Professional Documents
Culture Documents
presents
PAC-A TOYS
Sling N Toss
Instruction Manual
CAUTION:
Date: 04/12/2017
PAC-A TOYS
Page 2 Page 11
PAC-A TOYS
Attach (K) to (L)and insert the (C) into the slit of (K), pull back in an upward Red U-Shape-1 (I)
position and Sling n Toss away !
Teal
Page 10 Page 3
PAC-A TOYS
1. Begin with the (J). Slide (F) onto (J) about of the way down from the 7. Take the top end of (A) and wrap it in the front of (F), where the two sides
top. of (A) are behind the two wings of (F) above (I).
2. Take (I) and slide it onto the (J) until it meets with the (F).
8. Wrap one (D) around (G) between (I) and (F). Repeat on other side.
3. Take another (F), slide it on from the top of the (J) until it meets with piece
(I). Note: make sure the two (F) pieces are pressing against piece (I) in be-
tween them tightly 9. Take piece (C) and slide one side of the band in the slit of the upright (F) on
each side of (I) to enable the sling. Pull front of piece tightly towards you,
making it completely straightened in front,
and loose in back.
Page 4 Page 9
PAC-A TOYS
4. Place one (E) onto (J) from the top until it meets with the (F).
4. Take piece (A) and insert it into each of the slits on the outside of (G), locat-
ed on each side of the (I ).
5. Gather two (G) and enter them through the side holes of the (I).
6. Once the (G) pieces are entered, place them in the side holes within (E), and
push them in tightly.
7. Now slide one (F) onto each (G) until it meets the (I) tightly. Note:
Make sure the (F) are sitting in an upright position where the bars are
6. Take the bottom part of (C) and hook it onto the bottom of the (I) . standing vertically
Page 8 Page 5
PAC-A TOYS
8. Finally, place (J) into top hole of the round yellow piece. 1. Take one (B) piece and latch one loop of the band onto (F), located below
(I), into slits of the wing. Repeat on other side
2. Take the other end of (B) that is not attached, pull, and stretch it over (E)
where it will meet with (F) again and attach it.
Page 6 Page 7