimposed, S2-compatible DC level. 4:3 video signal when below 1.3V. 4:3 letterbox signal when between 1.3V and 2.5V. 16:9 image squeeze signal when above 2.5V. To be pulled down to GDN at 100K to produce 4:3 video signal when open. Used to switch between composite video and S signals. Detection results to be written in status register. S signal when below 3.5V. Composite video signal when above 3.5V. To be pulled up to 5V at 100K to produce composite video signal when open. Used to select I2C Bus slave address. 90H when below 1.5V. 92H when above 2.5V. 90H also when the terminal is open. I2C Bus signal input terminal. I2C Bus signal input terminal. Used to feed out S2-compatible DC level to be superimposed on COUT3 output. DC to be superimposed by connecting to COUT3 output via a capacitor. Control to be made by I2C Bus. S2-specified output impedance of 10 3K to be realized by adding an external resistance of 4.7K. Subcarrier trap circuit to be connected. Audio signal output mute terminal. Mute off when below 1.3V. Mute on when above 2.5V. Mute off when the terminal is open. Internal reference bias (Vcc/2) terminal. To be connected to GND with a capacitor in between.
55 46 48 50
I I I I
PDP-R03U
5 6 7 8
115
VHiMM1519XQ-1 (AV UNIT : IC1401) Component Input Video Switch Block Diagram
116
1 2
PDP-R03U
3 4
Pin Function
Pin No. Pin Name 1 VIDEO 1-L1 2 VIDEO 1-L2 3 VIDEO 1-L3 11 VIDEO 2-L1 12 VIDEO 2-L2 13 VIDEO 2-L3 21 VIDEO 3-L1 22 VIDEO 3-L2 23 VIDEO 3-L3 4, 14, 39, 45, 52, VCC 58 51 AVCC 5 VIDEO 2-Y 15 VIDEO 3-Y 53 TUNER-Y 59 VIDEO 1-Y 24 DGND 6, 8, 16, 18, 33, GND 35, 37, 41, 43, 47, 49, 54, 56, 60, 62 7 VIDEO 2-Pb 9 VIDEO 2-Pr 17 VIDEO 3-Pb 19 VIDEO 3-Pr 55 TUNER-Pb 57 TUNER-Pr 61 VIDEO 1-Pb 63 VIDEO 1-Pr 10 VIDEO 2-SW 20 VIDEO 3-SW MONO-SW 32 64 VIDEO 1-SW 25 ADDRESS SDA 26 27 SCL 28 DVCC L3 OUT 29 30 L2 OUT 31 L1 OUT Pr OUT 3 34 36 Pb OUT 3 38 Y OUT 3 Pr OUT 2 40 42 Pb OUT 2 44 Y OUT 2 Pr OUT 1 46 Pb OUT 1 48 50 Y OUT 1 I/O I I I I I I I I I I I I I Pin Function Line input of D-terminal A
Y-signal input
GND
I I I I I I I I I I I I I I/O I O O O O O O O O O O O O
Slave address select pin Data input of I2C bus Clock input of I2C bus Digital power supply (5V) Line output for monitor D
PDP-R03U
5 6 7 8
117
RH-iX3370CEN1 (AV UNIT : IC2501) Multi Standard Sound Processor Block Diagram
118
1 2
PDP-R03U
3 4
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11, 12, 13 14, 15, 16 17 18, 19, 20 21 22, 23 24 25 26 27 28 29 30 31, 32 33 34 35 36 37 38 39 40 41, 42 43, 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61, 62 63, 64 65, 66 67 68 69 70 71 72 73 74 75, 76 77 78 79 80 Pin Name NC I2C_CL I2C_DA I2S_CL I2S_WS I2S_DA_OUT I2S_DA_IN1 ADR_DA ADR_WS ADR_CL DVSUP DVSS I2S_DA_IN2 NC RESETQ NC DACA_R DACA_L VREF2 DACM_R DACM_L NC DACM_SUB NC SC2_OUT_R SC2_OUT_L VREF1 SC1_OUT_R SC1_OUT_L CAPL_A AHVSUP CAPL_M NC AHVSS AGNDC NC SC4_IN_L SC4_IN_R ASG4 SC3_IN_L SC3_IN_R ASG2 SC2_IN_L SC2_IN_R ASG1 SC1_IN_L SC1_IN_R VREFTOP NC MONO_IN AVSS NC AVSUP ANA_IN1+ ANA_INANA_IN2+ TESTEN XTAL_IN XTAL_OUT TP AUD_CL_OUT NC D_CTR_I/O_1 D_CTR_I/O_0 ADR_SEL STANDBYQ I/O I/O I/O I/O I/O O I O O O I I O O O O O O O O O I I I I I I I I I I I I I I O O I/O I/O I I Pin Function Not connected I2C clock I2C data I2S clock I2S word strobe I2S data output I2S1 data input ADR data output ADR word strobe ADR clock Digital power supply 5V Digital ground I2S2-data input Not connected Power-on-reset Not connected Headphone out, right Headphone out, left Reference ground 2 Loudspeaker out, right Loudspeaker out, left Not connected Subwoofer output Not connected SCART 2 output, right SCART 2 