Professional Documents
Culture Documents
Din 3962 3 1978 Eng PDF
Din 3962 3 1978 Eng PDF
I d L I U I 13
Part 3
EN 9
2 2 2
n n P
3 3 3
' E
E 88 8
<-
c
41
8
2
I I
5
I
10
I
50 100
I
Arc length I! in mm -
SOO lob0
5000 10000
Continued on page 2
www.bzxzw.com
Page 2 DIN 3962 Part 3
In general the tolerancing of the cumulative pitch over 45O and 180 of the gear periphery according to the vaiuesFpm
and Fp in DIN 3962 Part 1 is fully adequate. However, where additional tolerances are necessary for any other arc lenghts
or angle ranges, they should be selected according t o the diagram in this Standard.
Fp i s at least equal to f p . Therefore if with small arc lengths L it should happen that Fp < f p , then Fp should be made
equal t o t p , see also DIN 3961,August 1978 edition, Section 6.4.
www.bzxzw.com