Professional Documents
Culture Documents
BOOKLET
SAFEGUARDS 14. Do not use this appliance for anything other
than its intended use. Do not use in moving
We at Cuisinart are very safety conscious. We vehicles or boats.
design and manufacture consumer products 15. Do not use outdoors.
with the safety of you, our valued customer,
foremost in mind. In addition we ask that you 16. Always switch the appliance off, and then
exercise a degree of care when using electrical remove plug from the power outlet when
appliances and adhere to the following the appliance is not being used and before
precautions. cleaning.
When using electrical appliances, basic safety 17. An extension cord is not recommended.
precautions should always be followed, However, if one is needed, the extension
including the following: cord should be a grounded type and its
electrical rating must be the same or higher
1. Carefully readall instructions wattage as the appliance. Regularly inspect
before operating APPLIANCE and the supply cord, plug and actual appliance
save for future reference. for any damage. If found damaged in any
2. To protect against fire, electrical shock and way, immediately cease use of the
injury to persons do not immerse the appliance and call Cuisinart Customer
appliance, cord or plug in water or any Service at 1-800-726-0190.
other liquid. 18. For any maintenance other than cleaning,
3. This appliance is for household use only. call Cuisinart Customer Service at 1-800-
726-0190.
4. Do not use this appliance for anything other
than its intended use. 19. Refer servicing to qualified personnel.
5. This appliance should not be used by or 20. Do not operate any appliance with a
near children or individuals with certain damaged cord or plug or after the
disabilities. appliance malfunctions, or has been
damaged in any manner. Return appliance
6. Do not leave the appliance unattended
to the nearest authorized service facility for
when in use.
examination, repair or adjustment.
7. Do not touch hot surfaces. Use handles.
21. Unplug from outlet when not in use and
8. Always use the appliance on a dry, level before cleaning. Allow to cool before
surface. putting on or taking off parts, and before
9. To disconnect, turn all controls off, then cleaning the appliance.
remove plug from power outlet.
10. Do not place this appliance on or near a
hot gas or electric burner, or where it could
touch a heated oven.
SAVE THESE
11. Do not let the cord hang over the edge of
a table or counter, touch hot surfaces or
INSTRUCTIONS
become knotted.
12. The use of accessory attachments not
FOR HOUSEHOLD USE
recommended by Cuisinart may cause a
risk of injury to persons, fire or electrical
ONLY
shock.
WARNING: RISK Of FIRE OR SPECIAL CORD SET
ELECTRIC SHOCK INSTRUCTIONS
The lightning flash with arrowhead A short power-supply cord is provided to
symbol within an equilateral reduce the risks resulting from becoming
triangle is intended to alert the entangled in or tripping over a longer cord.
user to the presence of Longer extension cords are available and may
uninsulated dangerous voltage be used if care is exercised in their use.
within the products enclosure
that may be of sufficient If a long extension cord is used, the marked
magnitude to constitute a risk of electrical rating of the extension cord must be
fire or electric shock to persons. at least as great as the electrical rating of the
appliance, and the longer cord should be
The exclamation point within an arranged so that it will not drape over the
equilateral triangle is intended to countertop or tabletop where it can be pulled
alert the user to the presence of on by children or tripped over.
important operating and
maintenance (servicing)
instructions in the literature NOTICE
accompanying the appliance. This appliance has a polarized plug (one blade
is wider than the other). To reduce the risk of
SPECIAL SAFETY electric shock, this plug will fit in a polarized
outlet only one way. If the plug does not fit fully
INSTRUCTIONS in the outlet, reverse the plug. If it still does not
1. Use only cold water in the water reservoir. fit, contact a qualified electrician. Do not
Do not use any other liquid. modify the plug in any way.
2. Never use the machine without water in it.
3. Ensure that the portafilter holder is firmly
IMPORtant UNPACKING
secured when using the machine. INSTRUCTIONS
4. Never remove the portafilter holder during the 1. Open the gift box.
brewing operation as the machine is under 2. Remove the top corrugated cardboard.
pressure. 3. Remove the entire unit from the box.