output, left Reference ground 1 SCART 1 output, right SCART 1 output, left Volume capacitor AUX Analog power supply 8V Volume capacitor MAIN Not connected Analog ground Analog reference voltage Not connected SCART 4 input, left SCART 4 input, right Analog Shield Ground 4 SCART 3 input, left SCART 3 input, right Analog Shield Ground 2 SCART 2 input, left SCART 2 input, right Analog Shield Ground 1 SCART 1 input, left SCART 1 input, right Reference voltage IF A/D converter Not connected Mono input Analog ground Not connected Analog power supply 5V IF input 1 IF common(can be left vacant, only if IF input 1 is also not in use) IF input 2(can be left vacant, only if IF input 1 is also not in use) Test pin Crystal oscillator Test pin Audio clock output (18.432MHz) Not connected D_CTR_I/O_1 D_CTR_I/O_0 I2C Bus address select Stand-by (low-active) F A
PDP-R03U
5 6 7 8
119
120
1 2
PDP-R03U
3 4
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 Pin Name CVBS1/Y1-IN SYNC-IN CVBS-OUT VS COMB Y-IN D-VDD COMB C-IN D-GND HS SCP Yvi-IN SYNC-VCC SCL SDA YS3 (RGB1-in) SYNC-GND Cr1-IN Cb1-IN Y1-IN CLP-FIL Y-OUT Cb-OUT Cr-OUT YS1 (YVbC2-IN) B1-IN G1-IN R1-IN Y/C-GND Cr2-IN Cb2-IN Y2-IN Y/C-VCC B2-IN G2-IN R2-IN YS2/YM (RGB2-IN) FIL. XTAL C3-IN APC-FIL CVBS3/Y3-IN ADDRESS C2-IN CVBS2/Y2-IN COMB SYS Fsc-OUT AFC-FIL C1-IN I/O I I O O I I O O O I I/O I I I I O O O I I I I I I I I I I I I I I I I O O I Pin Function CVBS1 or Y1-IN signal input. Sync signal input. CVBS or Y+C signal output terminal. Counted-down vertical sync signal output. Input of Y signal coming from comb filter. Open when not used. DDS/BUS/V-CD/H-CD block power supply. DC5V (standard). Input of C signal coming from comb filter. Open when not used. DDS/BUS/V-CD/H-CD block grounding terminal. H-AFC-processed horizontal sync signal output. Sand Castle Pulse output. Clamping pulse and horizontal blanking pulse outputs. Output of sync input Y signal selected with Video-SW. SYNC/HVCO block power supply. DC5V (standard). I2C BUS SCL terminal. I2C BUS SDA terminal. Selector switch for main signal and RGB1 input signal. YS3 input effective only when RGB1-ENB is set at enable in bus setting. SYNC/HVCO block grounding terminal. Y1/Cb1/Cr1 signal input. A
Selector switch for main signal and Y/Cr/Cb2 input signal. RGB1 signal input. This input is selected at YS3 or I2C BUS. C
Y/C/Text/Video-SW/1HDL block grounding terminal. Y2/Cb2/Cr2 signal input. This input is selected at YS1. Open when not used. Y/C/Text/Video-SW/1HDL block power supply. DC5V (standard) RGB2 signal input. This input is selected at YS2. Open when not used. Selector switch for main signal and RGB2 input signal. Connected to Y/C-VCC terminal. 16.2MHz crystal oscillator to be connected. Chroma signal input. Open when not used. Chroma demodulation filter to be connected. CVBS3 or Y3 signal input. Open when not used. Slave address to be preset. Chroma signal input. Open when not used. CVBS2 or Y2 signal input. Open when not used. Received color system judgment result to be output from this pin and pin 46. Subcarrier output. AFC detection filter to be connected. Chroma signal input. Open when not used. D
PDP-R03U
5 6 7 8
121
VHICXA2101Q-1 (MAIN UNIT : IC803) Baseband Video Signal Processor Block Diagram
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Pin Name IN2-H IN2-V IN2-1 IN2-2 IN2-3 Vcc-MAT IN3-H IN3-V IN3-1 IN3-2 IN3-3 GND-MAT IN4-H IN4-V IN4-1 IN4-2 IN4-3 I/O I I I I I I I I I I I I I I I Pin Function IN2-H : Independent horizontal sync signal input terminal. IN2-V : Independent vertical sync signal input terminal. IN2 line signal input terminal.
