Professional Documents
Culture Documents
Application
The E7800 Motorized Potentiometer is proper electrical contact at all times. The On DC versions the potentiometer speed
typically used as an interface between use of a real potentiometer also provides is adjustable by a built-in trim potentio
increase/decrease contacts and a device the additional feature of manual control. meter, which is an advantage for stabili
requiring control/adjustments by an sing control circuits. The speed can be
external potentiometer. Potentiometer resistance and number of adjusted from 0.8 to 6 revolutions per
turns (gearing) must be specified upon minute (RPM), equal to 75 to 10 seconds
In generator control applications with ordering. Optional RPM adjustment is per revolution.
generator sets, the E7800 Motorized also available. Potentiometer and output The three potentiometer wires as well as
Potentiometer can be used as speed trim ramp time is defined by number of turns the three motor connections are directly
of an electronic speed governor, inter and the optional RPM setting. RPM set- accessible on external connection terminals.
facing the synchronizer or the load sharer. ting is only available on the DC versions.
To obtain the speed setting, the potentio
meter supplied with the governor can Changing Potentiometer
be built into the E7800, and via this unit Function To fit into the assembly, the potentiometer
the frequency and load of the governor The Motorized Potentiometer is a to be attached must have a 6mm or 1/4”
are controlled. It is important in this combination of a potentiometer and an shaft diameter and a shaft length of
situation that the governor can operate electric motor, connected with a 20.6mm, measured from the part of the
with droop. coupling. There is a direct mechanical potentiometer that touches the outside
link between the potentiometer and the of the back plate to the end of the shaft.
The Motorized Potentiometer can also be knob, which gives access to adjusting Unscrew the back plate and remove the
used alone for full range speed adjustment the potentiometer in situations where supplied potentiometer. Remove the
or speed trim of electronic governors. manual control is necessary. clutch and fit to new potentiometer.
Another application is control of genera Fasten it firmly with an 0.05” Allen Key.
tor voltage, power factor and reactive The E7800 motorized potentiometer is Replace the back plate and fasten it with
load via the potentiometer for generator available for DC as well as AC voltage four screws, checking that the clutch has
voltage adjustment. These are only some supply. The unit features a large size a firm connection. Adjust the knob for
examples of many other industrial knob for manual control plus LED- symmetrical turning angle using the
applications. based indication of turn direction. centre screws on the knob under the cap.
Fig. 3. Dimensions.
Potentiometer Value
Please indicate potentiometer value by replacing
“xx” letters with digits according to the table below.