Programmed by Wim Van Wassenhove, SE-Hyprotech – wimvw@se-hyprotech.
be
This extension calculates the GOR of a feed fluid
It can also modify the composition of the stream to obtain a different GOR. The method used is as follows: Take the vapour and liquid from the feed stream Change the amount of vapour and reflash at the feed stream conditions until the required GOR is obtained Change the total flow rate to maintain the selected feed quantity
The following options are available:
Reference flow phase: determines what flow rate is kept constant Basis: determines whether the reference flow is kept constant in mass, mole or volume GOR calculation conditions: determines if the volumes used to calculate the GOR are at the process conditions or at standard conditions. The flash is always done at the feed conditions. The outlet conditions (temperature, pressure) are per default the feed conditions, but they can be modified to be different conditions.
One can either use GOR or GLR (GLR includes the water phase)
Use the ignore checkbox to set a new GOR or to set custom outlet conditions.