Professional Documents
Culture Documents
1A. With the help of a block diagram describe the steps for transferring a sensor data to PLC. What are
the safety constraints involved?
1B. Write about sinking device with a sourcing input module and sourcing device with sinking output
module.
1C. Draw the structural and functional block diagram of PLC.
(5+3+2)
2A.
In this application a lifter motor is used a tray of PCB boards up, before being pushed up the piston
onto the conveyor for packing. When the start button is pressed, the conveyer motor and the lifter
motor will turn on. The proximity switch will temporarily stop the lifter motor for the position to
push the PCB onto the conveyor belt. After the PCB is pushed, the piston will retract and the lifter
motor starts again. The whole procedure should take place within 45 sec; if it exceeds an alarm sign
should be done. Develop appropriate ladder logic.
3B. With an example, draw the block diagram for the following:
i. FAL
ii. FLL
3C. Draw the electrical symbol for the following devices
a. alarm
b. horn
c. solenoid valve
d. motor over load contact
(5+3+2)
4A. Explain all types of PLC troubleshooting methods.