Professional Documents
Culture Documents
Gasification of Coal, Petrocoke and Biomass
Gasification of Coal, Petrocoke and Biomass
Lecture 3
Gasification of Coal,
Petrocoke And Biomass
Lecture 3
GASIFICATION OF COAL, PETROCOKE AND
BIOMASS
Gasification of coal, petrocoke, biomass and other carbonaceous materials to produce synthesis
gas has gained significant economic and environmental importance in the recent years. Although
the technology of gasification or partial oxidation of heavy feedstock is quite established for over
half century, however the technology of gasification has undergone continuous developments
over years to tackle higher ends of refinery bottoms, petrocoke, coal and biomass [Sukumar and
Nair, 2010]
Gasification of coal to produce coal gas goes to the end of 18th century when coal gas was used
for heating and lighting. History of gasification is given in Table M-II 3.1.However with the
availability of natural gas and petroleum products at cheaper rate the interest in coal gasification
dwindled. However due to increasing cost of oil and gas and the availability of petrocoke and
look for alternative feed stock for gasoline and petrochemical, interest was renewed in coal
gasification. Coal gasification is now used by surface and underground gasification. Gasification
of biomass is also getting interest during recent years because of availability of biomass in
abundance
India has estimated coal reserves of 253 billion tons and lignite around 28 billion tons and lignite
around 28 billion tons. Indian coal is mainly non-coking anthracite and bituminous in nature with
ash content of over 35percent. Gasification of coal offers as promising source of chemicals as
well liquid fuel. The gasification of coal involves the conversion of coal to high content gas (CO
and H2)
Gasification technology offers the cleanest and most efficient way to convert low and/or negative
value carbon based feed stock to syngas. Indian context of gasification is given in Table M-II
3.2. Synthetic gas can ultimately replace natural gas for Industrial uses, electrical power
generation and basic raw material to produce chemical and fuel oil. Commercial Success of
Gasification Technology will depend on the advancement of technologies such as:
Low cost oxygen production
Syngas cleanup
69
Cost effective separation of Hydrogen from C2
Gasification is the process of converting organic part of solid fuel to combustible gases of high
heat value by interaction with steam and oxygen. Gasification converts the low value fuel to high
heat value gas. Typical gasification flow diagram is shown in Figure M-II 3.1.
The feed for Gasification can be
Gas (e.g., Natural gas)
Liquid (e.g., Light or Heavy oils)
Solid (e.g., Petroleum Coke, Coal, Lignite or Biomass).
70
Figure M-II 3.1: Typical Flow Diagram of Gasification process and its
Products.
71
Feed Preparation: Wet feed system or dry feed system may be used in gasification. Wet feed
system employ grinding and slurring with water and pumping to gasifier while dry system
consist of grinding of the feed and employ lock hopers to pressurize the feed
Gasification: Gasification is carried out at temperature between 900-1100oC. carbon react with
oxygen and steam to raw synthesis gas( CO and H2) and some minor by products which is
removed to produce clean synthesis gas which can be used as fuel , for generation of steam and
electricity or may be used as chemical feed stock.
Syn gas cooling: High temperature syn gas produced from gasification is cooled
Air Separation Unit: The process produces oxygen for gasification. The process is based on
cryogenic separation of air. The process involves liquefaction of air and fractionation to get
oxygen, nitrogen and other gases.
Acid Gas Removal: This involves removal of impurities like H2S, COS, NH3 and HCN by
absorption using various commercial solvent like mono-ethanol amine (MEA), methyl diethanol
amine (MDEA), methanol rectisolvent and Selexol [Handa and ganesh, 2011]. The solvent is
regenerated by stripping the acid gases and recycle.
Slag Handling System: The gasifier may be either slagging or non slagging.
