Professional Documents
Culture Documents
Name Date/Place of Birth Phone number Mobile number Nearest Airport Home address Email address Nationality Languages Passport number Date of application
: : : : : : : : : : : Insert photo
Profile In not less than 100 words tell us a bit about yourself , not diving related
Reference (industry related, must be minimum supervisor referee, or contract diver at Subsea7) Name Position Company : : :
Email.
Courses completed and Certificates held Your Air Diving Experience since qualified
2.
Page 1 of 5
seabed-to-surface
3.
4.
5.
6.
7.
8.
9.
10. Do you get lost finding the work site occasionally? yes No __________________________________________________________________________ Employment 1. Who was your last employer?
2.
Period of employment?
3.
4.
Page 2 of 5
seabed-to-surface
5.
6.
7.
------------------------------------------------------------------------------------------------------------EQUIPMENT tick if you have 'hands on' experience AT WORK with the following? Lift bags Hydraulic impact wrench Hydraulic Jack hammer Hydraulic cutter Hydraulic grinder Flange splitter Nut splitter Drift pins Close tolerance pins Hydratight jacks Chain fall Lever hoist Mule Tirfor Lacing wires Spansets Flange turner C spanner Flange pullers DMA ----------------------------------------------------Mattress lifting beam Morgrip Stilsons Torque wrench Torque multiplier Webbing strops Shackles Vernier Micrometer Mole grips LP grit gun HP jetting gear Air Lift Dredge HOG GTO Roberts Lathe Diamond Cutting tool Bandit tool Grillion Clogger i.e petzl ascender etc ------------------------------------------------------------
Burning Pass this question if no work site experience? 1. Can you use broco rod effectively? yes No If so, what is the maximum thickness you have burnt through?
2.
Are you a good safe burner? How do you rate your burning?
yes
No
Page 3 of 5
seabed-to-surface
INSPECTION Pass this question if not qualified 1. How many minutes achieved of inspection in last 12 months?
2.
3.
Equipment used
Answer the next three questions to the best of YOUR ability and be specific! Question 1 Describe the correct lifting procedure when lifting a known weight of 750 kg with a 1 ton lift bag inside a structure, and what to look out for, be specific!
Question 2 You are asked to do some burning within a structure, you have read the task plan and risk assessment, there is an overhead void 2 metres above you which hasnt been identified, is this a problem?
Page 4 of 5
seabed-to-surface
Question 3 What would make you go for a 50% pass on a flange when bolt tensioning instead of a 100% and what are the key differences
Page 5 of 5
seabed-to-surface