NOTE: For safety reasons it is recommended 4. Remove the three filter baskets, scoop/
you plug your Cuisinart appliance directly into tamping tool and portafilter holder from the
the power outlet. Use in conjunction with a side polyfoam.
power strip or extension cord is not
recommended. 5. Remove the frothing pitcher from the middle
of the espresso maker and then remove the
polyfoam from the espresso maker.
We suggest you save all packing materials in
the event that future shipping of the machine
is needed. Keep all plastic bags away from
children.
CONTENTS Element 2: Coffee
Important Safeguards . . . . . . . . . . . . . . . . . . . 2 While the bulk of the liquid is water, all of the
Unpacking Instructions . . . . . . . . . . . . . . . . . . 3 flavor should be from the coffee. To achieve the
same great quality of coffee you receive at a
The Quest for the Perfect Cup of Espresso . . 4
caf, you need to use the same quality beans.
Features and Benefits, Diagram . . . . . . . . . . . 5 If you choose to grind your own beans, buy the
Preparing Your Espresso Machine beans fresh and whole, only about a two-week
Before Use . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 supply at a time for maximum freshness. Once
Guide to the Perfect Espresso . . . . . . . . . . . . 7 the coffee bean is broken, its flavor degrades
Guide to Milk Texturing . . . . . . . . . . . . . . . . . 8 very quickly. If it is not practical to buy smaller
Using the Hot Water Function . . . . . . . . . . . . 8 supplies, we recommend you separate larger
Cleaning and Maintenance . . . . . . . . . . . . . . . 9 amounts of beans and store them in airtight
containers in a cool, dry area. They should not
Recipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
be kept for longer than 1 month as flavor will
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 diminish. Do not refrigerate or freeze coffee
beans.
Introduction
Congratulations on the purchase of your new Element 3: Grind
Cuisinart Espresso Maker! Youre only minutes The grind of the coffee is critical for proper
away from experiencing the rich, flavorful flavor extraction. If using a pre-ground coffee,
espresso found in the worlds best cafs, right be sure to purchase an espresso grind that is
in your own home. Please take a few moments specifically for espresso/cappuccino machines.
to discover the features of your new espresso If the grind is too fine, over-extraction and
maker, and be sure to enjoy every espresso, bitterness will occur with a spotted and uneven
cappuccino and latte to come! crema on the top. If the grind is too coarse, the
water will pass through too rapidly and
The Quest for there will be an inadequate amount of
the Perfect Cup crema on the top of the espresso.
FEATURES AND Benefits 15. Measuring Scoop/Tamping Tool
Use one side as a coffee scoop and the
other to compact the coffee grounds in
1. Water Reservoir Lid the filter basket prior to brewing.
2. Removable 53-ounce Water Reservoir 16. Filter Baskets
Use the one-cup filter basket for a single
3. Large Cup-Warming Plate espresso, the two-cup filter basket for a
double espresso or the pod filter basket
4. 15 Bar Pump (not shown)
for espresso pods.
5. Red Heating Light
Will illuminate indicating that espresso
1
machine is adjusting the temperature of
the heating system. 2
3
6. Steam/Hot Water Knob
To use the hot water function, the Steam/
5
Hot Water Knob must be turned to the
setting.
6
8
7. Power Button
5 7 8
Used to turn the espresso maker on. 7
8. Function Knob 10
3 different settings can be used to
steam, use hot water or to make coffee.
9
9. Portafilter Holder
Can be used with ground or pod 11
espresso. Has two positions, lock
and unlock, for ease of cleaning.
