Professional Documents
Culture Documents
Assignment 7 - Prob Statement
Assignment 7 - Prob Statement
F, CAf, Tf
Fy, Tyin
CA, T, V
Fy, Ty
Ty
F, CA, T
T
This is the diagram of a jacketed CSTR in which a first order reaction is taking place. The reaction is
exothermic and hence, it is cooled using cooling water in its jacket to maintain its temperature at Ty.
Assume:1) No energy balance for jacket.
2) Inside is perfectly mixed.
3) Constant volume and constant parameters.
Solution:
i.e., =
= (/)( )
= + ( ) ( )
= ( ) ( ) + (
) (/ )( )
= 0 and
=0
The final steady state values depend upon initial values of Ca, T in the reactor.
Dynamic Behaviour:
Case 1: ( CA = 9 and T =300)
Stability Analysis:
The Eigenvalues of the A matrix determine the stability of the steady state operating points.
- Case 1:
1 = -0.8953
and 2 = -0.5197
As both values are negative, steady state point is Stable (node)
Case 2:
1 = -0.7653+0.9568i
and 2 = -0.7653-0.9568i
As real part of lambda is negative , the steady state point is stable (focus)
Case 3:
1 = -0.7652+0.9507i
and 2 = -0.7652-0.9507i
As real part of lambda is negative , the steady state point is stable (focus)
Eigen value method involves linearization of system around a point. But here the system assumes nonlinear behaviour due to the exponential term exp(-E/RT). Therefore Eigen value method is not much
effective.
The terms in above equation can be related to the energy removed and generated.
A steady-state solution exists when there is an intersection of the Qrem and Qgen curves. Also note that
from the above eqn, Heat Removal Qrem is linear curve(Straight line).
A slight perturbation at point 1 brings back to the original steady state and so is stable. But at point 2 it is
unstable.
Therefore the stability criterions for operating points of CSTRs is that the slope of the straight line of heat
removal must be larger than the slope of the heat generation curve ie.
>
Algorithm:
We defined Qgen as a function of Ts (Reactor temperature) and determined
and
at the
If the above inequality condition satisfies then the steady state is stable and the condition does not
satisfy the steady state is unstable.
Using this method we got same stability analysis results as the previous one.