Selector line and sync processor line power terminal. IN3-H : Independent horizontal sync signal input terminal. IN3-V : Independent vertical sync signal input terminal. IN3 line signal input terminal.
Selector line and sync processor line grounding terminal. IN4-H : Independent horizontal sync signal input terminal. IN4-V : Independent vertical sync signal input terminal. IN4 line signal input terminal.
122
1 2
PDP-R03U
3 4
Pin No. 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 37 39 36 38 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
Pin Name V-PH IN5-H IN5-V IN5-1 IN5-2 IN5-3 H-PH YG-OUT YG-IN IREF-SYNC VS-OUT HS-OUT Vcc-OUT SCP-IN VTIM-IN HP-IN GND-OUT R-OUT G-OUT B-OUT R-SH G-SH B-SH IK-IN PABL-FIL ABL-FIL ABL-IN YS/YM-1 LR1-IN LG1-IN LB1-IN YS/YM-2 LR2-IN LG2-IN LB2-IN ADDRESS DPIC-C SCL SDA DPIC-MUTE CLP-C VM-OUT VM/SHP/COL-OFF YCBCR-SW ECR-IN ECB-IN EY-IN V1-IN H1-IN CR1-IN CB1-IN Y1-IN GND-SIG IREF-YC Vcc-SIG SELCR-IN SELCB-IN SELY-IN SELY-OUT SELCB-OUT SELCR-OUT SELH-OUT SELV-OUT
I/O I I I I I O I O O O I I I O O O O
Pin Function Vsync peak holding capacitor connection terminal. IN5-H : Independent horizontal sync signal input terminal. IN5-V : Independent vertical sync signal input terminal. IN5 line signal input terminal.
Hsync peak holding capacitor connection terminal. Sync separation composite video signal output terminal. Sync separation composite video signal input terminal. Reference current setting terminal (about 4.6V) Used to select between IN1-line HV and IN2/IN5-line selector output HV by I2C BUS YCBCR/MAT and feed out the signal in positive polarity. RGB line power terminal. Sand-Castle-Pulse input terminal. V timing pulse input terminal. H pulse input terminal. RGB line grounding terminal. RGB signal output terminal. Output to be made at 2.6Vp-p with 100IRE white input. RGB AKB sample-and-hold terminal.
I I I I I I I I I I I O I I I I I I I I I I I I O O O O O
Reference pulse to return to this terminal. Peak ABL peak holding terminal. Used to form LPF for ABL control signal. ABL control signal input terminal. YM1/YS1 control input terminal. Input level to be of 3 values. VM turning-off function also available when YM and YS have reached their specified values. Analog RGB1 signal input terminal.
YM2/YS2 control input terminal. Input level to be of 3 values. VM turning-off function also available when YM and YS have reached their specified values. Analog RGB2 signal input terminal.
I2C BUS slave address setting terminal. Capacitor to be connected for grounding in order to detect the black signal in dynamic picture (black stretching). I2C BUS standard SCL (Serial Clock) input terminal. I2C BUS standard SDA (Serial Data) input terminal. Used to control MUTE of dynamic picture (black stretching). Y line clamp capacitor connection terminal. VM output terminal to feed out Y signals differential waveform in positive polarity. Used to turn off VMASHARPNESS and COLOUR. Input level to be 3 values Used to switch between INT and EXT SW input signals. External input terminal to be selected at High level. External Y, Cb, and Cr input terminals.
IN1-line HV input terminal. Positive-polarity input. IN1-line Y, Cb, and Cr input terminals. E Y color difference signal processor grounding terminal. Reference current setting terminal (mainly for Y color difference signal processing line). Y color difference signal processor power terminal. Used to feed in selector outputs Y, Cb, and Cr through clamp capacitor.