PREPARING YOUR 7. Place a sufficiently large
container under both pouring
9
Important: For first time use or if the machine through until the water
has not been used for some time, it is reservoir is empty.
important that the machine is rinsed as
follows: USING THE
2. Insert the power cord into a CONTROL PANEL
power outlet. Press the
power button to turn the Power
espresso machine on (1). NOTE: Before turning on the espresso machine,
The light located on the make sure that the function knob is in the off
power button will illuminate 1 position.
red and the heating light will Press the power button to turn the espresso
also illuminate red; this machine on. The light located on the power
indicates that your espresso switch will illuminate red and the heating light
machine is on and is heating will illuminate red; this is to indicate that your
up. When the heating light 2 espresso machine is on and is heating up.
switches off, this indicates
that the espresso machine is heated and
ready to use (2).
3. Make sure that the drip tray and grate are
in place.
3
4. To fill the espresso machine The espresso machine will automatically adjust
with water. Simply lift the lid the temperature of the heating system to the
of the water reservoir at the espresso temperature. When the machine is
top of the espresso machine heated and ready to use, the red heating light
(3) or fill with fresh cold will go out.
water or filtered water (4). 4
TIP: Use the one-cup filter basket for a single
Steam/Hot Water espresso and the two-cup filter basket for a
When the espresso machine is switched on, use double espresso and pod filter for an espresso
the steam/hot water knob to select either the pod.
steam or hot water function.
3. Using the measuring scoop,
A. If you want to froth milk for cappuccinos and place finely ground coffee in
12
lattes, you must turn the steam/hot water the filter basket holder (12).
knob to the steam setting. The red Use one scoop for one cup
heating light will illuminate, indicating that or two scoops for two cups,
the espresso machine is adjusting the or place espresso pod into
temperature of the heating system. filter basket holder. 13
coffee.
TIP: Make sure the tamping
Once the espresso machine is heated to the tool is dry so that wet coffee
correct temperature, the red heating light will grinds do not stick to it.
go out.
6. Secure the portafilter 16
To start machine, simply turn the function knob holder onto the brew head
counter-clockwise to the steam/hot water (15-16).
setting and turn it back to the off position NOTE: Check to see that the espresso machine
to stop. is ready for use. Remember that if the heating
light is on, the espresso machine is still
guide to THE adjusting the temperature of the heating system.
PERFECT ESPRESSO 7.Turn the function knob 17
clockwise to the
1. You may want to preheat the cups by filling espresso setting to start
them with hot water; this will help preserve the pour and turn it back to
the crema of the espresso. Set the cups the off position to stop (17).
aside. 8. Check the espresso pour.
2. Select the appropriate filter The ideal pour is dark and caramel with
basket and insert it into reddish reflections.
portafilter handle (11). 9. Serve espresso immediately.
11
Caring for your Espresso Machine 6. Angle the pitcher so that the 24
2. Once you have dispensed abrasive washing liquid. Do not use any
the required amount of hot scouring agents or harsh cleaners.
water into the cup or
NOTE: Do not clean any of the parts or
container, stop the hot water accessories in the dishwasher.
by turning the function knob 29
to the off position (29). CLEANING THE STEAM WAND
3. Remove the cup or The steam wand should always be cleaned
container and swing the after steaming milk.
steam/hot water wand over Wipe the steam wand with a damp cloth, then
the drip tray to catch any with the steam wand directed back into the
30
drips of water (30). drip tray, momentarily set the function knob to
the hot water setting. This will release any
Cleaning and remaining milk from inside the steam wand.
Maintenance Ensure the function knob is in the off position.
Always turn the Espresso Maker off and remove Press the power button off, unplug the power
the plug from the electrical outlet before cleaning. cord and allow the machine to cool.
Never immerse unit in water or other liquid. To If the steam wand remains blocked, use a
clean, simply wipe with a clean damp cloth and cleaning pin to clear the opening.
dry before storing. DECALCIFICATION
Decalcification refers to the removal of calcium
CLEANING THE FILTERS, PORTAFILTER deposits that form over time on the metal parts
HOLDER AND BREW HEAD of the coffeemaker.
