Professional Documents
Culture Documents
http://www.bosch-home.co.uk
Sensixx‘x DA70
en Operating instructions
Index pag
BOSCH 3
EN • Operating instructions
4 BOSCH
Important notices • This appliance must be connected to
• This appliance has been designed an earthed socket. If it is absolutely
exclusively for domestic use and must not necessary to use an extension cable,
be used for industrial purposes. make sure that it is suitable for 16A and
has a socket with an earth connection.
• This appliance must be used only for
the purposes for which it was designed, • The appliance must never be placed
i.e. as an iron. Any other use will be directly under the tap to fill the water tank.
considered improper and consequently • Unplug the appliance from the mains
dangerous. supply after each use, or if a fault is
• The manufacturer will not be held suspected.
responsible for any damage arising from • The electrical plug must not be removed
misuse or improper use. from the socket by pulling the cable.
• This appliance reaches high temperatures • Never immerse the iron in water or any
and produces steam during use, this other fluid.
could cause scalds or burns in case of • Do not leave the appliance exposed to
improper use. weather conditions (rain, sun, frost, etc.).
- Do not touch the soleplate! Hold the
iron by its handle. Advice on disposal
- Do not leave the supply cord hanging Our goods come in optimized packaging.
over the table or ironing board, to This basically consists in using non-
prevent the appliance from falling. contaminating materials which should be
- Do not iron clothing while it is being handed over to the local waste disposal
worn! service as secondary raw materials. Your
local town council can give you information
- Never spray or aim the steam at
about how to dispose of obsolete
persons or animals!
appliances.
• Do not allow the power cable to come
This appliance is labelled in
into contact with sharp edges or with the
accordance with European
soleplate when it is hot.
Directive 2012/19/EU
• Never rest the iron in a horizontal position concerning used electrical and
when the soleplate is hot. Rest it on its electronic appliances (waste
heel. electrical and electronic
• Do not touch the appliance with wet equipment – WEEE).
hands when in operation. The guideline determines the framework
• This appliance is to be connected and for the return and recycling of used
used in accordance with the information appliances as applicable throughout the
stated on its characteristics plate. EU.
BOSCH 5
14 1 2
13
4
5
6
12
11 10 9 8 7
15*
TDZ1550
16*
17*
TDZ1101
TDZ1750
* Model dependent
6 BOSCH
Description EEposition
Set the steam regulator (3) to the
and unplug the iron from
the mains!
1. Spray button
2. Shot of steam button
3. Steam regulator
4. Water inlet
5. Water inlet lid
6. Spray nozzle
7. Soleplate
8. Level mark for maximum filling
9. Temperature index
10. “clean” button
11. Water tank
1. Open the water inlet lid (5).
12. Temperature control
2. Fill the water tank (11). Never fill beyond
13. Power cord the level mark for maximum filling (8).
14. “SensorSecure” light
15. “TextileProtect” fabric protector *
16. Descaling liquid *
17. “StoreProtect” accessory *
45º
* Model dependent
8 BOSCH
2.3 “AntiShine” function* 3. Ironing with steam
If this function is selected, the risk of shiny The steam regulator (3) is used to adjust
marks on the garment due to the ironing is the amount of steam produced when
reduced. ironing.
When the “AntiShine” function is selected, 1
1 2 3 max
2 3 max
the blue light inside the temperature control Temperature Recommended position of
comes on. control (12) the steam regulator
• eco
• eco max (3) *
• max
•
1 2 3 max
max
11 22 33 max
• eco
eco ••
max
max
•• eco • max
1 2 3
1 2 3 maxmax
• eco
• • max
eco • max
1 2 3 max
i-Temp 1 2 3 max
1 2 3 max
1• eco
2 3• max
max
1 eco max
2 3•• max
•• eco
AntiShine
• eco • max
• eco • max
5´´
* Model dependent
10 BOSCH
2. Hang article of clothing on a clothes
hanger. Operate the iron in a vertical 6. Ironing without steam
position at a distance of 10 cm / 4 in,
and press the shot of steam button This enables the iron to be used for dry
(2) repeatedly with pauses of at least 5 ironing.
seconds.
1. Set steam regulator (3) to the position.
10 cm / 4 in
5´´
lf the temperature is set too low, the steam The “SensorSecure” function switches
is automatically switched off to avoid off the iron when the handle is no longer
dripping. gripped, thus increasing safety and
There may be an audible click when this saving energy.
occurs. 1. Plug in the iron.
* Model dependent
12 BOSCH
3. If the iron handle is released for more 2. Empty the tank. Hold the iron with the
than 10 seconds, the iron will stop point down and shake lightly.
heating automatically.
4. When the handle is gripped again, the
iron heating up and continuous steam
generation processes will start again.
Initial heating up process: it is not
necessary to grip the handle until the iron
heats up to the set temperature.
Once reached such temperature, the
“TempOK” indicator will stop flashing and
remain lit continuously.
10. After ironing 4. Store the iron standing on the rear, not on
the soleplate. Do not wrap the power cord
1. Switch the steam regulator (3) from to (13) too tight!
“max” and back again several times (self-
cleaning).
* Model dependent
14 BOSCH
2 Set the temperature control (12) to the
Multiple descaling system “max” position and plug in the iron.
AntiCalc
C.
D. anti-calc
A. self-clean
B. Calc'nClean
B Calc’nClean
The “Calc’nClean” function helps to remove
scale particles out of the steam chamber.
Use this function approximately every 2
weeks if the water in your area is very hard.
1 Unplug the iron from the mains socket,
set the steam regulator (3) to the
position and fill the water tank (11) with
water.
45º
7 Repeat the steps 5 and 6 three times C “Calc’nClean” with descaling liquid *
until the tank is empty. For deep descaling, it is recommended to
use the descaling liquid especially
developed by Bosch. This procedure should
be carried out every 3 months.
1. Fill the water tank (11) with tap water
mixed with a measure (25 ml) of the
descaling liquid (16*).
2. Then follow the procedure described
above in section “Calc’nClean” (steps 2 to
9).
The descaling liquid may be purchased
x3 from our after-sales service or specialist
shops.
Name of accessory: TDZ1101
* Model dependent
16 BOSCH
D anti-calc*
The “anti-calc” cartridge has been designed
“StoreProtect” *
StoreProtect
to reduce the build-up of scale produced
during steam ironing, helping to extend the The “StoreProtect” accessory (17*)
useful life of your iron. Nevertheless the enables an immediate and safe storage
“anti-calc” cartridge cannot remove all of the of the iron, even with a hot soleplate (7).
scale that is produced naturally over time. This accessory may be purchased from our
after-sales service or specialist shops.
Name of accessory: TDZ1750
“TextileProtect” fabric
TextileProtect protector *
The fabric protector (15*) is used for
steam-ironing delicate garments at
maximum temperature without damaging
them.
The fabric protector may be purchased from
our after-sales service or specialist shops.
Name of accessory: TDZ1550
18 BOSCH
Guarantee conditions
The terms of the guarantee for this
appliance are in accordance with that stated
by our representative for the country in
which it is sold.
The details of these conditions can be
obtained from the retailer from whom the
appliance was purchased. The purchase
receipt must be presented when making
any claims against the terms of this
guarantee.
Customer Service
Great Britain
Bosch Customer Service
Grand Union House UK +44 (0)344 892 8979
Old Wolverton Road Milton Keynes IRL +353 (0)1450 2655
MK12 5PT www.bosch-home.co.uk