Analog multimeter is a rectangular instrument used to measure voltage, current, and resistance. It consists of probes, a selector knob, indicator dial, scales, and takes a battery. The probes plug into the body to measure components. The zero adjuster and selector are used to calibrate measurements and select the function.
Analog multimeter is a rectangular instrument used to measure voltage, current, and resistance. It consists of probes, a selector knob, indicator dial, scales, and takes a battery. The probes plug into the body to measure components. The zero adjuster and selector are used to calibrate measurements and select the function.
Analog multimeter is a rectangular instrument used to measure voltage, current, and resistance. It consists of probes, a selector knob, indicator dial, scales, and takes a battery. The probes plug into the body to measure components. The zero adjuster and selector are used to calibrate measurements and select the function.
Part/bagian dan penjelasan fisik Probe Cara menggunakan Maintenance
Analog multimeter is an instrument to measure voltage, current and resistance
of electrical component. Analog multimeter consists of a pair of probes, zero adjuster, selector, analog indicator, battery, cover and body. It is shaped like a rectangle . The length of analog multimeter is 120 mm and the width is 100 mm. The body and the cover are made of plastic called polycarbonate. The zero adjuster is circular and has teeth around it. Its diameter is 15 mm. The selector is circular and the diameter is 40 mm. On the top of it there is grip to select the function. The length is 40mm, the width is 7mm and the height is 5mm. And there is an arrow on the one of the sides. The Analog indicator consists of a dial, a needle and meter scales. The dial is the zero collector whenever you calibrate, the beginning as 0 voltages both the AC and DC measurement. Use your flat screw driver to set this knob to calibrate the 0 voltages of your tester. The name alone as Infinity knob because 0 voltage region of the tester is the infinity region of the resistance. Because the principle of the Multitester is The higher the measurement of the voltage, the lower the resistance". The Zero Adjustment is used to calibrate the tester whenever you wanted to measure the resistance. To assure that the tester calibrated to zero Ohms, just follow this procedure. Take the two metal tip of the test probe of the VOM connected Then look at the meter scale of the tester, notice the needle or the pointer if it takes to the zero ohms situated right of the meter scale. If the needle didn't take to the zero ohms just rolled the knob clockwise until the middle position in the zero ohms. And the meter scales is the basis of the measurement where the graduation, bar drawn in the body, commonly the resistance or ohms scale have a measurement from 0-2k ohms depend of the range and settings. And the voltage both AC and DC from 0-250,50, 10 and it depends on the range and settings you sited. A battery is used to supply the multimeter.
Probe are detached from the body and the cover, but they can be plugged to the body when a user want to measure voltage, current or resistance of a component.