Professional Documents
Culture Documents
M/s. Anabond Ltd, Type II , No. 36, Dr. V.S.I. Campus, Thiruvanmiyur, Chennai 600 041. Ph: +91 44 23460041 / 42 Fax: +91 44 23460048 E-mail: marketing@anabond.com
PRODUCT INFORMATION ON
Anabond 618E
Liquid Gasket
PRODUCT DESCRIPTION
Anabond 618E is a single component dimethacrylate ester based anaerobic adhesive systems, specially designed for flange sealing on rigid flanges such as transmissions, cast metal housings etc. Like any other anaerobic adhesives, this product also gets cured in the absence of air when confined between two closely fitting metal surfaces and prevents leakage of fluids or gases by forming impervious barriers. This product is available in the form of high viscous paste, conveniently packed in PP tubes. The consistency of this material is well suited for applications where a liquid anaerobic adhesive may be too fluid to remain on a part. This gasket sealant eliminates the need for very smooth surface & is far superior to conventional gaskets such as asbestos, cork etc., The cured sealant offers excellent resistance to fuels, solvents and lubricants. It also provides resistance to low pressures immediately after application & assembly of flanges. This product withstand heavy vibration, shock resist & impact load. Typically used as a form-in-place gasket on rigid flanged connections, e.g. gearbox and engine casings, etc.
METHOD OF USE
Clean mating components thoroughly & apply bead of sealant one side of the male flange surface. Mate the female flange and clamp & allow it to cure. TYPICAL PROPERTIES
Sl. No 1. 2. 3.
Properties Appearance Colour Handling cure @ 25s2|C i. M10 Black bolt & nut ii. M10 White passivated
Units ---
Minutes Hours
2 10 35 - 50 12 1-3 05 15 (1.01 2.03) 8 15(0.81 1.52) 9 10(85.29 130.50) >120 200000 - 800000 -55 to +120 1.0 0.25
4.
Functional cure @ 25s2|C i. M10 Black bolt & nut ii. M10 White passivated Breakaway torque @ 25s2|C i. M10 Black bolt & nut ii. M10 White passivated Compressive shear strength @ 25s2|C Pin & Bush Pressure resistance, (Flange method) Viscosity @ 25C(sp.no-7,rpm-5) Temperature Resistance Specific gravity @ 25C Gap filling
5.
6. 7. 8. 9. 10. 11.
: Twelve months from the date of manufacture, if stored below 35 C. STORAGE : Store in cool dry place away from heat source and direct sunlight. PACKING : 250 g in LDPE tube & cartridge. The information contained herewith based on the present state of our knowledge. However, testing under condition by the user is recommended. AL/01-08/00 SHELF LIFE