Professional Documents
Culture Documents
Solutions To Chapter 15: Fire and Explosion Hazards of Fine Powders
Solutions To Chapter 15: Fire and Explosion Hazards of Fine Powders
EXERCISE 15.1:
It is proposed to protect a section of duct used for pneumatically transporting a food
product in powder form in air by adding a stream of carbon dioxide. The air flowrate
in the present system is 3 m3/s and the air carries 2% powder by volume. If the
minimum oxygen for combustion (by replacement of oxygen with carbon dioxide) of
the powder is 13% by volume, what is the minimum flowrate of carbon dioxide which
must be added to ensure safe operation?
At the limit, the exit oxygen concentration of the flowing mixture should be 13% by
volume.
from which, the minimum required flow rate of added carbon dioxide, n = 1.75 m3/s.
EXERCISE 15.2:
A combustible dust has a lower flammability limit in air at 20C of 1.2% by volume.
A dust extraction system operating at 3 m3/s is found to have a dust concentration of
1.5% by volume. What minimum flow rate of additional air must be introduced to
ensure safe operation?
CHAPTER 15: FIRE AND EXPLOSION HAZARDS OF FINE POWDERS Page 15.1
air: 2.955 m3/s 98.5% by volume
dust: 0.045 m3/s 1.5% by volume
At the limit, the dust concentration after addition of dilution air will be 1.2%, hence:
from which, the minimum required flow rate of added dilution air, n = 0.75 m3/s.
EXERCISE 15.3:
A flammable pharmaceutical powder suspended in air at a concentration within the
flammable limits and with an oxygen concentration above the minimum oxygen for
combustion flows at 40 m/s through a tube whose wall temperature is greater than the
measured ignition temperature of the dust. Give reasons why ignition does not
necessarily occur.
EXERCISE 15.4:
A fine flammable plastic powder is leaking from a pressurised container at a rate of
0.5 litres/min into another vessel of volume 2 m3 and forming a suspension in the air
in the vessel. The minimum explosible concentration of the dust in air at room
temperature is 1.8% by volume. Stating all assumptions, estimate:
a) the delay from the start of the leak before explosion occurs if there is no
ventilation
b) the delay from the start of the leak before explosion occurs if the air ventilation
rate in the second vessel is 0.5 m3/h
c) the minimum safe ventilation rate under these circumstances.
CHAPTER 15: FIRE AND EXPLOSION HAZARDS OF FINE POWDERS Page 15.2
SOLUTION TO EXERCISE 15.4:
Mass balance on the dust in the second vessel:
dC
V = F in Qout C (Solution Manual-Equation 15.4.1)
dt
(where Fin is the leak rate of dust in m3/h, Qout is the air ventilation rate in m3/h, V is
the volume of the second vessel in m3 and C is the dust concentration in m3/m3 in the
second vessel at time t).
(Leak rate of dust into vessel,
F in = 0.5 litres / min = 0.5 10 -3 60 m3 / h = 0.03 m 3 / h )
dC
(a) If there is no ventilation, Qout = 0 and so V = F in = 0.03
dt
Integrating, C = 0.015t + constan t
Q out C
2 0.015 - 2
t= ln hours
Q out 0.015
Assuming the explosion occurs when the dust concentration reaches the lower
flammability limit, 1.8%.
Therefore, substituting Qout = 0.5 m3/h and C = 0.018 m3/m3 in the above equation:
0.5 0.018
0.015 -
2 2
time required = t = ln = 1.43 hours .
0 .5 0.015
CHAPTER 15: FIRE AND EXPLOSION HAZARDS OF FINE POWDERS Page 15.3
(c) To ensure safety, the limiting ventilation rate is that which gives a dust
concentration of 1.8% in the second vessel at steady state (ie. when dC/dt = 0). Under
this condition, from Solution Manual-Equation 15.4.1:
0 = Fin Qout,safeC
Hence, the minimum ventilation rate for the second vessel = 1.667 m3/h.
CHAPTER 15: FIRE AND EXPLOSION HAZARDS OF FINE POWDERS Page 15.4