Professional Documents
Culture Documents
Ignition Switch
Power Tilt Column
Item
Part
Number
Description
11572
Ignition switch
11B572
Item
Part
Number
Description
3F888
W504142
11B572
11572
Ignition switch
All vehicles
1. Depower the Supplemental Restraint System (SRS). For additional information, refer to
Section 501-20B .
2. Remove the steering column shroud. For additional information, refer to Section 211-04 .
Vehicles with manual tilt
3. Position the steering column in the full down position.
4. Remove the steering wheel. For additional information, refer to Section 211-04 .
All vehicles
5. Detach the wiring harness retainer from the steering column.
6. Disconnect the following electrical connectors.
Multifunction switch (2)
Clockspring
Passive Anti-Theft System (PATS) connector
Key release interlock actuator (if equipped)
7. Disconnect the ignition switch electrical connector.
Vehicles with manual tilt
8. Remove the 3 bolts and the multifunction switch carrier.
All vehicles
9. Remove the screw and the ignition switch.
To install, tighten to 5 Nm (44 lb-in).
10. NOTICE: Make sure the electrical wiring harness is routed correctly and secured to the
steering column or damage to the wires and/or connectors may occur.
To install, reverse the removal procedure.
11. Repower the SRS . For additional information, refer to Section 501-20B .