The stainless steel filters and portafilter holder
should be rinsed under water immediately For best performance from your espresso
after use to remove all coffee particles. You maker, decalcify the unit from time to time. The
may also use a cleaning pin to clean the frequency depends on the hardness of your tap
opening. water and how often you use the coffeemaker.
To clean, fill the water reservoir to capacity with
Periodically run water through the machine a mixture of white vinegar and water. Be
with the portafilter holder in place, but without sure the power button is in the off position, and
any ground coffee, to rinse out any lingering the unit is unplugged. Remove the portafilter
coffee particles. The inside of the brew head holder. Pour the decalcifying agent into the
should be wiped with a damp cloth to remove water reservoir, plug the machine back in, and
any coffee particles. power the unit back on. Set the power button to
CLEANING THE OUTER HOUSING/CUP on and the function knob to the off position.
WARMING PLATE Place a large container under the brew head
and steam wand. When brewing temperature is
The outer housing and cup warming plate can
reached, the heating light will switch off. Set the
be cleaned with a soft, damp cloth.
function knob to the espresso position (show
Do not use any scouring agents or harsh
icon of espresso cup) and let half of the solution
cleaners.
run through the brew head. Set the function
CLEANING THE DRIP TRAY knob to steam position and allow the remaining
The drip tray can be removed after the grate is solution to run through the steam wand. When
removed and then cleaned with a soft, damp the solution stops running, set the function knob
cloth. Do not use any scouring agents or back to the off position. After decalcifying, let
harsh cleaners. one cycle of fresh cold water through the unit
before using the unit again to brew coffee.
The drip tray can be washed in warm soapy
water and rinsed thoroughly. Use a non-
RECIPES *This could also be used to make two single
espressos. Follow the same instructions for
Classic Espresso the Doppio, but place two demitasse cups
under the brew head instead of one.
Makes 1 serving (1 ounces)
Americano
1 easured scoop finely ground
m
espresso or 1 espresso pod Makes 1 serving (6-8 ounces)
10
Turn the Cuisinart Espresso Maker on. When Secure the portafilter holder in place. Place a
the machine is heated and ready to use, the demitasse cup underneath the brew head and
amber heating light will go out. turn the function knob to the espresso
setting. Espresso will begin to brew. When 1
Secure the portafilter holder in place. Place a
ounces have been brewed (after about 15
demitasse cup underneath the brew head
seconds), to turn the machine off.
and turn the function knob to the espresso
function. Espresso will begin to brew. When Using a large spoon, spoon one tablespoon of
1 ounces have been brewed (after about 15 the frothed milk on top of the espresso.
seconds), turn the machine off.
Take whipped cream out of refrigerator and
Espresso Breve
spoon about 1 tablespoon on top of espresso. Makes 1 serving (3 ounces)
11
Cappuccino Caf Latte
Makes 1 serving (3 ounces) Makes 1 serving (5 ounces)
12
Mochaccino Caf Mocha
Makes 1 serving (5 ounces) Makes 1 serving (6 ounces)
13
Fill a tall glass with the steamed milk, leaving Slowly pour 1 ounces of the steamed milk
about 2 inches at the top. Add the espresso down the side of the glass. Top with 2
and chocolate syrup. Top the drink off with tablespoons of the frothed milk.
about 2 tablespoons of the whipped cream.
If desired, top with shaved chocolate or cocoa Iced Cappuccino
powder.
Makes 1 serving (4 ounces)
14
In a tall glass, place 3 to 4 ice cubes. Pour the
espresso over the ice; add the whole milk.
Frozen Mocha
Spoon 2 tablespoons of the frothed milk on Makes 1 serving (8 ounces)
top.
