1. Determine the modulus of rigidity (G) of the material for a given specimen by conducting the torsion test. 2. Determine the modulus of elasticity (E) of the material for a given wooden specimen on simply supported beam. 3. Determine the impact resistance of the material by conducting Izod test. 4. Determine the modulus of elasticity (E) of the material for a given specimen on cantilever beam. 5. Determine the modulus of elasticity (E) of the material for a given M.S. specimen on simply supported beam. 6. Determine the impact resistance of the material by conducting Charpy test.
Mos 2nd mid Q.P.
2nd mech C 1. Derive bending formula. (5M) 2. A compound cylinder has inner radius 200mm, radius at common surface 250mm and outer radius is 300mm. Initial pressure at common surface is 6N/mm2. What are final hoop stresses if a fluid is admitted at a pressure of 80N/mm 2. Draw also stress
distribution curve. (5M) 3. (a) Derive torsion equation. (3M) (b) What are the assumptions of Eulers theory? (2M)
Metrology 2nd mid Q.P.
3rd mech B 1.Explain the measurement of effective diameter of screw thread by using two wire size method. (5M) 2.Explain the construction and working of gear tooth vernier caliper with a neat sketch. (5M)