Material Test Report Requirement for SA-240/SA-240M, Section II, Part A (2001 Edition, 2002 and 2003 Addenda) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . II-A-04-9R BC04-1068* Material Test Report Requirements in SA-20/SA-20M, in Section II, Part A (2004 Edition) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . II-A-04-11 BC05-216 SA-577/SA-577M Requirement for Ultrasonic Examination of Plate Material, Section II, Part A (2004 Edition) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . II-A-04-10 BC05-359 Interpretation: II-A-04-09R Subject: Material Test Report Requirement for SA-240/SA-240M, Section II, Part A (2001 Edition, 2002 and 2003 Addenda) Date Issued: September 28, 2004 File: BC04-1068* Question: For stainless steel plate, sheet or strip supplied to SA-240/SA-240M, is it necessary for the certication to include the following sentence on the material test report: The material was manufactured, sampled, tested, and inspected in accordance with the requirements of SA-240/SA-240M and has been found to meet those requirements? Reply: No. Interpretation: II-A-04-10 Subject: SA-577/SA-577M Requirement for Ultrasonic Examination of Plate Material, in Section II, Part A (2004 Edition) Date Issued: March 11, 2005 File: BC05-359 Question: When a steel plate is examined by the ultrasonic method in accordance with SA-577/SA-577M and no indications that equal or exceed the required calibration curve are found following the scan with the 45 deg angle beam search transducer, is an additional scan required using an alternate angle beam transducer? Reply: No. Interpretation: II-A-04-11 Subject: Material Test Report Requirements in SA-20/SA-20M, in Section II, Part A (2004 Edition) Date Issued: April 12, 2005 File: BC05-216 Question (1): Can as cast ingot or hot worked continuously cast material that does not meet the reduction requirements of 5.3 of Specication SA-20/SA-20M be certied to Specication SA-516/SA-516M? Reply (1): No. Question (2): Is certication of strand cast slab material that is supplied for hot rolling into steel plate to a product specication included in Section II-Arequired to include the specication number and year date? Reply (2): No. Question (3): For strand cast material that has been hot rolled into plate and supplied to a second supplier for certication to a Section II-A steel pressure vessel plate specication, must the original manufacturers certication indicate that the requirements of Section 5 Material and Manufacture of Specication SA-20/SA-20M have been met? Reply (3): Yes. Copyright 2005 by the American Society of Mechanical Engineers. No reproduction may be made of this material without written consent of ASME. c