Professional Documents
Culture Documents
DANGER
HAZARD OF ELECTRIC SHOCK, BURN, OR EXPLOSION This equipment must be installed and serviced only by qualified electrical personnel. Turn off all power supplying this equipment before working on or inside. Always use a properly rated voltage sensing device to confirm that power is off. Replace all devices, doors, and covers before turning on the power to this equipment. Failure to follow these instructions will result in death or serious injury.
This bulletin provides instructions for adding a shelf and unit door to an existing Model 6 Motor Control Center.
INSTALLATION
1. Turn off all power supplying the MCC. Use a properly rated voltage sensing device to verify that all power is off. 2. Position shelf (Item A, Figure 1) in the approriate area of the structure. 3. Place the mounting foot (Item B) of the shelf into the mounting pan slots (Item C). Secure the shelf on the left and right with at head screws, (Item D, Detail A). 4. Install the hinge leaves (Detail A, Item E) into the hinge slots (Item G), which are on the structure corner channel. With hex head screws (Item H), fasten the hinge leaves to the structure corner channel. 5. Install quarter turn fastener receptacles (Item J) into bracket slots (Item K) and fasten with hex head screws (Detail B, Item H).
Table 1:
NOTE: For unit installation, refer to the Model 6 MCC Installation and Maintenance Manual (8998IM9201_) supplied with initial equipment purchase.
Item
A D F H J
B A See Detail A or B C E Detail A D H F G
Description
Shelf Flat head screws Unit door Hex head screws Quarter turn fastener receptacle
Assemble Per
Steps 2 and 3 (or 4) Step 3 or 4 Step 5 Steps 5 and 6 Step 6
Shelf is furnished with order. Structure may already have shelf mounted in position. All necessary hardware for typical installation of shelf is included. Door installation may require additional hardware.
D See Detail A H J
F See Detail B
8998-9810
Detail B
Square D Company 1990 Sandifer Blvd. Seneca, SC 29678 USA (864) 882-2414 Internet: www.squared.com
Square D and
Electrical equipment should be serviced only by qualied electrical maintenance personnel. No responsibility is assumed by Square D for any consequences arising out of the use of this material.