Professional Documents
Culture Documents
Module 10 Exam Practice Exam Module 10 Aircraft Regulations: This Is Exam Number 1
Module 10 Exam Practice Exam Module 10 Aircraft Regulations: This Is Exam Number 1
Answer:C
Answer:B
6. A type certificate is
a) issued before a C of A
b)issued after a C of A
c) issued after a CRS
Answer:A
7. Scheduled maintenance can be extended by authority written into the
a) Approved Maintenance Schedule
b)Approved Maintenance Document
c) Aircraft Maintenance Manual
Answer:A
8. Vital points are
a) a check on every maintenance schedule input
b)when an engine/fuel system is disturbed
c) parts of the aircraft where a single malfunction could cause
catastrophic failure
Answer:C
Answer:B
4. What does JAR stand for?
a) Joint Aviation Requirements
b)Joint Airworthiness Requirements
c) Joint Airworthiness Regulations
Answer:A
Answer:C
6. If an engineer has a heavy cold, he/she
a) may take medication without advice
b)must seek medical advice from a doctor
c) must take only the medication which is prescribed specifically to
him/her
Answer:A
10. If the CAA require an engineer to produce his/her license, this must
be done
a) immediately
b)as soon as possible
c) within seven (7) days
Answer:A
6. When the block CRS is finally issued for base maintenance at a JAR
145 organisation, who is ultimately responsible for maintenance carried
out during the check?
a) the Accountable Manager
b)the Category C LAE
c) the Category B LAE
Answer:C
Answer:A
8. A JAR 145 approval is not required to carry out
a) pre-flight checks
b)daily checks (as long as 48 hours has not passed)
c) defect rectification
Answer:A
9. How long does a JAR 145 approved organisation have to retain aircraft
documents?
a) At least four (4) years after the aircraft has been permanently
withdrawn from service
b)Five (5) years after the aircraft has been permanently withdrawn from
service
c) Two (2) years after the aircraft has been released from the
organisation
Answer:C
4. Where would you find the requirements and the syllabus for a
maintenance license?
a) JAR 66
b)JAR 145
c) JAR 147
Answer:A
Answer:A
9. The Flight Manual is part of the
a) Certificate of Airworthiness
b)JAA Form 1
c) Certificate of Registration
Answer:A
10. All aircraft which fly in UK airspace must be registered, with the
exception of
a) kites, balloons, gliders and variant aircraft
b)kites, captive balloons and aircraft under B conditions
c) none
Answer:B
Answer:A
7. Since June 1st 2001, engineers are required to be licensed in
accordance with
a) BCARs
b)JAR 66
c) ICAO
Answer:B
8. A JAR 145 maintenance organisation has to conform to
a) BCARs
b)Sub Part M of JAR OPS
c) ANO Article 104
Answer:B
Answer:C
10. An approved maintenance organisation is authorised to
a) issue certificates for work completed in aircraft maintenance or
overhaul
b)originate repair schemes and manufacture parts
c) approve major modifications
Answer:A
Answer:A
4. Scheduled Maintenance can be extended by
a) authority written into the approved maintenance manual
b)authority written into the approved maintenance document
c) authority written into the approved maintenance schedule
Answer:C
Answer:A
10. What is an ‘Exposition’?
a) A document which sets out details of an organisation
b)A document which sets out details of the maintenance schedule
c) A document which sets out details of how maintenance work is
carried out
Answer:A
5. What Certificate must an Operator have who flies for public transport
and cargo carrying?
a) Air Operators Certificate
b)Air Navigation Certificate
c) Air Transport Licence
Answer:A
6. Where is a definition of a ’reportable accident’ found?
a) In the Air Navigation Order
b)In the Air Navigation (General) Regulations
c) In the Civil Aviation (Investigation of Accidents) Regulations
Answer:C
4. The legal responsibility for ensuring that the aircraft load is not
excessive and has been properly loaded rests with
a) Chief Pilot
b)Load Master
c) Commander of the aircraft
Answer:C
Answer:B
6. When does a Radio Licence become valid?
a) When the C of A is issued
b)After the radio station has been approved and the C of A issued
c) Once the Certificate of Registration has been issued
Answer:B
1. A Type Certificate is a
a) pre-requisite to the issue of a C of A
b)requirement for aircraft above 2730Kg MTWA
c) requirement prior to the issue of a C of A for aircraft in the
Transport Category.
