Benha Faculty of Engineering Strength & Testing of Materials
Mechanical Engineering Department 2nd Year Mechanical Engineering Dr. Abdalla M. Abdalla Sheet # 1
1) The load binder is used to support a load. If the
force applied to the handle is 50 lb, determine the tensions T1 and T2 in each end of the chain and then draw the shear and moment diagrams for the arm ABC.
5) The industrial robot is held in the stationary
position shown. Draw the shear and moment diagrams of the arm ABC if it is pin connected at A and connected to a hydraulic cylinder (two- 2) The engine crane is used to support the engine, force member) BD. Assume the arm and grip which has a weight of 1200 lb. Draw the shear have a uniform weight of 1.5 lb/in. and support and moment diagrams of the boom ABC when it the load of 40 lb at C. is in the horizontal position shown.
3) Draw the shear and moment diagrams for the
shaft. The bearings at A and D exert only vertical reaction on the shaft. The loading is 6) For the cantilever beam and loading shown, applied to the pulleys at B and C and E. derive equations for the shear force and the bending moment for any location in the beam (place the origin at point A).
4) Members ABC and BD of the counter chair are
rigidly connected at B and the smooth collar at 7) For the simply supported beam subjected to the D is allowed to move freely along the vertical loading, derive equations for the shear force and slot. Draw the shear and moment diagrams for the bending moment for any location in the member ABC. beam (place the origin at point A).