IN2- thru IN5-line selector output terminals. Used to feed out Y-, Cb-, and Cr-converted signals. IN2 thru IN5 selector HV output terminals. F
PDP-R03U
5 6 7 8
123
RH-iXA194WJZZ (MAIN UNIT : IC1901) PLD (Programmable Logic Device) Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 Pin Name TDI VD1 SP_HD GND SP_VD SP_CP TMS HD3 VCC VD3 GND MODEA MODEB MODEC SELA GND VCC SELO HD2 VD2 HDS VDS US_VD GND US_HD TCK TEXT_VD TEXT_HD VCC GND PL_BLK TDO PLCP PL_HD PL_VD GND GCLK1 OE1 GCLRn OE2/GCLK2 VCC CNR_CP CNR_HBLK HD1 I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I I I I I/O I/O I/O Pin Function
Ground
Ground
124
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
125
Pin Function
Pin No. A 3 1 11 4 2 10 5 6 7 8 20 B 9 24 12 13 15 14 16 17 18 21 19 22 23 Pin Name HD1-IN HD2-IN HD3-IN VD1-IN VD2-IN VD3-IN ANALOG GND AFC FILTER HVCO VCC DAC1 (V. SYNC output) DAC2 (H/C. SYNC output) DAC3 CP-OUT HD1-OUT HD2-OUT DIGITAL GND SDA SCL ADDRESS SW SYNC1-IN SYNC2-IN VD1-OUT VD2-OUT I/O I I I I I I O O O O O O I/O I I I I O O Pin Function Input the horizontal synchronizing signal. Its polarity corresponds to both positive and negative. Input from this pin does not be synchronized internally. Input the horizontal vertical signal. Its polarity corresponds to both positive and negative. Input from this pin does not be synchronized internally. The GND pin for analog circuit block. Connect the filter for horizontal AFC. The frequency of the horizontal output is varied by the volyage at this pin. Connect the ceramic oscillator for horizontal oscillator. The VCC pin. (9.0V) DAC1 output pin. When TEST mode, VD or vertical sync signal to frequency counter circuit is output. DAC2 output pin. When TEST mode, HD or composite sync signal to frequency counter circuit is output. DAC3 output pin. This pin is open-collector system. When TEST mode, test pilses for the shipping is output. Clamp pulse output pin. CP mode at synchronization circuit is output. HD output pin. This pin is open-collector system. HD1/HD2 does not be synchronizing and they are output from this pin. Its polarity is switched by BUS write function. The GND pin for logic circuit block. The SDA pin for IC BUS. The SCL pin for IC BUS. Slave address switch. Input a signal to separate sync signal. VD output pin. This pin is open-collector system. VD1/VD2 does not be synchronizing and they are output from this pin. Its polarity is switched by BUS write function.
126
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
127
Pin Function
A Pin No. 1, 40, 55, 80 45, 64, 100 98 99 2-9 10 11 12 13-28 29 30 31 32 33-36 37 38 39 41-44 46 47 48 49 50 51 52 53 54 56 57 58 59 60 61 62 63 65-74 D 75 76 77 78 79 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 ALTF CSI TEST LINE KIL AVDD CBPC ACO AYO CBPY AGND AGND AYI VCLY VRBY VRTY AVDD AVDD VRTC VRBC ACI AGND O I I I I O O O O I O O O O O I Pin Name DGND DVDD MRAS MA8 MA7-MA0 MCAS MWE MOE MIO15-MIO0 DGND XI XO DVDD HO3-HO0 HWCK HRCK HRST HI3-HI0 AVDD FSCO AGND AGND FSCI CPLL RPLL AVDD CKMD CLK8 RSTB SLA0 SCL SDA ST0 ST1 NSTD DYCO0-DYCO9 I/O O O O O O O I/O I O O O O O I I I O/I I I I I/O O O O I/O Pin Function Digital section grounding. Digital section power. External EDO memory RAS output. External EDO memory address output. External EDO memory address output. External EDO memory CAS output. External EDO memory WE output. External EDO memory OE output. External EDO memory data input/output. fsc generator digital section grounding. fsc generator reference clock input. fsc generator reference clock reverse output. fsc generator digital section power. External field memory data output. External field memory write clock output. External field memory read clock output. External field memory reset signal output. External field memory input. fsc generator DAC power. fsc generator fsc output. fsc generator DAC grounding. 8fsc-PLL grounding. 8fsc-PLL fsc input. 8fsc-PLL filter output. Test input. 8fsc-PLL power. CLK8 test mode select (L: Usual, H: Test mode). 8fsc clock output (8fsc clock input at CLK8 test mode). System reset input (Active Low). (Active-Low reset pulse input from outside) PC bus slave address select input (L: B8/B9h, H: BA/BBh). PC bus clock input (To be connected to systems SCL line). PC bus clock input/output (To be connected to systems SDA line). nternal signal monitor output. Internal signal monitor output. Non-standard detection monitor output. (L: Judged standard, H: Judged non-standard) EXADINS=0: Digital Y/C signal alternate output. EXADINS=1: External Y-ADC data input. (Non-used lower bits to be connected to GND with resistor in between) EXADINS=0: Digital Y/C signal alternate flag output (L: Y, H: C). EXADINS=1: External Y-ADC 4fsc clock output. Composite sync input (Active Low). IC select test terminal (L: Usual operation, H: Test mode). (Connected to GND) Forced line-to-line process select input (L: Usual operation, H: Forced line-to-line processing). External killer input (L: Usual operation, H: Forced Y/C separation stop). Y-DAC, C-DAC power. C-DAC phase compensation output. C-DAC analog C signal output. Y-DAC analog Y signal output. Y-DAC phase compensation output. Y-DAC, C-DAC grounding. Y-ADC grounding. Y-ADC analog composite signal/Y signal input. Y-ADC clamp potential output. Y-ADC bottom reference voltage output. Y-ADC top reference voltage output. Y-ADC power. C-ADC power. C-ADC top reference voltage output. C-ADC bottom reference voltage output. C-ADC analog C signal input. C-ADC grounding.