Answer:A
2. A B2 License applies to
a) line maintenance on electrical systems and avionics
b)line maintenance on airframe structure
c) line maintenance on airframe structure and powerplants
Answer:A
Answer:A
7. A LAE license remains valid
a) if he/she has received continuation training in the last 2 years
b)if he/she has worked on aircraft for 6 months in the last 2 years
c) if he/she has worked on aircraft for 4 months in the last 2 years
Answer:B
8. An approved certificate must have
a) an approved signature
b)the Store Managers signature
c) the signature of the issuing clerk
Answer:A
Answer
1. 2 3 4 5 6 7 8 9 10
C A B C B C B C A C
10. Who is responsible for the control and issue of engineers licenses
a) CAA
b)JAA
c) ICAO
Answer
1. 2 3 4 5 6 7 8 9 10
B B C C A A B A B A
This is exam number 13.
OOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO
OOOOOOOOOOOOOOOOOO
2. Where is the period of validity of CMR stated?
a) Maintenance schedule
b)Maintenance manual
c) AOC
1. When investigation is carried out for the issue of an AOC the NAA
a) acts on behalf of the JAA for technical findings and for itself on
legal findings
b)acts for itself for both technical and legal findings
c) acts on behalf of the JAA for legal findings and for itself for
technical findings
4. Condition Monitoring is
a) a preventative process
b)not a preventative process, having neither Hard Time nor
On-Conditioning elements
c) a combination of Hard Time and Flexi-time working practices
7. An MMEL is compiled by
a) an air operator and approved by he CAA
b)the manufacturer and the CAA after joint consultation
c) the manufacturer and the AOC company after joint consultation and
then approved by the CAA
7. I.C.A.O provides
a) a set of rules which all NAAs must adhere to
b)safe, orderly development of civil aviation with equal opportunity
c) a set of safety guideline for operators and maintenance
organisations
8. If the second copy of the Tech Log can not be left on the ground, it
should
a) be flown in an approved box by the CAA on the aircraft
b)flown on a different aircraft
c) carried by the pilot
b)Manufacturer
c) Approved Organisation
1. CAP 393 is
a) the ANO and regulations
b)AWNs
c) Air Operators Certificate
5. AWN 3 is
a) coloured white
b)related to engineers licance rating
c) related to the responsibilities of licensed engineers
10. A maintenance company approved under JAR 145 is required for the
maintenance of:
a) all aircraft with a valid United Kingdom certificate of
airworthiness
b)all UK civil registered aircraft operating for commercial air
transport
c) only those commercially operated, UK civil registered, aircraft
over 5700 KG
Answer
1. 2 3 4 5 6 7 8 9 10
A B B B C A A C A B
10. Consumable items such as split pins, nuts, nuts bolts etc are
usually identified by a
a) batch number on each item
b)release note on each item
c) batch/part number on the containing bag
Answer
1. 2 3 4 5 6 7 8 9 10
C B A B C C A B B C
3. The Approval Authority Number for a typical UK JAR 145 company would
be
a) AI/1234/94
b)DAI/1234/94
c) CAA 00023
8. All reports received by the CAA under the MOR scheme are processed by
the
a) safety data department
b)Occurrence Digest Unit
c) Air Accident Investigation Branch
Answer
1. 2 3 4 5 6 7 8 9 10
C A C B A A C A B B
10. The ANO states that the Log Book shall be kept for the aircraft and
one for
a) each engine and VP propeller
b)each engine and undercarriage
c) its radio and navigation equipment
Answer
1. 2 3 4 5 6 7 8 9 10
B B C B C A B B B A
1. In which book would you expect to find all the following: a CMR, a
maintenance statement, a sector record and a deferred defect?
a) Flight manual
b)Aircraft Log book
c) Technical log book
8. For a simple aircraft the CAA LAMS Schedule may need to be amended by
a) deleting non application items
b)rewriting it
c) completing the supplementary tests
Answer
1. 2 3 4 5 6 7 8 9 10
C A C A C C C C C C
This is exam number 24.