Gasification in Petroleum refinery [Handa and Ganesh,2011]: With increasing use of heavier
crude and processing of heavy residue has resulted in increased production of tar, petroccoke and
asphalt by various residues upgrading technologies processes like visbreaking, coking and
deasphalting. These residues can be gasified for production of hydrogen, syn. gas, electricity
ammonia and chemicals.. During recent years petrocoke gasification is getting interest by
petroleum refiners for production of syn. gas which can be further process to separate hydrogen
or can be used for production of useful chemicals.
72
Gasifier Configurations
Various types of gasifier used are mention in Table M-II 3.3 and shown in Figure M-II 3.2
below:
Table M-II 3.3: Various Type of Gasifier
Fixed bed Fixed bed involves an upward flow of reaction gas through a
relatively stationary bed of hot coal. The gas velocity is low.
Moving bed Moving bed gasifier operates counter currently where the coal
gasifier inter the gasifier at the top and moves downward and slowly
heated with the product gas. Gasification takes place in the
gasification zone.
Fluidised bed Fluidised bed operates at higher gas velocities than fixed bed
gasifier e.g.,
and uses smaller particle. The gasifier operates at atmospheric
Winkler/KBR/U-
GAS pressure and moderate and uniform temperature.
Entrained flow Entrained bed operates with parallel flows of reaction gas and
gasifier pulverized coal which minimize the reaction time and maximize
throughput of product.. The residence time is few seconds. Ash
is removed as molten slag
Source: Vorres, K.S. “Coal gasification” Encyclopedia of Chemical Technology vol 6,p.760
Gasification Reactions:
Cn H m n 2 O2 nCO m 2 H 2 1 n 4
Where for gas as pure methane m=4 and n=1 hence m/n=4
For oil m/n≈2 hence m=2, n=1
For coal m/n≈1 hence m=1,n=1
It is exothermic and produces a gas containing mainly CO and H2. The raw synthesis gas
contains small quantities of CO2, H2O and H2S and impurities, such as CH4, NH3, COS, HCN,
N2, Argon and ash, the quantities being determined by the composition of the feedstock, the
oxidant and actual gasification temperature (1300-1400oC). A small amount of unconverted
carbon is also present and ranges from 0.5 to 1.0 by percent wt in liquid feedstock or 50-200 ppm
73
wt in gaseous feedstock. The various reactions can be summarized as follows [Chemical Industry
Digest. Annual-January 2010, Page- 148]:
Combustion
C 1 2 O2 CO, H 111 MJ Kmol
CO 1 2 O2 CO2 , H 283 MJ Kmol
H 2 1 2 O2 H 2O, H 242 MJ Kmol
Boudourard Reaction
C CO2 2CO, H 172 MJ Kmol
Methanation Reactions
C 2 H 2 CH 4 , H 75 MJ Kmol
74
Figure M-II 3.2: Various Type of Gasifier Commonly Used
Source: Parthasarthi,2009
75
Figure M-II 3.3: Fluidised bed gasifier
Source: Parthasarthi,2009
76
KBR Transport Gasifier (TRIGTM) [Parthasarthi,2009}
Low rank, high-ash, high-moisture coal compatible
For power generation, air can be employed as the oxidant
Lower cost predicted
Higher availability predicted
Non-slagging, and refractory issues should therefore be minimal
Higher predicted efficiency
Lower emissions (due to higher efficiency)
Large scale up of the technology still required, by a factor of ~30
By 2010, this technology will be operating at the scale of E-Gas which has >20 years
experience already in 2007.
Lower temperatures and short gas residence time may lead to some methane formation,
which is detrimental in chemical applications.
Ash disposal problem if carbon conversion predictions are not met in commercial
apparatus.
Catalytic Coal Gasification – BluegasTM {Parthasarthi,2009}
Elimination of oxygen plant
For SNG objective, little or no catalytic methanation required
High thermodynamic efficiency potential
Catalyst cost and recoverability
Carbon conversion and methane production yields in the gasifier
Cost of applying the catalyst effectively to the coal
Inherently must be done in a fluidized bed which have not been scaled up to larger
capacities of entrained gasifier (yet)
Interactions of catalyst with coal ash
Separation costs of syngas and methane – cryogenic process
Excess steam requirements
Unsuitable for chemical synthesis processes due to CH4 reforming requirement.
