Professional Documents
Culture Documents
The STABL6H.EXE program is a modified version of STABL6. This version allows the
use of up to 40 layers of geogrids and up to 10 points on each layer. The following
changes to the manual apply to STABL6H:
Page 19 - C.3 Input restrictions (revised):
1.
2.
A reinforcing layer must be specified by at least 2 but not more than 10 points.
3.
4.
The inclination factor must be between 0.0 and 1.0. A factor of 0.0 specifies that
the reinforcing force acts in the direction of the reinforcement. A factor of 1.0
specifies that the force acts tangent to the failure surface.
RF03 -
Please note that the reinforcement option is implemented only for the Bishop method of
analysis, i.e., for circular failure surfaces. This may not be appropriate for all cases. In
order to evaluate overall stability it may be necessary to delete the reinforcing data to
allow the use of non-circular surfaces outside of the reinforced zone.
You are referred to current procedures recently published (1995) by the Federal Highway
Administration regarding design with geosynthetics.
The STABL6 program is supplied as-is and no warranty is expressed or implied.