2. A maintenance statement is
a) the approval for a maintenance schedule
b)part of the tech log
c) used to certify a pre-flight check
8. A flight manual
a) forms part of the C of A
b)is sometimes called the operations manual
c) must be carried on all public transport aircraft
2. A C of A for export is
a) A statutory document
b)to allow an aircraft to be flown away on export
c) necessary for each exported aircraft
7. Guidance with respect to JAR 145 and CAA national requirements can be
found in
a) CAAIPs
b)AWN 14
c) BCAR section A
Answer
1. 2 3 4 5 6 7 8 9 10
B C B A B A B B B A
8. B.C.A.R.s
a) are issued by Ministry of Trade and Industry
b)contain minimum requirements to be met
c) detail mandatory requirements for aircraft design and
construction
9. CAAIPs
a) are issued by CAA
b)contain mandatory instructions
c) contain approved inspection procedures
Answer
1. 2 3 4 5 6 7 8 9 10
C C A A A C A B A A
9. A C. of R. is renewable
a) every year
b)when ownership changes in U.K. only
c) when aircraft is sold abroad
10. A C. of R
a) is issued by Ministry of Trade and Industry
b)may not be issued if aircraft could be more suitable registered
elsewhere
c) is valid only in country of origin
Answer
1. 2 3 4 5 6 7 8 9 10
A C C B B C C C C B
1. An approved store
a) is required by every approved organization
b)must contain at least a bonded store
c) is the responsibility of Quality Assurance Department
Answer
1. 2 3 4 5 6 7 8 9 10
C B A B A C B B A A
This is exam number 29.
Answer
1. 2 3 4 5 6 7 8 9 10
C B B B B B C B C C
Answer
1. 2 3 4 5 6 7 8 9 10
A B C A A C C B B B
Answer
1. 2 3 4 5 6 7 8 9 10
A A A B B A B C B C
Answer
1. 2 3 4 5 6 7 8 9 10
C A B B C C C A B A
4. When extra documents are used for maintenance recovery and are too
numerous to list in the aircraft Log Book, what action is taken?
a) Enter brief details in the Log Books and cross refer to a work pack
b)Obtain new Log Book and cross refer to the original Log Book
c) Enter brief details in Log Book and retain documents
8. A Quarantine Store
a) holds life controlled items only
b)holds materials and parts until proved to conform to specification.
c) holds parts and materials received from overseas
9. A bonded Store
a) holds parts and materials until released by H.M. Customs
b)holds aeronautical supplies proved to conform to specification
c) holds aeronautical supplies which have failed to conform.
1. A concession is
a) authority for a permanent reduction of a requirement
b)authority to accept a limited quantity of parts which may not be
strictly in accordance with the relevant drawings or specifications
c) authority not to embody a modification
8. A Flight Manual is
a) for information of the crew only
b)part of the Certificate of Airworthiness
c) part of the Certificate of Registration
10. Where would you find inspection and classification of damage and
repair
a) Maintenance Manual
b)Flight Manual
c) Repair Manual
Answer
1. 2 3 4 5 6 7 8 9 10
B A A B A C A B B C
4. The aircraft captain records the aircraft hours flown and defects in
a) Aircraft Log Book
b)Technical Log
c) Maintenance Statement
7. Where would you find mandatory instrument marking and warning plaques
a) Crew Manual
b)Chapter 11 of the Maintenance Manual (complying with ATA 100)
c) Aircraft Operations manual
8. Who produces and prints maintenance schedules?
a) CAA for Air Operators Certificate Organizations
b)CAA and approved by the manufacturer
c) Aircraft manufacturer and in some cases the operator, and approved
by CAA.
10. When a minor adjustment to a control system has been made away from
base, a pilot or flight engineer may sign, if licensed for the type
concerned
a) both parts of the duplicate inspection
b)the second part of the duplicate inspection
c) neither part of the duplicate inspection
Answer
1. 2 3 4 5 6 7 8 9 10
C C C B B B C C B B
Answer
1. 2 3 4 5 6 7 8 9 10
B B A B B C A C C B
4. The basis for the flight duration time entered in the Aircraft Log
Book is
a) chock to chock
b)take-off to touch down
c) engine start to engine cut
2. A Flight Manual is
a) issued by the C.A.A.
b)issued by the Operator
c) part of the C of A
10. A new imported series aircraft requires flight testing prior to the
issue of its first British C of A. this flight test should be carried out
under
a) ‘B’ Conditions of Schedule 2 of the A.N.O.
b)No Fitness for Flight Certificate as it has a foreign C of A
c) ‘A’ Conditions of the A.N.O.
