Professional Documents
Culture Documents
General Tolerance From Asme Y145m 2009 PDF
General Tolerance From Asme Y145m 2009 PDF
Limit dimensioning
-The high limit is placed
above the low limit.
1
Plus and Minus Tolerancing
-The dim. is given first and is
followed by a plus and minus
expression of tolerance.
2
Millimeter Tolerances
3
Φ25
C A
4
Inch Tolerances
5
Tolerances Accumulation
6
Dimensional Limits should
be counted from an origin.
7
Limit of size.
•MMC (Maximum Material Condition): The condition in which a
feature size contains max. amount of material within the limits of
size.
•LMC (Least Material Condition)
8
Angled Surface
• Where defined by a linear dimension and an angle, the surface lie within the tolerance by two
nonparallel planes.
•Where a tolerance zone with parallel boundaries is desired, the basic angle can be specified in
rectangle.
9
Conical Tapers
Φ23 Φ23
10
Flat Tapers
11
Radius Tolerance Controlled Radius Tolerance
12