Post Eng1 Assessment - MWD/LWD Operations 1 completed
Total score: 13 out of 1! "#$ Congratulations you have passed this assessment. Your score will be recorded in LMS 1 of 1 If you use the LTB adapter, which is the maximum data transfer speed you can get? 4800 bauds 900 bauds !000 bauds % out of 1 "rong #nswer$ %&ease re'iew the materia& and try again$ & of 1 Loo(ing at the pictures, &abe& the extender stabs according&y) *ema&e wet stab +ry stab ,a&e wet stab 1 out of 1 -orrect. 3 of 1 "hat is the use of the coc(ing too&? To a&ign the dry stab when it is bent$ To extract the wet stab$ To ma(e sure the extender is fu&&y extended, specia&&y when re/running it$ 1 out of 1 -orrect. ' of 1 %ut in order the steps to proper&y ad0ust the &ength of an 12T, extender$ +etach the bottom and topside of the extender to perform the ad0ustment$ 3emo'e the topside of the extender with the specia& wrench$ *ix the boot in p&ace$ 3e&ease the wire from the topside of the extender by re&easing the wetstab$ 3eturn the ma&e connector to its correct position with the pin a&igned with the s&ot in the connector$ -oi& the wire and insert it through the topside$ Insert re4uired shims in the s&ee'e$ 5se the nut remo'a& too& to remo'e the brass nut ho&ding the wetstab in p&ace$ 6crew the s&ee'e bac( on and tighten it with the wrench$ 3emo'e the wetstab from its boot comp&ete&y$ 1 out of 1 -orrect. of 1 3e&ate the type of extender to the corresponding too& and position 1 out of 1 -orrect. ( of 1 "hat are the 4ua&ity chec( criteria for +7I ca&ibration? Latitude #cce&erometer sca&e factors 3epeat chec(s Loca& ,agnetic *ie&d intensity ,agnetometer bias #cce&erometer bias ,agnetometer sca&e factor 1 out of 1 -orrect. # of 1 6e&ect the correct minimum re4uirements to obtain a good ca&ibration$ ,inimum distance from meta&&ic ob0ects 8ft9 :0 0 ;0 ;: #ir/ca& samp&ing rate 8sec9 :0 0 ;0 ;: ,inimum number of samp&es :0 0 ;0 ;: ,inimum too& height from ground 8ft9 :0 0 ;0 ;: % out of 1 "rong answer$ %&ease re'iew the materia& and try again$ " of 1 "hat is the use of the norma&i<ation factor? To smooth any 'ariation of high 'o&tage app&ied to gamma ray sensor during operation$ To account for too& to too& 'ariations in sensiti'ity to formation gamma rays$ To account for 'ariations in crysta& reso&ution and sensiti'ity during run$ 1 out of 1 -orrect. ) of 1 =ow many positions in tota& there are during a +7I ca&ibration? ; 4 :; >one of the abo'e 1 out of 1 -orrect. 1% of 1 ?ne of the fo&&owing statements ref&ects the best the heat test procedure for arc@I6I?>A gamma ray$ ,ar( the correct one$ The o'en is set at B;!0 deg -$ The high 'o&tage is decrease at steps of !0 'dc starting at /900 'dc unti& /:000 'dc, each step &asting ;00 seconds$ *ina&&y, it is set to /;400 'dc and the too& is dumped$ "ith the C63/+ correct&y positioned on top of the o'enDs &id, the high 'o&tage is decrease at steps of !0 'dc starting at /900 'dc unti& /:000 'dc, each step &asting ;00 seconds$ *ina&&y, it is set to /;400 'dc and the too& is dumped$ The test is run at room temperature and then at B;!0 deg-$ The o'en is set at ;!0 deg -$ The high 'o&tage is decrease in steps of !0 'ac, starting at :000 'ac unti& 900 'ac$ *ina&&y it is set at ;400 'ac and the too& is dumped$ 1 out of 1 -orrect. 11 of 1 "hat is the fre4uency for %ower%u&se Camma 3ay ca&ibration? ?nce a month #fter a ser'ice 1'ery three months 1'ery six months 1 out of 1 -orrect. 1& of 1 If you perform an air ca&ibration and a&& the to&erances are passed, this indicates by itse&f you ha'e a good ca&ibration? Ees, this is the on&y re4uirement$ >o, a&& setup re4uirements ha'e to be respected as we&&$ 1 out of 1 -orrect. 13 of 1 The %ower%u&se Camma 3ay ca&ibration can be di'ided into the fo&&owing steps) "ater tan( chec( Camma 3ay b&an(et *oi& test Bac(ground 1 out of 1 -orrect. 1' of 1 "hat is the recommended fre4uency for +7I ca&ibrations? ?nce a year 1'ery F months 1'ery months ?nce a month 1 out of 1 -orrect. 1 of 1 "hat is the purpose of the gamma ray gain for arc@I6I?>A too&s? To norma&i<e the C3 detectors so that typica&&y two too&s of the same si<e with different sensiti'ities wi&& read the same 'a&ues in the same en'ironment$ To correct for the effect on the crysta& due to different too& si<es a'ai&ab&e$ To account for the difference between the test at room temperature and the one at B;!0 deg-$ 1 out of 1 -orrect. =ome Questionmark Perception licensed to Schlumberger
Helmut Lethen - Cool Conduct - The Culture of Distance in Weimar Germany (Weimar and Now - German Cultural Criticism) - University of California Press (2001) PDF