2 easured scoops finely ground
m
Frozen Espresso espresso or 2 espresso pods
water
Makes 1 serving (8 ounces)
1 teaspoon granulated sugar
2 easured scoops finely ground
m 2 tablespoons whole milk
espresso or 2 espresso pods
3 ice cubes
water
1 teaspoon granulated sugar Place the two-cup filter basket in the
portafilter holder. Spoon the espresso grounds
2 ice cubes into the basket. Using the tamping tool, lightly
Place the two-cup filter basket in the press down on the grounds and clean any
portafilter holder. Spoon the espresso grounds excess from the rim.
into the basket. Using the tamping tool, lightly Turn the Cuisinart Espresso Maker on.
press down on the grounds and clean any When the machine is heated and ready to
excess from the rim. use, the amber heating light will go out.
Turn the Cuisinart Espresso Maker on. Secure the portafilter holder in place. Place a
When the machine is heated and ready to glass underneath the brew head and turn the
use, the amber heating light will go out. function knob to the espresso setting.
Secure the portafilter holder in place. Place a Espresso will begin to brew and after 3
glass underneath the brew head and turn the ounces have been brewed (after about 25
function knob to the espresso setting. seconds), turn the machine off.
Espresso will begin to brew and when 3 Add the sugar to the hot espresso and stir to
ounces have been brewed (after about 25 dissolve. Pour the espresso mixture and the
seconds), turn the machine off. milk into the jar of a Cuisinart Blender. Place
Stir the sugar into the hot espresso and stir to the lid on and process on high. While the
dissolve. Pour the espresso/sugar mixture into motor is running, drop the ice cubes in and
the jar of a Cuisinart Blender. Place the lid on continue to process until the mixture is
and process on high. While the motor is homogenous, about 30 seconds.
running, drop the ice cubes in and continue to Pour into a glass.
process until the mixture is homogenous,
about 20 seconds.
Espresso Martini
Pour into a glass.
Makes 4 servings
15
Place the two-cup filter basket in the cups in total. Stir sugar into combined
portafilter holder. Spoon the espresso grounds espresso to dissolve.
into the basket. Using the tamping tool, lightly Pour the espresso mixture in a bowl. Cool to
press down on the grounds and clean any room temperature. Cover with plastic wrap
excess from the rim. and place in freezer. At every hour, for about 5
Turn the Cuisinart Espresso Maker on. hours in total, scrape the mixture with a fork
When the machine is heated and ready to to allow crystals to form.
use, the amber heating light will go out. To serve, layer equal amounts of granita and
Secure the portafilter holder in place. Place a whipped cream in a parfait glass. Garnish with
glass underneath the brew head and turn the shaved chocolate, if desired.
function knob to the espresso setting.
Espresso will begin to brew. After cup has
been brewed (after about 30 seconds), turn
Affogato
the machine off. Cover and refrigerate the Makes 2 servings
brewed espresso.
2 easured scoops finely ground
m
When espresso has fully chilled, pour it into a
espresso or 2 espresso pods
cocktail shaker filled with ice and add the
liquors. Shake and strain into individual water
espresso glasses. 2 scoops vanilla ice cream
Place the two-cup filter basket in the
Granita portafilter holder. Spoon the espresso grounds
Makes 4 servings into the basket. Using the tamping tool, lightly
press down on the grounds and clean any
4 easured scoops finely ground
m excess from the rim.
espresso or 4 espresso pods Turn the Cuisinart Espresso Maker on.
water When the machine is heated and ready to
use, the amber heating light will go out.
2 teaspoons granulated sugar
Secure the portafilter holder in place. Place
2 ups heavy cream, whipped to a stiff
c
two demitasse cups underneath the brew
peak head and turn the function knob to the
ittersweet or semisweet chocolate,
B espresso setting. Espresso will begin to
shaved (optional) brew. When 3 ounces have been brewed
(after about 25 seconds), turn the espresso
Place the two-cup filter holder in the portafilter
maker off.
holder. Spoon the espresso grounds into the
basket. Using the tamping tool, lightly press Place one scoop of ice cream in each of two
down on the grounds and clean any excess individual dishes. Pour one espresso over
from the rim. each scoop of ice cream.
Turn the Cuisinart Espresso Maker on.
When the machine is heated and ready to Espresso Gelato
use, the amber heating light will go out.
