Professional Documents
Culture Documents
Nats PDF
Nats PDF
SIIA1647E
BL-160
NATS (NISSAN ANTI-THEFT SYSTEM)
A
NATS (Nissan Anti-Theft System) has the following immobilizer functions:
Since only NATS ignition keys, whose ID nos. have been registered into the ECM and IMMU (Smart
entrance control unit) of NATS, allow the engine to run, operation of a stolen vehicle without a NATS reg-
istered key is prevented by NATS. B
That is to say, NATS will immobilize the engine if someone tries to start it without the registered key of
NATS.
This version of NATS has dongle unit to improve its anti-theft performance (RHD models). Dongle unit has C
its own ID which is registered into NATS IMMU (Smart entrance control unit). So if dongle unit is replaced,
initialization must be carried out.
When dongle unit has a malfunction of dongle unit is detected: D
The security indicator lamp illuminates for about 15 minutes after ignition switch is turned to ON.
When dongle unit has a malfunction and the indicator lamp is illuminated, engine can not be started. How-
ever engine can be started only one time when security indicator lamp turns off in about 15 minutes after E
ignition switch is turned to ON.
All of the originally supplied ignition key IDs have been NATS registered.
If requested by the vehicle owner, a maximum of five key IDs can be registered into the NATS compo-
nents. F
The security indicator blinks when the ignition switch is in OFF or ACC position. Therefore, NATS
warns outsiders that the vehicle is equipped with the anti-theft system.
When NATS detects trouble, the security indicator lamp lights up as follows. G
Security indicator
Condition IGN ON and
With dongle With out dongle H
1. 6 time blinking
NATS malfunction (except dongle unit) is detected 2. Staying ON after ignition switch is Staying ON
turned ON BL
Stay ON for about 15 minutes after
Only malfunction of dongle unit is detected.
ignition switch is turned ON
1. 6 time blinking J
Malfunction of NATS and engine related parts are
2. Staying ON after ignition switch is Staying ON
detected
turned ON
Only engine related part malfunction is detected. K
Just after initialization of NATS 6 time blinking
NATS trouble diagnoses, system initialization and additional registration of other NATS ignition key IDs L
must be carried out using CONSULT-II hardware and CONSULT-II NATS software.
Regarding the procedures of NATS initialization and NATS ignition key ID registration, refer to CONSULT-
II operation manual, NATS.
M
When servicing a malfunction of the NATS (indicated by lighting up of Security Indicator Lamp) or
registering another NATS ignition key ID no., it may be necessary to re-register original key iden-
tification. Therefore, be sure to receive ALL KEYS from vehicle owner.
BL-161
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1666E
BL-162
NATS (NISSAN ANTI-THEFT SYSTEM)
BL
MKWA0697E
BL-163
NATS (NISSAN ANTI-THEFT SYSTEM)
CONSULT-II EIS002M4
SIIA1645E
SEL026X
SEL027X
SEL150X
BL-164
NATS (NISSAN ANTI-THEFT SYSTEM)
NOTE:
When any initialization is performed, all ID previously registered will be erased and all NATS igni- A
tion keys must be registered again.
The engine cannot be started with an unregistered key. In this case, the system may show DIFFERENCE
OF KEY or LOCK MODE as a self-diagnostic result on the CONSULT-II screen. B
In rare case, CHAIN OF ECM-IMMU might be stored as a self-diagnostic result during key registration
procedure, even if the system is not malfunctioning.
HOW TO READ SELF-DIAGNOSTIC RESULTS C
SEL151X
BL
NATS SELF-DIAGNOSTIC RESULTS ITEM CHART
P No. Code
Detected items (Self-diagnostic Reference J
Malfunction is detected when.....
(NATS program card screen terms) result of page
ENGINE
NATS MAL- K
The malfunction of ECM internal circuit of IMMU commu-
ECM INT CIRC-IMMU FUNCTION BL-170
nication line is detected.