128
1 2
PDP-R03U
3 4
PDP-R03U
5 6 7 8
129
Pin Function
Pin No. A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15, 28 32, 33, 35, 16, 27, 34 18,23-26,29,36 17 19 20 21 22 30 31 37 38 Pin Name CLPO ADIN RB ADVS ADVD RT ACO DAVD AYO DAVS VG VRF IRF VB TEST TEST DVDD DVSS MOD2 MOD1 VEH3 VEH2 VEH1 APCN TRAP FIN CKSL I/O O I O O O O O I O O I I I I I I I I I I I Pin Function Built-in clamp circuit current output terminal. To be connected to ADIN when built-in clamp is used. Comb filter analog input (A/D converter) terminal. A/D converter reference bottom voltage. (standard 0.52V) A/D converter analog grounding terminal. A/D converter analog power terminal. (5.0V) A/D converter reference top voltage. (standard 2.6V) Analog chroma signal output terminal. Resistance to be added between this pin and GND (DAVS) for obtaining the output. D/A converter analog power terminal. (5.0V) Analog luminance signal output terminal. Resistance to be added between this pin and GND (DAVS) for obtaining the output. D/A converter analog grounding terminal. D/A converter terminal. Y,C ch D/A converter output full-scale setting terminal. x16 resistance to be connected against D/A converter output resistance R. D/A converter terminal. Test terminal. Usually fixed at Low. Test terminal. Usually open or fixed at Low. Digital power terminal. (5.0V) Digital grounding terminal. Y/C separation mode setting terminal. MOD2 MOD1 L L Most suitable process H L BPF separation mode Vertical contour enhancement setting terminal. VEH3 VEH2 VEH1: Presettable in 8 steps from LLL(Off) to HHH(Max). Horizontal aperture correction circuit setting terminal. L: off, H: on Trap filter circuit setting terminal. L: off, H: on Clock input terminal. Burst lock (4fsc) to be fed in with built-in PLL system. Burstlocked 4fsc signal to be fed in when PLL is not used. PLL control terminal. L : PLL not used. FIN input clock (4fsc) to be fed in. H : PLL used. VCO oscillator outputs 4fsc clock to be fed in. FIN input fsc to be selected. L: fsc input, H: 2fsc input. Either at L or H when 4fsc is fed in PLL (without built-in PLL). Clock (4fsc) output terminal. A/D converter clock input terminal. To be connected to MCKO. PLL phase comparator output terminal. Open when PLL is not used. PLL analog grounding terminal. VCO control voltage input terminal. To be connected to PLVS when PLL is not used. PLL analog power terminal. (5.0V) Clamp D/A converter analog power terminal. (5.0V) Clamp circuit enable terminal. L: Clamp on, H: Clamp off Clamp D/A converter analog grounding terminal.