Makes 4 cups
Secure the portafilter holder in place. Place a
glass underneath the brew head and turn the 2 easured scoops finely ground
m
function knob to the espresso setting. espresso or 2 espresso pods
Espresso will begin to brew. After 1 cup has
water
been brewed (after about 40 seconds), turn
the espresso maker off. Repeat to have 2 3 cups whole milk
16
2 cups espresso beans Once properly chilled, process in a Cuisinart
1 cup brewed espresso Ice Cream Maker according to the units
instructions.
10 large egg yolks
1 cup granulated sugar Tiramis
pinch of salt Makes 4 cups
Place the two-cup filter basket in the
portafilter holder. Spoon the espresso grounds 4 easured scoops finely ground
m
into the basket. Using the tamping tool, lightly espresso or 4 espresso pods
press down on the grounds and clean any water
excess from the rim.
3 large eggs
Turn the Cuisinart Espresso Maker on.
When the machine is heated and ready to cup granulated sugar, separated
use, the amber heating light will go out. 1 (8-ounce) container mascarpone
Secure the portafilter holder in place. Place a cheese
glass underneath the brew head and turn the cup chilled heavy cream
function knob to the espresso setting.
1 tablespoon water
Espresso will begin to brew. When 1 cup has
been brewed (after about 40 seconds), turn pinch of salt
the espresso maker off. Reserve. 2 cups brewed espresso, cooled
Pour milk into a medium sized, heavy- 2 tablespoons dark rum (optional)
bottomed saucepan. Over medium-low heat,
gradually bring the milk to a boil. Turn the 24 unces bittersweet chocolate, shaved
o
burner off and stir in the espresso beans. or unsweetened cocoa powder
Let steep for 15 to 20 minutes. Strain; discard (for garnish)
beans. Place the two-cup filter basket in the
Add the espresso to the steeped milk. Over portafilter holder. Spoon the espresso grounds
medium-low heat, gradually bring to a boil. into the basket. Using the tamping tool, lightly
press down on the grounds and clean any
While the milk/espresso mixture is heating, excess from the rim.
slowly whisk the sugar and salt into the egg
yolks. Beat together until the mixture is light Turn the Cuisinart Espresso Maker on.
and thickened. When the machine is heated and ready to
use, the amber heating light will go out.
Once the milk/espresso mixture has reached a
boil, slowly whisk of it into the yolk mixture. Secure the portafilter holder in place. Place a
Return the combined mixture to the remaining glass underneath the brew head and turn the
milk/espresso in the saucepan. Over medium- function knob to the espresso setting.
low heat, stirring constantly in a figure-eight Espresso will begin to brew. When 1 cup has
rotation with a wooden spoon, heat the been brewed (after about 40 seconds), turn
mixture until it coats the back of a spoon, the espresso maker off. Repeat to brew a total
about 4 minutes. This mixture must NOT boil of 2 cups. Reserve.
or the eggs will overcook. Whisk together yolks and cup sugar in a
Strain into a container and cool to room large bowl over a simmering pot of water.
temperature. Cover; refrigerate for 2 to 3 Whisk in rum. Continue whisking until the
hours, or overnight. mixture is thick and pale and warm to the
touch.
17
Using a Cuisinart hand mixer with the beaters
attached, beat in the mascarpone cheese, on
the lowest level, until just combined. Reserve.
With the whisk attachment of the Hand Mixer,
beat the cream to soft peaks. Gently fold in
the whipped cream to the mascarpone
mixture until just combined, but still streaky.
In another bowl, with a cleaned whisk
attachment on the hand mixer, beat the egg
whites, salt, and water, to soft peaks. While
still beating, gradually add the remaining
sugar and beat to medium-stiff peaks. Gently
fold the meringue into the mascarpone/cream
mixture.
In a shallow bowl, mix the espresso and rum.
Dip 1 ladyfinger in, soaking each side for a
few seconds, and transfer to an 8-inch (2-
quart) glass baking dish. Repeat with 11 more
and arrange in the bottom of the dish,
trimming if necessary to cover the entire
surface. It should be a tight fit. Reserve.
