Professional Documents
Culture Documents
Testing Cylinders PDF
Testing Cylinders PDF
Parts List for 57321042 Kit Parts List for 58220750 Kit
©2008 Vapor Bus International, Buffalo Grove, IL. All International Rights Reserved.
This controlled document is subject to change.
1 of 4
Vapor Bus International is a registered trademark. U.S. and Foreign Patents are applicable and/or pending for the products described and illustrated herein.
Overhaul Procedure Bulletin # 0015
Pneumatic Cylinder Re-issued April 2008
2 of 4
Vapor Bus International 1010 Johnson Drive Buffalo Grove, IL 60089 847-777-6400 Fax: 847-520-2222
Email: techsupport@vapordoors.com Web site: www.vapordoors.com
P/N 50510521
Overhaul Procedure Bulletin # 0015
Pneumatic Cylinder Re-issued April 2008
Re-Assembly
1. Install a new O-ring to the speed adjusting
screw on the front end cap. Replace the
spacer and jam nut. Note: If adjusting screw
is 1/4” dia. use 45528345-39 O-ring. If screw
is 5/16” dia. use 45528345-79 O-ring.
Some rear end caps on single-acting cylinders
may contain speed adjusting screws. If so,
If equipped with speed adjusting screws on the
remove and retain the jam nut and spacer
rear end cap, install new O-rings. Replace the
from both adjusting screws. Do not remove
spacers and jam nuts.
the adjusting screws. Remove and discard
the O-rings.
2. Install a new packing ring and O-ring and
attach the piston rod plate to the front end
cap with lock washers and screws.
©2008 Vapor Bus International, Buffalo Grove, IL. All International Rights Reserved.
This controlled document is subject to change.
3 of 4
Vapor Bus International is a registered trademark. U.S. and Foreign Patents are applicable and/or pending for the products described and illustrated herein.
Overhaul Procedure Bulletin # 0015
Pneumatic Cylinder Re-issued April 2008
3. Be sure the piston rod is free of nicks and 8. Re-attach accessory items and air lines to the
burrs. Slide the front end cap onto the rod cylinder.
and install the E-ring.
9. Re-install the cylinder in the bus and connect
4. For 57346755 type cylinder: Assemble the air and electrical lines.
new U-seal and O-ring on the piston, then
mount the piston and O-ring on the piston 10. Verify proper operation of the cylinder.
rod and secure with a new lock nut. See
photo 4A on page 2.
4 of 4
Vapor Bus International 1010 Johnson Drive Buffalo Grove, IL 60089 847-777-6400 Fax: 847-520-2222
Email: techsupport@vapordoors.com Web site: www.vapordoors.com