77
Coal Gasification in fertilizer Industry: Coal gasification fro production of synthesis
gas and ammonia has being used many part of the world where large quantity of coal is present.
However, higher energy consumption in coal based ammonia plant has been major constrain.
Relative energy consumption per tonne of ammonia is given below [ Murthy and Patnaik, 2001].
Gas Naphtha Fuel oil Coal
1.1 1.15 1.45
There has been extensive research for improvement of coal gasification technology to improve
the efficiency and reduce the cost.
TM
Rapid Thermal Processing (RTP ) Process for Conversion of Biomass to
Liquid Fuels
TM
RTP is fully heat integrated technology that yields over 70percent liquid products from
typical biomass feed stocks. It is a fast thermal process where biomass is rapidly of heated in the
absence of oxygen. The biomass is vaporized and the vapour cooled to generate high yields of
pyrolysis oil. Typical yield of various biomass is given in Table M-II 3.4. Chemical and bio-
chemical conversion of biomass to biofuel is shown in Figure M-II 3.4 and Figure M-II 3.5
respectively.
Table M-II 3.4: Typical Yield of Various Biomass
Biomass Feed stock Typical Pyrolysis oil yield ,wt% of
dry feed stock70-75
Hardwood 70-80
Softwood 70-80
Hardwood bark 60-65
Soft wood bark 55-65
Corn fiber 65-75
Bagasse 70-75
Waste Paper 60-80
Source: Reno et al., 2011
78
Figure M-II 3.4: Chemical Conversion Route of Biomass to Biofuels
Ethanol
Fermentable Ferment
Butanol
Hydrol sugar ation
Hydrogen
ysis
Residue Bio-oil
Biomass
Anaerobic
digestion Biogas Purification SNG CH4
REFRENCES
1. Chemical Industry Digest. Annual-January 2010, p.148.
2. Chemielniak, T., Sciazko, M., “Co-gasification of biomass and coal for methanol synthesis”
Applied Energy Vol. 74,2003, p.393
3. Furimsky, E., “Gasification in Petroleum refinery of 21st century” Oil & Gas science and
Technology- Rev IFP, Vol. 54, No5, 1999, p.597
4. Hamelinck, C.N., Faaij A.P.C., “Outlook for Advance Biofuels”, Energy Policy. 34, 2006,
3268-3283.
79
5. Handa, S.K., Ganesh, C., “Gasification technology- status and challenges” Compendium of
16th refinery Technology meet on Feb 17-19,2011 held at Calcutta, Organised by Centre for
high Technology and Indian oil Corporation New Delhi
6. Murthy, G.G.K., Patnaik, L.N., “Coal gasification in fertliser industry-A future perspective”
Chemical weekly, June 2001,p.163
7. Parthasarthi Deb, “Clean coal technology Conference” 10th November 2009 PDU,
GandhiNagar, Gujarat
8. Reno, M.E., Streff, M., Hird, A, Ray, A. “Conversion of biomass to fuel as an environmental
impact reduction opportunity for the pulp and paper Industry” In paper International, April-
June 2011, p.18
9. Sawhney, P., Meeting of Indo-US working group on Coal April, 2008
10. Sukumarannair, M.P. “Harness gasification for integrated chemical complex” Chemical
Industry digest Annual-January 2010, p.144
11. Tirodkar, R.B., Belgaonkar, V.H., “Use of Chemicals derived from coal in surface coating
industry” Chemical Business April 20-May 4,1991, p.35
12. Vorres, K.S., “Coal gasification”, Encyclopedia of Chemical Technology, Vol. 6, p.760
80