Professional Documents
Culture Documents
Contractor
Job Location
Approval
Engineer
Approval
Representative
LEAD FREE*
Series LFN55B
Features
Bronze cage
Double union inlet & outlet connections
Integral stainless steel strainer
Thermoplastic seat
Lead Free* brass body construction
Serviceable in line
Bypass feature controls thermal expansion pressure***
Sealed spring cage on all models for accessible outdoor or pit installations
Models
Reinforced
Diaphragm
Integral Stainless
Steel Strainer
LFN55B
LFN55BU
LFN55BU-S
LFN55BDU
Threaded or
solder ends
Specifications
A Water Pressure Reducing Valve and strainer shall be installed on the water
service pipe near its entrance to the building where supply main pressure
exceeds 60psi (413 kPa) to reduce it to 50psi (345 kPa) or lower. The water
pressure reducing valve shall be constructed using Lead Free* materials. Lead
Free* regulators shall comply with state codes and standards, where applicable,
requiring reduced lead content. Sill cocks and outside wall hydrants may be left
on full main pressure at the option of the owner. Provision shall be made to permit the bypass flow of water back through the valve into the main when pressures, due to thermal expansion on the outlet side of the valve, exceed the pressure in the main supply. Pressure reducing valves with built-in bypass check
valves and integral strainer will be acceptable. Approved valves shall comply
with ASSE 1003. Valve shall be a Watts Series LFN55B.
Thermoplastic Seat
Thermal Expansion
Bypass
Watts product specifications in U.S. customary units and metric are approximate and are provided for reference only. For precise measurements,
please contact Watts Technical Service. Watts reserves the right to change or modify product design, construction, specifications, or materials without prior notice and without incurring any obligation to make such changes and modifications on Watts products previously or subsequently sold.
Capacity
Materials
Body:
Seat:
Thermoplastic
Cage:
Bronze
kPa
0
psi
0
34
Reinforced EPDM
Valve Disc:
Elastomer
Pressure Temperature
2" (50mm)
69
Pressure Drop
Standards
Meets requirements of ASSE Standard 1003; (ANSI A112.26.2);
CSA Standard B356; and listed by IAPMO.
10
1 1/2"
(40mm)
103
15
138
20
172
25
1 1/4"
(32mm)
Options
G
Gauge tapping
GG
0
0
Dimensions Weights
10
38
Flow
AN - NONE
BN - NONE
C
Max.
D
BT = NPT
BS = sweat
G
AT = NPT
AS = sweat
SIZE (DN)
DIMENSIONS
AT
in.
114
112
2
mm
in.
As
mm
in.
AN
mm
in.
BT
mm
in.
Bs
mm
in.
mm
in.
ES-LFN55B-L 0940
C
mm
32 838 213 71516 201 51316 148 438 111 418 105 3116
40 838 213 8316 207 51316 148 4916 115 4716 112 314
50 9 228 914 235 638 162 5 126 5116 129 31116
WEIGHTS
BN
in.
D
mm
in.
ET
mm
in
11 16
ES
mm
in
G
mm
17 1 25
1116
17 118 28
1116
17 138 34
in.
mm
lbs.
314
314
31116
82
82
93
7.5 3.4
9 4.0
10 4.5
kgs.
2009 Watts