39 40 41 42 43 44 45 46 47 48
PLSL MCKO ADCK CPO PLVS VCV PLVD CLVD CLPEN CLVS
I O I O I I
130
1 2
PDP-R03U
3 4
RH-iX3473CEZZ (ASSY: IC804, IC810) RH-iX3474CEZZ (ASSY: IC811) Monolithic Video Filter * RH-iX3473CEZZ is 6.7MHz at Cut-off frequency. * RH-iX3474CEZZ is 30MHz at Cut-off frequency. Block Diagram
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Pin Name A/B MUX RINA/YINA GND VCC RINB/YINB GINA/UINA GINB/UINB BINA/VINA BINB/VINB BOUT GOUT VCCO ROUT GNDO DISABLE SYNC IN I/O I I I I I I O O O I I Pin Function Logic input pin to select between Bank <A> and Bank <B> video inputs. This pin is internally pulled high. Unfiltered analog R- or Y-channel input for Bank <A>, Sync must be provided at SYNC IN pin. Analog ground. Analog 5V supply. Unfiltered analog R or Y-channel input for Bank <B>, Sync must be provided at SYNC IN pin. Unfiltered analog G or U-channel input for Bank <A>, Sync must be provided at SYNC IN pin. Unfiltered analog G or U-channel input for Bank <B>, Sync must be provided at SYNC IN pin. Unfiltered analog B or V-channel input for Bank <A>, Sync must be provided at SYNC IN pin. Unfiltered analog B or V-channel input for Bank <B>, Sync must be provided at SYNC IN pin. Analog B or V-channel output. Analog G or U-channel output. 5V power supply for output buffers. Analog R or Y-channel output. Analog ground. Disable/Enable pin. Turns the chip off when logic high. Internally pulled low. Input for an external H-sync logic signal for filter channels. CMOS level input. Active High. D
PDP-R03U
5 6 7 8
131
132
1 2
PDP-R03U
3 4
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 Pin Name VCC1 RT CT CS3 CS5 CS4 CS1 CS2 VREF CREF VREG IN2FB2 IN1FB1 IN5+ IN5FB5 IN6FB6 IN3+ IN3FB3 IN4+ IN4FB4 CP GND TLSEL CNT5 CNT4 CNT2 CNT3 CNT1 VCC2 VDRV PGND1 OUT1S OUT1 OUT4 OUT3 OUT2S OUT2 OUT6S OUT6 OUT5 OUT5S PGND2 I/O O O O I O I O I I O I O I I O I I O I I I I I I I O O O O O O O O O O O Pin Function Power supply for control circuit. Oscillator timing resistor. Oscillator timing capacitor. Soft start for Ch.3 & Ch.4. Soft start for Ch.6. Soft start for Ch.5. Soft start for Ch.1 Soft start for Ch.2. Reference voltage output. Capacitor for reference voltage output. Regulated for voltage output. Ch.2 inverting input to error amplifier. Ch.2 output of error amplifier. Ch.1 inverting input to error amplifier. Ch.1 output of error amplifier. Ch.5 non-inverting input to error amplifier. Ch.5 inverting input to error amplifier. Ch.5 output of error amplifier. Ch.6 inverting input to error amplifier. Ch.6 output of error amplifier. Ch.3 non-inverting input to error amplifier. Ch.3 inverting input to error amplifier. Ch.3 output of error amplifier. Ch.4 non-inverting input to error amplifier. Ch.4 inverting input to error amplifier. Ch.4 output of error amplifier. Timing capacitor for timer latch delay. Ground. Ch.3 & Ch.4 timer latch selection(Low:disable). Ch.6 ON/OFF function. Ch.5 ON/OFF function. Ch.2 ON/OFF function. Ch.3 & Ch.4 ON/OFF function. Ch.1 ON/OFF function. Power supply for output stage. Bias for logic circuit of output. Power ground. Ch.1 source electrode of output stage. Ch.1 output(for Pch-MOSFET) Ch.4 output(for Pch-MOSFET) Ch.3 output(for Pch-MOSFET) Ch.2 source electrode of output stage. Ch.2 output(for Pch-MOSFET) Ch.6 source electrode of output stage. Ch.6 output(for Pch-MOSFET) Ch.5 output(for Pch-MOSFET) Ch.5 source electrode of output stage. Power ground. A
PDP-R03U
5 6 7 8
133
134
1 2
PDP-R03U
3 4
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Pin Name Vss GREEN BLUE SEN HIN SMS VIDEO CSYNC LPF RREF Vss(A) Vdd Vin/INTRO SDA SCK SDO BOX RED I/O O 0 I I I I O O I I/O I/O I O O O Pin Function Power Supply GND. Video Output Video Output Serial Enable Horizontal In Serial Mode Select Composite Video Composite Sync Loop Filter Resistor Reference Power Supply (Analog) GND. Power Supply Vertical In/Interrupt Out Serial Data Serial Clock Serial Data Out OSD Timing Signal Video Output A
PDP-R03U
5 6 7 8
135
136
1 2
PDP-R03U
3 4
Pin Function
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Pin Name IICSEL H SEL Xout NRST HIN/XIN Vss VIDEO CSYNC LPF RREF Vss (A) Vdd PB SDA SCLK NC INTRO NC I/O I I 0 I I I O O I O I/O I O Pin Function IIC Adderss Select HIN/XIN Select XTAL Output RESET Horizontal In/XTAL In Power Supply (Digital) GND. Composite Video Composite Sync Loop Filter Resistor Reference Power Supply (Analog) GND. Power Supply +5V Program Blocking Serial Data Serial Clock No Connect Interrupt Output No Connect A
PDP-R03U
5 6 7 8
137
7.3 IC DESCRIPTIONS
A
Description of Main ICs IC1301 (CXA2069Q) This IC is a 7-input, 3-output selector. The video signals other than those for the PC and components, which have been input from each input connector and the tuner, and all the audio signals are sent to the IC1301 and then selected. The video signals sent to the IC1301 are then input to the YC separation circuits, IC7001 (main) and IC402 (sub). The audio signals are input to the PC I/F Unit via IC2501 (sound processor). IC1401 (MM1519XQ) This IC is a 4-input, 3-output video selector for component input. The VIDEO-1/3 Y/Pb/Pr signals, RGB component input and TV signal are input to the IC1401. The output signals go to the main, sub, and component channels. IC2501 (IX3370CE) This IC is used to decode audio signals. It serves as both the S-IF decoder and the selector for the input audio data. IC801/IC802 (TB1274AF) This IC is intended for color TV brightness, chroma demodulation and sync processing. It receives the main and sub brightness signals and color signals from IC7001 (main) and IC402 (sub) in the preceding stage, and gives out color difference signals.