P1613
Communication impossible between ECM and IMMU
NATS MAL- L
(In rare case, CHAIN OF ECM-IMMU might be stored
CHAIN OF ECM-IMMU FUNCTION BL-170
during key registration procedure, even if the system is
P1612
not malfunctioning.)
NATS MAL- M
IMMU can receive the key ID signal but the result of ID
DIFFERENCE OF KEY FUNCTION BL-172
verification between key ID and IMMU is NG.
P1615
NATS MAL-
CHAIN OF IMMU-KEY FUNCTION IMMU cannot receive the key ID signal. BL-172
P1614
NATS MAL-
The result of ID verification between IMMU and ECM is
ID DISCORD, IMM-ECM FUNCTION BL-174
NG. System initialization is required.
P1611
When the starting operation is carried out five or more
times consecutively under the following conditions, NATS
NATS MAL- will shift the mode to one which prevents the engine from
LOCK MODE FUNCTION being started. BL-176
P1610
Unregistered ignition key is used.
IMMU or ECMs malfunctioning.
DON'T ERASE BEFORE CHECK- All engine trouble codes except NATS trouble code has
BL-166
ING ENG DIAG been detected in ECM.
BL-165
NATS (NISSAN ANTI-THEFT SYSTEM)
SEL729WE
BL-166
NATS (NISSAN ANTI-THEFT SYSTEM)
A
First perform the SELF-DIAG RESULTS in SMART ENTRANCE with CONSULT-II, when perform the each
trouble diagnosis. Refer to BCS-19, "CONSULT-II INSPECTION PROCEDURE"
BL
BL-167
NATS (NISSAN ANTI-THEFT SYSTEM)
BL-168
NATS (NISSAN ANTI-THEFT SYSTEM)
BL-169
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1667E
Self-diagnostic results:
ECM INT CIRC-IMMU displayed on CONSULT-II screen
1. Confirm SELF-DIAGNOSTIC RESULTS ECM INT CIRC-IMMU
displayed on CONSULT-II screen.
2. Replace ECM.
Ref. part No. B
3. Perform initialization with CONSULT-II.
For initialization, refer to CONSULT-II operation manual NATS.
SEL152X
Self-diagnostic results:
CHAIN OF ECM-IMMU displayed on CONSULT-II screen
1. CONFIRM SELF-DIAGNOSTIC RESULTS
Confirm SELF-DIAGNOSTIC RESULTS CHAIN OF ECM-IMMU
displayed on CONSULT-II screen.
NOTE:
In rare case, CHAIN OF ECM-IMMU might be stored during key
registration procedure, even if the system is not malfunctioning.
Is CONSULT-II screen displayed as above?
Yes >> GO TO 2
No >> GO TO BL-168, "SYMPTOM MATRIX CHART 1" .
SEL292W
BL-170
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1565E
BL-171
NATS (NISSAN ANTI-THEFT SYSTEM)
Self-diagnostic results:
DIFFERENCE OF KEY displayed on CONSULT-II screen
1. CONFIRM SELF-DIAGNOSTIC RESULTS
Confirm SELF-DIAGNOSTIC RESULTS DIFFERENCE OF KEY
displayed on CONSULT-II screen.
Is CONSULT-II screen displayed as above?
Yes >> GO TO 2
No >> GO TO BL-168, "SYMPTOM MATRIX CHART 1" .
SEL367X
ual NATS.
Diagnostic Procedure 4 EIS002MA
Self-diagnostic results:
CHAIN OF IMMU-KEY displayed on CONSULT-II screen
BL-172
NATS (NISSAN ANTI-THEFT SYSTEM)
D
SEL957W
Check NATS antenna amp. installation. Refer to BL-180, "How to Replace NATS Antenna Amp" .
OK or NG?
F
OK >> GO TO 3
NG >> Reinstall NATS antenna amp. correctly.
NOTE:
If harness is OK, replace IMMU, perform initialization with CONSULT-II. For initialization, refer
to CONSULT-II operation manual NATS.