Spread half of the mascarpone/meringue
mixture over the soaked ladyfingers. Make
another layer of ladyfingers and spread an
even layer of the remaining mascarpone
mixture on top. Cover with plastic wrap and
chill for at least 6 hours.
Before serving, sprinkle with the shaved
chocolate or the cocoa powder.
18
WARRANTY These warranties expressly exclude any defects
or damages caused by accessories,
replacement parts or repair service other than
Limited Three-Year those that have been authorized by Cuisinart.
Warranty These warranties exclude all incidental or
This warranty supersedes all previous consequential damages. Some states do not
warranties on the Cuisinart Espresso Maker. allow the exclusion of or limitation of incidental
or consequential damages, so the foregoing
This warranty is available to consumers only. limitation or exclusion may not apply to you.
You are a consumer if you own a Cuisinart
Espresso Maker that was purchased at retail for CALIFORNIA RESIDENTS ONLY
personal, family or household use. Except as California law provides that for In-Warranty
otherwise required under applicable state law, Service, California residents have the option of
this warranty is not available to retailers or other returning a nonconforming product (A) to the
commercial purchasers or owners. store where it was purchased or (B) to another
We warrant that your Cuisinart Espresso retail store which sells Cuisinart products of the
Maker will be free of defects in material or same type. The retail store shall then, according
workmanship under normal home use for three to its preference, either repair the product, refer
years from the date of original purchase. the consumer to an independent repair facility,
replace the product, or refund the purchase
We suggest that you complete and return the price less the amount directly attributable to the
enclosed product registration card promptly to consumers prior usage of the product. If either
facilitate verification of the date of original of the above two options does not result in the
purchase. However, return of the product appropriate relief to the consumer, the
registration card is not a condition of these consumer may then take the product to an
warranties. In the event that you do not have independent repair facility if service or repair
proof of purchase date, the purchase date for can be economically accomplished. Cuisinart
purposes of this warranty will be the date of and not the consumer will be responsible for the
manufacture. reasonable cost of such service, repair,
If your coffeemaker should prove to be defective replacement, or refund for nonconforming
within the warranty period, we will repair it (or, if products under warranty.
we think it necessary, replace it) without charge California residents may also, according to their
to you. To obtain warranty service, please call preference, return nonconforming products
our Consumer Service Center toll-free at directly to Cuisinart for repair or, if necessary,
800-726-0190 or write to: replacement by calling our Consumer Service
Cuisinart Center toll-free at 800-726-0190. Cuisinart will
150 Milford Road be responsible for the cost of the repair,
East Windsor, NJ 08520 replacement, and shipping and handling for
To facilitate the speed and accuracy of your such nonconforming products under warranty.
return, please also enclose $10.00 for shipping BEFORE RETURNING YOUR CUISINART
and handling of the product (California residents PRODUCT
need only supply proof of purchase and should Important: If the nonconforming product is to be
call 1-800-726-0190 for shipping instructions). serviced by someone other than Cuisinarts
Please also be sure to include a return address, Authorized Service Center, please remind the
description of the product defect, product serial servicer to call our Consumer Service Center to
number, and any other information pertinent to ensure that the problem is properly diagnosed,
the products return. Please pay by check or the product serviced with the correct parts, and
money order. to ensure that the product is still under
Your Cuisinart Espresso Maker has been warranty.
manufactured to strict specifications and has
been designed for use with the Cuisinart
coffeemaker authorized accessories and
replacement parts for your model.
19
Coffeemakers Food Toasters Rice Cookers Cookware Grills
Processors
Cuisinart offers an extensive assortment of top quality products to make life in the
kitchen easier than ever. Try some of our other countertop appliances and
cookware, and Savor the Good Life.
www.cuisinart.com
2006 Cuisinart
Cuisinart is a registered
trademark of Cuisinart
20