IC803 (CXA2101Q) With a high-performance picture correction circuit incorporated, this IC consists of a base band video signal processing section for color difference input and a video switch (including HV sync signal processing). Input selection is performed by INPUT-SEL (IIC BUS). The Y/Pb/Pr signals of Y/Cb/Cr/HD and their respective HV sync signals are input to each line. As the multi-scanning compliance range, a horizontal scanning frequency of 15-60 kHz can be input. IC1901 (IXA194WJ) This IC is FPGA for the synchronizing system. It creates sand castle pulses for IC803 and generates horizontal blanking signals.
IC604 (TA1318AF) This IC synchronizes TV component signals. The IC604 incorporates the necessary functions for measuring the frequency of input signals and synchronous replay into a single chip, and is applicable for horizontal synchronous replay (15.75, 31.5, 33.75, and 45 kHz) and vertical synchronous replay (525I, 525P, 625I, 750P, 1125I, 1125P, PAL 100 Hz, and NTSC 120 Hz). IC7001 (PD64082) Through 3-dimensional NTSC signal processing, the PD64082 performs high-precision Y/C separation for main video signals sent from the IC1301. In combination with a 4Mbit EDO (Hyper Page Mode) DRAM, this IC forms 3-dimensional Y/C separation and YNR/CNR system.
IC402 (CXD2093Q) This IC is a comb filter in the applicable field. Being a single high-precision Y/C chip, the 3-line comb filter performs the Y/C separation of the sub channel video signals that have been output from IC1301. IC804/IC810 (IX3473CE) The IC804 is a 6.7 MHz low-pass filter, incorporating a 6 dB amplifier, for the sub screen. The IC810, on the other hand, is a 6.7 MHz low-pass filter, also incorporating a 6 dB amplifier, for the main screen (for SDTV). IC811 (IX3474CE) This IC is a 30 MHz low-pass filter, incorporating a 6 dB amplifier, for the main screen (for HDTV).
138
1 2
PDP-R03U
3 4
IC1701 (FA3675CE) This IC is designed to control the 6-channel PWM switching regulator. With 5 step-up switching regulator lines incorporated, the IC converts +10V to +2.5V, +3.3V and +5.8V. Also with a step-down switching regulator line incorporated, the IC converts +10V to +6.0V, -5.0V, +12V and +35V. The lines are individually turned on and off. IC1602 (Z86129S) The Z86129S is built in the TV decoder circuit and serves to process the vertical blanking interval (VBI) data that has come from the video signal field of the data corresponding to the transmission format defined by EIA-608. The data flowing along Line 21 is composed of the data of some multiplexed data channels. Field 1 has 4 data channels: 2 caption channels and 2 text channels. Field 2 has 5 additional data channels: 2 caption channels, 2 text channels and expansion data service (XDS) channel. On any of these 9 data channels, the data transmitted can be recovered and displayed.
IC1601/IC1603 (Z86230S) The Z86230S functions for the process expansion data service (XDS) in Field 2 during the vertical blanking interval (VBI). The XDS data is processed in order to specify the Program Blocking (PB) signal or recovered XDS data packets. The on-chip XDS filter in the Z86230S enables to recover the XDS data packets only for programming. The Z86230S is compatible with monitors (Picture-In-Picture) for violence blocking and other XDS data service.