Answer
1. 2 3 4 5 6 7 8 9 10
A C A B C B B A A A
7. A letter of Transmittal
a) authorizes an amendment to a Maintenance Manual
b)records acceptance of a Type Certificate
c) authorizes a Maintenance Schedule by the CAA
10. The total engine hours expended may be determined from information
given in
a) the Technical Log
b)the Engine Log Book
c) the Maintenance Statement
Answer
1. 2 3 4 5 6 7 8 9 10
A C A C B A A B B B
c) current C of A
2. In the ATA 100 format, what would the third element of the reference
number refer to?
a) Chapter or system
b)Subject or component
c) Section or sub section
Answer
1. 2 3 4 5 6 7 8 9 10
C B B C C A B B B A
6. CRSs are
a) signed before each flight
b)kept for 2 years
c) can be signed by company approved engineers
4. JAR 145
a) applies only to European Aircraft
b)lists the minimum requirements acceptable to the CAA
c) replaces the relevant chapters of BCAR Section A
5. In order to obtain a type rating on an aircraft, an engineer must
a) have a manufacturer’s course within the last 3 years
b)work on the type for 6 months in the last 24 months
c) must work on aircraft for 6 months within the last 24 months
3. The check cycle for aircraft operating under the CAA LAMS/FW/1978
issue 2 is
a) 50 hr., 100 hr. Annual and star inspections
b)78 hr., 150 hr. and star inspections
c) 50 hr., 150 hr. Annual and star inspections
4. Radio flight test certificates are certified by
a) a CAA Radio Surveyor
b)a Type Rated (Radio) L.A.E.
c) a pilot
9. Condition monitoring
a) is a preventative maintenance process
b)permits in-life until failure occurs
c) is a time lifed method of maintenance
10. The allowable deficiency list is normally included in an aircraft’s
a) operations manual
b)modifications record book
c) approval document to the aircraft maintenance schedule
Answer
1. 2 3 4 5 6 7 8 9 10
A B C C A C C A B A
7. A star inspection is
a) an annual inspection coincident with a survey for C of A renewal
for Aaircraft not exceeding 2730kg MTWA
b)an inspection which has to be carried out on an imported aircraft to
ensure that it complies with U.K. additional requirements for foreign
aircraft, prior to the issue of a C of A.
c) an inspection to be carried out on a special category aircraft
prior to its Cof A renewal
10. The wording for the Certificate of Fitness for Flight is to be found
in
a) Chapter A6-2 of BCAR
b)Chapter (A&B) 3-8 of BCAR
c) Chapter (A&B) 6-7 of BCAR
Answer
1. 2 3 4 5 6 7 8 9 10
B B C A C B A B A B
Answer
1. 2 3 4 5 6 7 8 9 10
A A C C B C A A B B
6. How many times must the nationality and registration marks appear on
an aircraft?
a) 3 times
b)4 times
c) 5 times
8. At C of A renewal
a) the aircraft needs to be reweighed
b)the aircraft only needs to be reweighed if it is due for re-weighing
c) the aircraft needs to be reweighed because the CAA have requested
it
7. In a small JAR 145 company, the independent audit part of the quality
control system
a) may be contracted out to another 145 organisation
b)must be carried out by a person permanently employed by the company
c) is not necessary
Answer
1. 2 3 4 5 6 7 8 9 10
B B A A A B A B B A
This is exam number 54.
9. Where would you find details of the tasks that the holder of a PPL
can do on his own aircraft if it has a C of A in the private category?
a) BCAR A8-15
b)AN(G)R's
c) JAR 145
Answer
1. 2 3 4 5 6 7 8 9 10
C B C C C A B A C A
6. The responsibility to keep and maintain aircraft log books lies with
a) the owner
b)the operator
c) the JAR 145 organisation maintaining the aircraft
Answer
1. 2 3 4 5 6 7 8 9 10
C C C C A B C C C A
Answer
1. 2 3 4 5 6 7 8 9 10
A A B A A A A B A A
Answer
1. 2 3 4 5 6 7 8 9 10
A
2.
a)
b)
c)
3.
a)
b)
c)
4.
a)
b)
c)
5.
a)
b)
c)
6.
a)
b)
c)
7.
a)
b)
c)
8.
a)
b)
c)
9.
a)
b)
c)
10.
a)
b)