BL-173
NATS (NISSAN ANTI-THEFT SYSTEM)
NOTE:
If harness is OK, replace IMMU, perform initialization with CONSULT-II. For initialization, refer
to CONSULT-II operation manual NATS.
NOTE:
If harness is OK, replace IMMU, perform initialization with CONSULT-II. For initialization, refer
to CONSULT-II operation manual NATS.
Self-diagnostic results:
BL-174
NATS (NISSAN ANTI-THEFT SYSTEM)
SEL958W
F
2. PERFORM INITIALIZATION WITH CONSULT-II
Perform initialization with CONSULT-II. Re-register all NATS ignition key IDs.
For initialization, refer to CONSULT-II operation manual NATS. G
NOTE:
If the initialization is not completed or fails, CONSULT-II shows
above message on the screen. H
Can the system be initialized?
Yes >> Start engine. (END)
(System initialization had not been completed. Ref. BL
part No. B )
No >> ECM is malfunctioning.
Replace ECM. Ref. part No. B SEL297W
J
Perform initialization with CONSULT-II.
BL-175
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1653E
Self-diagnostic results:
LOCK MODE displayed on CONSULT-II screen
1. CONFIRM SELF-DIAGNOSTIC RESULTS
Confirm SELF-DIAGNOSTIC RESULTS LOCK MODE is displayed
on CONSULT-II screen.
Is CONSULT-II screen displayed as above?
Yes >> GO TO 2
No >> GO TO BL-168, "SYMPTOM MATRIX CHART 1" .
SEL960W
BL-176
NATS (NISSAN ANTI-THEFT SYSTEM)
SEL297W
BL
4. PERFORM INITIALIZATION WITH CONSULT-II AGAIN
1. Replace IMMU (Smart entrance control unit).
J
2. Perform initialization with CONSULT-II.
For initialization, refer to CONSULT-II operation manual NATS.
NOTE:
K
If the initialization is not completed or fails, CONSULT-II shows
the above message on the screen.
Can the system be initialized?
L
Yes >> System is OK. (IMMU is malfunctioning. Ref. part No. A
)
No >> ECM is malfunctioning.
Replace ECM. Ref. part No. B M
Perform initialization with CONSULT-II.
For initialization, refer to CONSULT-II operation man- SEL297W
ual NATS.
Diagnostic Procedure 8 EIS002P9
BL-177
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1674E
M/T MODELS
1. CHECK POWER SUPPLY CIRCUIT FOR IMMU
1. Disconnect IMMU (Smart entrance control unit) connector.
2. Check voltage between IMMU (Smart entrance control unit) harness connector M43 terminal 58(B/W) and
ground with CONSULT-II or tester.
Ignition switch
: Battery voltage should exist.
START position
Ignition switch OFF
: 0V
position
OK or NG?
OK >> GO TO 2
NG >> Check the following
Ignition switch
BL-178
NATS (NISSAN ANTI-THEFT SYSTEM)
E
SIIA1685E
SIIA1686E
K
A/T, CVT MODELS
1. CHECK POWER SUPPLY CIRCUIT FOR IMMU
L
1. Disconnect IMMU (Smart entrance control unit) connector.
2. Check voltage between IMMU (Smart entrance control unit) harness connector M43 terminal 59(B/W) and
ground with CONSULT-II or tester.
M
: Battery voltage should exist.
OK or NG?
OK >> GO TO 2
NG >> Check the following
Park/neutral position relay
SIIA1687E
BL-179
NATS (NISSAN ANTI-THEFT SYSTEM)
SIIA1688E
SIIA1689E
NOTE:
If NATS antenna amp. is not installed correctly, NATS sys-
tem will not operate properly and SELF-DIAG RESULTS on
CONSULT-II screen will show LOCK MODE or CHAIN OF
IMMU- KEY.
Initialization is not necessary only when NATS antenna
amp. is replaced with a new one.
SIIA1683E
BL-180