PDP-R03U
5 6 7 8
139
IC4 (CXA3506R) This IC is an A/D converter that incorporates a 3-channel, 8-bit, 120 MSPS amplifier and PLL. It is used for the video signals input to the I/F board on the main channel in the 1-screen and 2-screen modes, and also for the video signals input from the front for the PC. The video signals (analog RGB) from the CN6 are input to IN1 of IC4. For the PC, the video signals (analog RGB) from CN8 are input to IN2 of IC4. The input video signals are converted into digital signals and then sent to IC25. IC310 (TLC5733A) This IC is a 3-channel, 8-bit, 20 MSPS A/D converter. It is used for the sub-channel of the video signals input to the PC I/F Unit in the 2-screen mode. The video signals (analog Y, Cb, Cr) from CN6 are input to IC310. The video signals input to this IC are converted into digital signals and then sent to IC25. IC25 (IX3434CE) This IC performs the I/P conversion and scaling to match the digitalized video with the output resolution, and also the data conversion. It has two input lines, V0 and V1. The V0 line is used to process the RGB, composite, and skirt signals input to the 480i and 580i components for the sub-channel in the 2-screen mode. The V1 line is used to process all the signals as well as V1 for the main channel in the 1-screen and 2-screen modes. The IC25 detects what resolution is input from the input synchronizing signal; creates H synchronization in accordance with the frequency division ratio; creates the clamp signal in accordance with the input synchronizing signal; and performs the data matrix conversion. The video signals input to this IC is sent to IC413. IC413 (SiL168) This IC is a panel link transmitter. It converts the 8-bit RGB video data output from IC25 into the differential TMDS signals and then digitally transmits the converted signals to the monitor. The TMDS signals are transmitted at the frequency 10 times higher than the clock frequency. IC1 (IX3270CE) This IC is a 1-chip RISC microprocessor. It performs communication with the monitor and operates the system. The IC1 also controls each IC in the AVC System and partially manages the power source. IC405 (uPD4721) This IC is an RS-232 line driver receiver conforming to the EIA/TIA-232-E standard. The IC405, when connected to a PC, allows for externally controlling the system. It is also applicable for upgrading IC1.
140
1 2
PDP-R03U
3 4
8. PANEL FACILITIES
Media Receiver
Front view
PC INPUT terminal (ANALOG RGB) INPUT 4 terminal (VIDEO) CLEAR*
A
Push CLEAR lightly with the tip of a pointed object like a ballpoint pen.
MEDIA RECEIVER PDP-R03U
STANDBY/ON
POWER
* If youre having problems operating the Media Receiver and want to r eturn to normal screen, even when it stays on (the indicator lights gr een), press CLEAR on the Media Receiver. Pressing CLEAR resets the System as shown below.
AV SELECTION r sets to STANDARD e TV channel returns to initial channel setting(Air:2ch, Cable:1 or 2ch) Multiscreen resets to normal Audio setting initializes SRS resets to Off. Image position initializes NOTE Pressing CLEAR will not work if the System is in standby mode but the indicator lights r ed. Pressing CLEAR will not delete channel pr eset or secret number. See for initializing factory preset settings when you know your secret number. See for initializing factory preset values when you have for gotten your secret number.
Rear view
Antenna input terminal (A) Antenna input terminal (B) INPUT 3 COMPONENT VIDEO terminals (Y, PB, PR) INPUT 3 terminal (VIDEO) INPUT 3 terminals (AUDIO) INPUT 1 terminal (S-VIDEO) INPUT 1 terminal (VIDEO) INPUT 1 COMPONENT VIDEO terminals (Y, PB, PR) INPUT 1 terminals (AUDIO) SYSTEM CABLE terminal (WHITE)
SYSTEM CABLE
(WHITE)
INPUT 2 OUT ANT/CABLE 75 MONITOR OUTPUT S-VIDEO VIDEO R-AUDIO-L S-VIDEO VIDEO R-AUDIO-L
MONITOR OUTPUT terminal (S-VIDEO) MONITOR OUTPUT terminal (VIDEO) MONITOR OUTPUT terminals (AUDIO)
AC INLET terminal SYSTEM CABLE ter inal m (GRAY) CONTROL terminals (IN/OUT)
F
PDP-R03U
5 6 7 8
141
1 24 12 2 3 4 5
TV
13 Mode switch 14 15
CC 5 SUB CH
MTS
16 17
DISPLAY
SLEEP
EDIT/ LEARN
2 5 8 0
3 6 9
CH ENTER
4 7
18
4 5 6 7 8 9 10 11 12 13 14
19 20 21
15 16 17
7
C
5
CH
CH RETURN
+
VOL
8 9 10 11
MUTING
TV/SAT/DVD MENU
SET/ ENTER
DTV/SAT INFO
22 23
18 19 20 21 22 23
FAVORITE CH A B C
VCR REC
INPUT
VOL
VOL+
RECEIVER
PLASMA DISPLAY
24 NOTE When using the remote control unit, point it at the Plasma Display.
142
1 2
PDP-R03U
3 4